|
Ar
<br /> r r ARB Approved IOM-Heats Phase O EVH system-VR-2W-A(CA$-&9611 `' ,. Pros 18
<br /> INSTALLATION INSTRUCTIONS for Ed&��0
<br /> HEALY SYSTEMS,INC.
<br /> CLEAN AIR SEPARATOR
<br /> 7-1289Ri,INC.
<br /> no Model 9942,fiea€y systems Clean Air Separator htstallalon camists or 9 406 gallon sleet tank CrIffmc6 C'WW
<br /> easembty(9961)that contains a tuet reaislani bladder to contain excess gasoline vapors that may W?271t N.He81M
<br /> develop in gasoline storage tanla during idle periods of gasoline dispansing Facility operation. The DA;AAS,1%75284
<br /> - tank eas rANy weighs approximately 80o pounds whkh makes It neceeaery to have a Power
<br /> 21Ana1.67a1
<br /> sTAI's- assisted 9ftrg device available at the irwislatlon site to remove the tank from the transportation
<br /> I sportati in
<br /> vehicle and place k on the required concrete pad(see drawing L3990g-g9d5). The pe
<br /> mit lf8'lloop Is located within too feel to the storage lank vent lines. Site pad is a fe'quiroment of this
<br /> California State Fire Marshal NOTICE;
<br /> DO NOT PLACE THE TANK DIRECTLY ON THE GROUND OR ASPHALT SURFACE.
<br /> CODE INTERPRETATION NOTICE: The Installer is responsible to ensure that the€nstaAation meets the fatest edition
<br /> requirements of NFPA 30A. Chapter 16. No elearMal connections are required. The tank
<br /> socuremenk method shown In drawing 1399DD41C 45 strait be approved by the local authority having
<br /> Date leaved' duly 27,2007 66-124 jurisdktlon whh reaped to wind and seismic loading.
<br /> Topic Healy Clean Alr�,�.-Or�(CA�)la`Vapor fi addition to the tank,lettere lsa hardware ld1 that cokatalns the following:
<br /> Process) Dnir tl
<br /> Code Sectlon(g) CFC 5202.13.3.9 t prosaurefVacuum venlvatve(see rxhlblt l of VR-201-A formodel number)
<br /> Requested by Don Foster 4 Loddng 1"NPT Bail Valves
<br /> Getiier-Ryan[no. 4 Pad locks(keyed afike)
<br /> 1364 N-McDowell Blvd,Suite B2 1 Breather Assembly,Healy lyinda19948
<br /> Petaluma,CA 95954 f Vapor Intel Assembly,Healy Model 9956 9
<br /> 1 Float Check Valve Assembly,Model 9466G .a
<br /> The Callfomfa Mto Flm Marshal has accepted the EX eartf&2VOn Of the Referanca the appropriate Henry systems Installation drawing(C9900-9042,09900.9977,C9HIX1 F
<br /> treaty Crean Air3epamfor(CAS)Tank as e"Vapnrproceseing Unff". 2001 9972 or C9gg0.e973 of this manual) for placement of the above pads for the vent atadr
<br /> CFC section 6202.73.3.6 Indicates that rhe ven(tormkaatlon"An vapor configuration required by the local Authority Haying Jurisdiction(AHd)for the UST system. The
<br /> iumcassmg unfts51011 ba nol iess man B Peet above the processing unTf local contractor is responsible fo provide all necessary,galvanized piping,norhbmdenfng,Ut.
<br /> Itself. dasamw pipe joint compound and plumbing hHings.Addlllonal PressweNecuum(PN)vent valves
<br /> to complete installation are not included in the hardware kill. Healy is not responsibts for the
<br /> AN of the HAS&Wfalk1flOn mafwfars andthe California Afr-Rdsourees warranty of any other PN vent valve purchased to complete installation. W
<br /> Board Exacutrye order VR.202,A exhlbhs fndkafs that the umdetgrcundW
<br /> storage tank ptessurd vacuum vent valve temrhpffon need only be located The lank arrives at the site assembled and tested.All plumbing should be done using I'galvanized
<br /> 12 feel shove grade Na relerartce is rnedeto gm B fiat aeparad0n steel pipe(Schedule 40)and approved nipples,as called out In the 61slellation drawing appropriate
<br /> requirement for the s4e Inslalkation. Movntlng hatdware should be galvanized or stainless steel. careful Q o
<br /> attention must be paid to the installation drawing appropriate for the site installation assure proper R N
<br /> We have two Questfonsfor your conakfelaffohand lnterpretegon: operationofihebladdersyem. Dorwtinflatethebladderassembly after€nsla8etion. pq0)U
<br /> 1.Does the UST poessure vacuum vent valve freed to hefocafod6 feel His Imponantiltat the tank be seared to the concrete pad atabown in drawing 89900-9945 of this
<br /> above the CAS Tank as lndicateal an the atlachedDetelr T7 manual in prevenlany uamtentional repositioning of the tank as the connecting plumbing to the vent �n v 7,a
<br /> syslam is accomplished. Q p-,
<br /> NWho o.The design heCAS Tssuch that cop vapors from the UST are completely y,��
<br /> hopped wilhtn the'bladdef'contained In the CAS-The vent coming from the Weay Vkbake:NrpvMwe.healysyslerramm fit
<br /> CAS is to vena the interstitial apace between the bladder and the outside well of 1e Harrysla'm Ixa,a Email:aataaW4gflamoom Lr
<br /> the CAS.(See footnotebsi0w) y;nasmrdawita,r,pslsreoan5lIAEA TeephF-603022472 1�-
<br /> ARB Appwbd t taaatimt Op—nan and Valrft,onca M.—I(Assn 8,2005) Fax 6o3.Ee2fi199 z
<br /> L�
<br /> r4 11
<br /> 02 U
<br /> co Hm'1'.51'�anq rx-Vs kr,o:aSva le%derdSf-gre11 v�arrFOPIfl/YeY'+R° r�
<br /> r W
<br /> w
<br /> x
<br /> ABBAppraved fort-Heafypfass 11 FvR 6)slcm-1R-20t-A(CAS-9961} Page 17
<br /> OPERATION AND PURGING
<br /> s - NORMAL OPERATION:
<br /> 1 VAPORRECOVERV
<br /> 2.is the treaty GAS AtrBreathar Assembly conalderedan rmdergmund ❑ There are foot bail valves on the Sank In normal aperak[en,only the valve a!the Lop of the 2008
<br /> tank ventln the eonraxt of NECArflcfe 614,Group A bh4ston 1 Slid 2 tank shad p open-the other plrss should bvalves e installed using ll be closed- latnon-he our valves
<br /> classified
<br /> Hazardous Lacatfons7 Ina above compound
<br /> n d The two plug
<br /> ® pupa joint compound and lighlenetl 10 80 fiche.
<br /> As described In the above,the UST Is'vrented'to the bladder contained Wthln pitklNlNG THE BLADDER:uestlxr the CAS and by design,no vapors are created to atmosphere.(See footnote
<br /> y below)
<br /> Fress,reiv.wxn— A o An Inspection Who need to dra[a the bladder is easily made by contal ng the plug a tee
<br /> averts verdVeke The Intent of Gas tootnote is for reference only and to provtde elann°aaon.kis on the botem plumbing of the lank-be sure to have a metal collfaknar available to catch
<br /> Ealsaawd Vesper Re""My� m of tae elate Fkastafsbel m endorsoanyone specific product,devkaof fluid.Wdh the plug re
<br /> end the container lei plain,carefully open the 6971 valve shove
<br /> allrndalagy Ina tee to release any liquid. Any liquid Comin
<br /> mg over from the vent system would have
<br /> Mscapuenor opemgonafthe H�ly(uean Alfacymator"': collected above the valve In the riser pipe before going into the bladder. If-„ llquld In excess of
<br /> Ina Mary S�rsirrrs.Int.,rAo W*61 Healy 0—ArSepa,alar"'9aslandefare, Violas 16 ounces drains out,the bladder Should also be drained. Use 0aufien as the storage tanks
<br /> nreamwidevice uaL a"16&In aonuanirg tits gaeal9,a+apof errissfaiandm a gawme sora be pressurized.
<br /> 65psrrskg to lly.ttc°rsistsda4oajldl9d slam vasal wkhfrdegal ttadderand assocoted
<br /> vaMrg I[Is rronnarmdro ecoU eMea of me GOF stdage larks va"wr"V Wales Of We
<br /> W" -ander Vrnxd storage rassYs.Iaahg msrnal operalror,dtl,e(#]F,wti,todryk rpnced,alran pF u Should ft be neceesary to drain the bladder.
<br /> ORVRveh,Ges a➢padrmting lost,the eroragetarA Utage space Yla usuayeperate lnthe-W 1. Close lire upper ball valve(usually open)leading to the tank vent lines.
<br /> o — ter,e�lke PV to B'Vut:fly ctackk9 pe�,re)peseum -[krig'dosed'pe+k,da of the 2- Open the valve that goes to the vertical riser that enters lha top Of the lauyt(the one
<br /> ooh,lnaHasaxessUrewuvwao-rlg mi,a�seaerovapava*a,nheantmtl�
<br /> YPIDWVaaum M7+ porEssdfroah,drBavlrAoar lASTa.ttUe pressvm goesssgtAyhen OR
<br /> Rraimlhthe connect
<br /> the bag valve going tato the tank). Be sum flue other tires ball valves that
<br /> vapor ram Bre usrama acv irW a,a lnlemal Gadder-camersety,when o1xVR reluepn9 tefp+s canned is the vent GrheS and flank are Closed-
<br /> aeanAt and rte il3r pmsslaofalls belnv amnspliedy the vapor vlenvl tosheuedderwdl be down 3. Remove the plug from the bottom tee and conned an explosion proof evacuation
<br /> tepaata nackfntouatrsiv,mrhatda�iaraturtcafapsedwatn9farslunaawde. pump capable of herding liquid, Have a liquid tight,metal container to receive any
<br /> The Clean Alr Separatar�n Duet rum anaene haY yeah fYxlalled tete Septeriabafet&y t.or Auld that may exit the system"Start the pump. I!no hquidreturnwithin 3o seconds,
<br /> be3nghaperatlonal ov C.AR&rest saeln Seuercdrdaras lxenevak,flld rcpeeteRy to Bees line bladder is dry-discontinua pumping,remova the pump,replace the plug and
<br /> °40`djg pne�erl Todateu—baat�enIqUd lin w� av return the ball valves fo their original,locked,positions.
<br /> DRAINING THE TANK
<br /> asst ctaen Ars sepaaeer{calldrain
<br /> i# 4t17.—
<br /> u should fi be necessary to drslnfha tank(batmen(he bladder and steel walk: stops No-
<br /> 7heH,<AYalean Ak sepasta Pe'+ Se`®1 e1 e+dp°a,d•lawe'! 1. Close the ball valve at the lop otihe tank and also the twovalves on the vertical deers. 7g1tA1r3 41111 L
<br /> r uofinggawlm,taag t"Iuewsa.th°'nR—k,hambneawt 2, Remove the plug In the bottom tee and place a metal container below the plea Dun 8r_
<br /> wkh HmyUnugvoiypeno 1 asPatteiasydem Nat kx4t—waren opening.
<br /> para cow aaeAndmq. 3. Careful) open 0.881dIT,
<br /> D. Y Pa mLtix>rr:
<br /> alaah aarw,a a,rat��aaa lo ger c mesfr into does not Overflow theVal-empty-container as required until 9uld no k s�6
<br /> longer comesfrom the pipe when the valve Is spars. APl's0989 eY
<br /> allo n,ndraicarnw'!q» 4. Close The bag valve and replace the plug into the tee.
<br /> sno.krtddaa,a,sala,nrasded S. Return all ball valves to their oNklatloettedPositions. z/25109
<br /> 9di8 1440191:
<br /> •Lbw-Ay
<br /> wc_tm ucr.ne,w,eo
<br /> swurtvxcaspar>ne vn.mr ussvlmvo S�19091 uFF `k'r
<br /> Website:rilPfl w.hestyaf0 sr a
<br /> 0 Hanpslvre Drive Email salesysYSMmsoan c v�y3A a 13
<br /> Hud—efst�M,Nawl+offWke 0.1451 USA lcis ne:03582-2472
<br /> Apr Afv vad insbiblion Operation aril Maifeamme Marxrai(Api18,2005) Faxao18876189 a
<br /> ®
<br /> twn
<br /> r,14a0 etmk 9
<br /> sw1]aTlmffil
<br /> FOR REFERENCE ONLY FOR REFERENCE ONLY FOR REFERENCE ONLY
<br /> G9.3H
<br /> ENHANCED VAPOR RECOVERY SCHEMATIC
<br /> CALIFORNIA STATE FIRE MARSHAL NOTICE HEALY SYSTEM INSTALLATION INSTRUCTIONS
<br />
|