COMPLIANCE INFO_PRE 2019 - Laserfiche WebLink

Home Browse Search

SAN JOAQUIN COUNTY ENVIRONMENTAL HEALTH DEPARTMENT 600 East Main Street, Stockton, California 95202-3029 Telephone: (209) 468-3420 Fax: (209) 468-3433 Web: www.siaov.ora/ehd ABOVEGROUND PETROLEUM STORAGE ACT (APSA) PROGRAM INSPECTION REPORT CONTINUED actity IF Name West Valley Chevron Facility 2615 West Grant Line Rd Inspection Mar 28, 2011 Address: Date. VIOLATIONS # VCode Section HSC = CA Health and SafetyCode; CFR = Code of Federal Regulations; V = Violation; RV = Repeat violation Specific requirements of HSC 25270.4.5(a) are identified as CFR code sections beginning with 112 Failed to: test each aboveground container for integrity on a regular schedule or when repairs were made; 48 CFR 112.8(c)(6) inspect containers and container supports; or keep records of inspections and tests, or provide equivalence as allowed by CFR 112.7(a)(2) 49 CFR 112.8(c)(7) Failed to provide effective leakage control through defective internal heating coils, or provide equivalence as allowed by CFR 112.7(a)(2) 50 CFR 112.8(c)(8) Failed to install and regularly test approved liquid level sensing devices, or provide equivalence as allowed by CFR 112.7(a) 2 51 CFR 112.8(c)(9) Failed to observe effluent treatment facility frequently enough to detect system upsets that could cause a discharge, or provide equivalence as allowed by CFR 11 2.7 a 2 52 CFR 112.8(c)(10) Failed to promptly correct visible discharges and/or remove accumulations of oil in diked areas, or provide equivalence as allowed by CFR 112.7(a)(2) 53 CFR 112.8(c)(11) Failed to locate portable containers to prevent discharge or provide sufficient secondary containment capacity that will hold the volume of the largest container plus sufficient freeboard to contain precipitation Failed to provide buried piping with a protective wrapping and coating and cathodic protection and/or 54 CFR 112.8(d)(1) inspect buried piping for corrosion damage when exposed, or provide equivalence as allowed by CFR 112.7(a)(2) 55 CFR 112.8(d)(2) Failed to cap or blank -flange terminal connection at transfer point and mark its origin when piping is not in service or in standby service for an extended time, or provide equivalence as allowed by CFR 112.7(a)(2) 56 CFR 112.8(d)(3) Failed to design pipe supports to minimize abrasion and corrosion and to allow for expansion and contraction, or provide equivalence as allowed by CFR 112.7 a 2 57 CFR 112.8(d)(4) Failed to regularly inspect aboveground valves, piping, and appurtenances, or provide equivalence as allowed by CFR 112.7(a)(2) 58 CFR 112.8(d)(4) Failed to conduct integrity and leak test for buried piping at time of installation, modification, construction, relocation, or replacement, or provide equivalence as allowed by CFR 11 2.7 a 2 59 CFR 112.8(d)(5) Failed to provide adequate warnings to vehicles entering facility to protect aboveground piping and other oil transfer operations, or provide equivalence as allowed by CFR 112.7(a)(2) 999 Other: See attached "Continuation - Official Inspection Report" for violation(s) not listed above. Routine Aboveground Petroleum Storage Act inspection report 1, 13. Facility has an APSA regulated shell capacity of 1860 gallons. No Spill Prevention & Countermeasure Control (SPCC) Plan was available on site. All facilities which have an APSA regulated shell capacity of 1,320 gallons or greater shall prepare a written SPCC Plan which meets all of the requirements of the Code of Federal Regulations, Part 112. This facility qualifies as a Tier I facility which has no aboveground oil storage container with capacity >5,000 gallons. Immediately prepare a SPCC Plan in accordance with CFR Part 112, which will include all aboveground petroleum storage containers 55 gallons or larger. Submit a copy of self -certified SPCC Plan to the EHD for review by 04/28/11 . A template for Tier I can be found on SJC EHD website under the program Aboveground Petroleum Storage Act. (This copy will be returned to the facility after review.) A copy shall be maintained on site at all times. Submit to SJC EHD within 30 days (04/28/11)- 1. one copy of the completed "Return to Compliance Certification" form 2. a written corrective action statement for the above violations ALL EHD STAFF TIME ASSOCIATED WITH FAILING TO COMPLY BY THE ABOVE NOTED DATES WILL BE BILLED AT THE CURRENT HOURLY RATE. THIS FACILITY IS SUBJECT TO REINSPECTION AT ANY TIME AT EHD'S CURRENT HOURLY RATE. Insp r Phone: (209) 468-8257 Received By: Title: EHD 28-02 Rev \ / /19/ 0 Page 3 APSA INSPECTION REPORT