INSTALL_2003 FILL SUMP PLAN - Laserfiche WebLink

Home Browse Search

NOTES: ELECTRONIC MONITORING SYSTEMS (PER "APPROVED MATERIALS LIST") PROVIDES ADVANCED AUTOMATIC CONTROL OF UNDERGROUND TANK AND PIPING INS'T'ALLATIONS. _ ' USE SENSOR DETAIL FOR TURBINE AND FILL SUMP EACH MONITORING SYSTEM CAN BE CONFIGURED TO PROVIDE SIMULTANEOUS REAL EXPLOSION PROOF JUNCTION BOX TIME SURVEILLANCE OF SEVERAL DIFFERENT INSTALLATION PARAMETERS WITH AUTOMATIC ALARM NOTIFICATION AND AUTOMATIC SHUTDOWN OF SELECTED COMPONENTS I ADJUSTABLE /f IN THE ADVENT OF DEVIATIONS FROM INTENDED OPERATIONS, SENSOR DESCRIPTIONS ` LEADER CABLE NONCORROSIVE AND CLASSIFICATIONS ARE NOTED BELOW. RISER VENT SENSOR CABLE (SEE NOTE CABLE GRIP Si CONTINUOUS MONITORING OF PRESSURIZED PRODUCT PIPING TO TEST, ALARM, RISER AND SHUT DOWN TURBINE IF LEAK OCCURS. SENSOR IS MANDATORY. -'-'� PIPE CBPP 52 CONTINUOUS MONITORING OF SECONDARY CONTAINMENT PIPING AND TURBINE I SENSOR SUMP FOR INTRUSION OF ANY LIQUID. SENSOR IS TO BE INSTALLED SUCH I r SMFGREMS THAT ANY ALARM WILL SHUT DOWN TURBINE IF FUEL IS DETECTED. SENSOR I—t IS MANDATORY. CONTINUOUS SIMULTANEOUS MONITORING OF TANK INNER AND OUTER WALLS BY HYDROSTATIC MEANS. IF INTERSTITIAL LIQUID (WATER OR SALT BRINE) L�11P RISER SEAL OFF I / I \ LEVEL GOES UP OR DOWN BEYOND LIMITS, SENSOR WILL ALARM BUT SHUT PIPENOTHING DOWN AS SUCH ACTION WILL NOT ARREST THE PROBLEM. HOWEVER, PITTINGPE rj / \ INTERSTITIAL LIQUID WILL NOT PERMIT PRODUCT TO ESCAPE DUE TO HIGHER I LIQUID DENSITY AND HIGHER HYDROSTATIC HEAD REGARDLESS OF INVENTORY J I LEVEL. SENSOR IS MANDATORY FOR SUCH TANKS. L 1 �0 I I CONTINUOUS MONITORING OF TANK RISER INTEFISTII, IF RISERS ARE CONTAINED. INTRINSICALLY HREADEDY , SENSOR WILL AUTOMATICALLY ALARM IF ANY LIQUID INTRUDES INTO IN7ERSTII SAFE SENSOR \ ADJUSTABLE CONDUIT TO LEAK I BUT WILL SHUT NOTHING DOWN AS SUCH WILL NOT ARREST THE PROBLEM. 53 LEAD CABLE DETECTION PANELI �^ TANK SENSOR IS OPTIONAL. HOWEVER, IF RISERS ARE CONTAINED, SENSOR CONDUITS IN BLDG. MUST ALSO BE INSTALLED FOR POSSIBLE FUTURE USE, SINCE CONDUITS ARE PART OF SAID CONTAINMENT, SAID CONDUITS MUST PASS BOTH N.E.C. CONTINUITY NOTE: ` TEST AND PRESSURIZED LEAK TEST. INSTALL 1!4 POLYFLOW TUBE TO GRADE S SLEAVE IF GROUND WATER MAY EXCEED RISER HEIGHT (SMITH OR 2"0 FIBERGLAAMSRON PIPE) CONTAINMENT SUMP IF THESE RISERS ARE CONTAINED IN A SUMP, SUBSTITUTE AN S2 TYPE TO BE ATTACHED TO SIDE I I I SENSOR AND WIRE IT TO ALARM, THIS WILL SHUT DOWN NOTHING. OF SUMP USING METHACRYLATE �_ --} ADHESIVE f' S5 CONTINUOUS PRODUCT INVENTORY LEVEL MONITORING, CAN BE PROGRAMMED RISER PIPE CAP � JUNCTION I I I \ S2 EXPLOSION-PROOF JUNCTION BOX f0 PROVIDE LOW INVENTORY LEVEL WARNING, HIGH INVENTORY LEVEL ALARM, WATER WARNING, AND AUTOMATIC TANK LEAK TEST TO .01 GPH ACCURACY PER AND FITTINGS Box SUMP WAt.L USEPA PROTOGOL. SENSOR IS OPTIONAL BUT CONDUITS FOR SENSOR MUST 2"THREADED_,,-" TO BLDG 52 BE INSTALLED AND MUST PASS BOTH AN N.E.C. CONTINUITY TEST AND A PVC OR ABS ` PRESSURIZED LEAK TEST. PIPE RISER INTRINSICALLY I I I SAFE SENSOR SENSOR AND 2 CONTINUOUS MONITORING OF DISPENSER SECONDARY CONTAINMENT'SPACE FOR FIBERGLASS SLEAVE To INTRUSION BY ANY LIQUID. SENSOR WILL AUTOMATICALLY ALARM AND SHUT DOWN BE PLACEG ON SIDE JFSENSOR ROM OTO BE 11 OT(MAXIMUM) OF SUMP MPETHAT 0 CT U SUMP OFFENDING DISPENSER (NO ELECTRICAL POWER TO SAID DISPENSER) SHOULD WALL, SENSOR TE BE ANY FUEL BE DETECTED. SENSOR IS MANDATORY. RISER PIPE PLACED 1/2' (MAXIMUM) A ADDITIONAL. SENSORS CAN BE UTILIZED, BUT MUST FIRST BE APPROVED BY RESERVOIR FROM LOW:--ST POINT IN 1 A A HEAD OFFICE MARKETING ENGINEERING STAFF UNLESS GENERAL SPECIFICATIONS FRP RESERVOIR SENSOR THE SUMP. S3 SECTION A—A OR "APPROVED MATERIALS LIST" IS REVISED TO SHOW APPROVALS OF SAME IN. LIQUID MONITORING FLUID THE FUTURE. NOTE FOR ELECTRICIANS: ALL SENSITIVE CIRCUITS (SENSORS, DATA, ETC) ` SHALL BE ROUTED IN METALLIC CONDUIT AROUND (NOT THROUGH) WIRE TROUGH IN BUILDINGS. FAILURE TO COMPLY MAY CAUSE SYSTEMS TO PICK UP DOUBLE WALL FIBERGLASS TANK INDUCTIVE NOISE THAT DISRUPTS INTENDED OPERATION OF SENSITIVE DEVICES, S3 SEE E0103120 a" corfc NON—MANDATORY _ __ 12 UNIVERSAL 6 SLAB LOCKING,ACCESS R -� OBSERVATION NIECES - TIGHT ACCESS 80X.. PVC RISER PIPE SEE R- `• " o :'.','.'r'.,�. =SrHOWNSFLOW. 'lll= E01031200 I = UNPERFORATED r HOLE CASING 24 MOUtI DEEP. c 1_i ?� N� LO 12" NITRILE KEYCK S3 II - �EAGRAVEL FIL-SEAL-PAK JOINT (TY P) I BACKFILL: LINER WITH SOME STATES HAVE PERMIT REQUIREMENTS FOR WELLS. IT WILL BE THE ,.��' STAINLESS { - BAND CLMf PS. INSTALLING CONTRACrOR'S RESPONSIBILITY TO KNOW SAID CODE REQUIREMENTS AND TO OBTAIN REQUISITE PERMITS, PRIOR HEAD OFFICE I I j j 4" SCHED 40 PVC COMPANY ENGINEERING APPROVAL IS REQUIRED FOR ANY SIGNIFICANT I I - WELL CASING WITH TANKS DEVIATIONS FROM ABOVE. IF LOCAL CODES 00 NOT REQUIRE WELLS BUT DO BOTTOM OF TANK CONTINUOUS .020" REQUIRE REGULAR MONITORING IF INSTALLED, DO NOT INSTALL UNNECESSARY HOLE EXCAVATION, OBSERVATION WELLS. I = MACHINED SLOTS &THREADED LOCAL JURISDICTIONS MAY HAVE THEIR OWN REQUIREMENTS. IF THIS IS THE ( \ (NO LUED IONS JOINTS) CASE, CONTACT THE LOCAL ALLIANCE COMPANY ENVIRONMENTAL ENGINEER. I u d 12" MIN. WELL (TYP) TYPIGAL� T i(i,.1T1 TYPICAL DOUBLEWALL FIBERGLASS TANK /v� _ �� — TANK SLAB THREADED PVC CAP OR FERNCO QUIK-CAP. �REFERENCE Difi GS - E01031S00; E01032700 APPROVALS These drawings and specifications are the confidential and Shell Oil Products Uri 0 0 0 CALIFORNIA U .S.T. STANDARDS proprietary property of Sheli 011 Products US and shall not be — DISTRICT MANAGER i copied,, reproduced, disclosed, or used without Shell 011 ADRY D O U [ LEVVALL TANK/PIPING Products US written authorization. They are Intended as 3 04/12/02 ADD NEW DETAILS (2) ❑ contract documents for use on this specific project In p� AREA TECHNICAL MANAGER _ conjunction with its Issue date and are not suitable for use on 2 02/14/02 ADD NONMANDATORY OBSERVATION WELL ADPY ®tiva Enterprises LLC GRAPHIC SCALE ELECTRONIC MONITORING DETAILS a different project or at a later date. __ DIAGRAM FROM "DELETED DWG. E01031800" —__ TERMINAL MANAGER _� 1 — 2/11 /02 CLARIFICATION / CHANGES ADRY 12700 Northborough Drive m SCALE: SAP/WIC DATE: DRAV�N: REQUESTED DY: © Shell Oli Products US, All Rights Reserved 2002 REV DATE DESCRIPTION OF REVISION BY APP Houston TX 77067-2508 ENGINEER NONE 800062 03 MAY 2002 RABAGO HOVLAND E01031 4.00