|
Wiring Legend
<br />I 4
<br />�. t3 HOT'
<br />I fy 1 NEUTRAL---------'---
<br />r� GROUND ....."..............."..... ......"..
<br />4, Tokheim Model 168/268
<br />SEE NOTE 6
<br />1� Emergency Emergency °
<br />` t Cut -0 f Cu -Off Relay
<br />Switch kNC) °
<br />I aCOIL
<br />a
<br />---
<br />F-- C NG C
<br />t r -
<br />;E
<br />? I IC I I
<br />III
<br />3/4"c, 2,12 I I I
<br />TNONOOSEE NOTE 4
<br />4 I I I
<br />II
<br />3/4"C,
<br />I' 8,12
<br />IL-------^-----
<br />--- - - - --- ------
<br />♦- - - -- --------------------------------------
<br />L
<br />------------------ -
<br />I.::.....:.....1....................................................................................................
<br />SEE NOTE 5
<br />SIZE AS
<br />II ( I REQUIRED
<br />I� q. N B 3/4%, 2,12
<br />1 3/4"C, 2,12
<br />3/4'C, 2,12
<br />Panel 'A'
<br />#)i 3/4"C, 2,12
<br />ff I Sheet Notes
<br />1 TOkHEIM-_
<br />1'. .'STAND ALONE INSTALLATIONS DO NOT REQUIRE, MODELS 67/67A
<br />'AND 68. SEE NOTE 6 FOR REMOTE CONTROL INSTALLATION.
<br />2. 'A SEPARATE CONDUIT IS RECOMMENDED FOR DC AND AC WIRING
<br />FOR EACH DISPENSER TO PREVENT INDUCTIVE INTERFERENCE FOR
<br />DISPENSERS. A SINGLE CONDUIT MAY BE USED, BUT IT MUST
<br />BE CONNECTED TO BOTH CONNECTION BOXES IN DISPENSER.
<br />` 3. "CAUTION:
<br />.120VAC WIRING MUST NOT BE CONNECTED TO LOW VOLTAGE
<br />CONNECTIONS. DAMAGE FROM MISWIRING IS NOT COVERED BY
<br />" WARRANTY.
<br />4, MAXIMUM 20 AMP 2 -POLE, CIRCUIT BREAKER FOR 240 VAC, 1-1/2 HP
<br />MOTOR IN PANEL 'A'.
<br />5. DISTRIBUTION PANEL MASTER DISPENSER CIRCUIT BREAKER TO BE
<br />MAXIMUM 50 AMP. ALSO, IT IS RECOMMENDED THAT A SEPARATE
<br />CIRCUIT BREAKER BE INSTALLED IN EACH CIRCUIT BETWEEN
<br />,MODEL 67/67A (WHEN USED) AND EACH DISPENSER. FOR
<br />CALCULATING TO AL'LOAD, AND DISPENSER LOAD, SEE MAXIMUM
<br />AMP RATING ON INSIDE OF DISPENSER DOOR BY AC CONNECTION
<br />6. REMOTE CONTROL ONLY
<br />.RELAYS USED IN MODEL 68 RELAY CONTROL BOX HAVE A CONTACT
<br />RATING OF 1-1/2 HP. 0 240 VAC. IF A MODEL 68 RELAY CONTROL
<br />BOX 15 NOT USED, A MOTOR RELAY MUST BE USED HAVING A COIL
<br />.'RATING OF 1/2 AMP MAXIMUM 0 120 VAC. AND A CONTACT
<br />'RATING OF 1-1/2 HP. 0 240 VAC.
<br />s' 7. REMOTE CONTROL ONLY
<br />71 MAXIMUM. OF (3) DISPENSER MOTOR CONTROL CONDUCTORS
<br />RECOMMENDED PPOR EACH PRODUCT TERMINAL BLOCK LOCATION,
<br />' 8, ALL U.G. CONDUIT INCLUDING FITTINGS SHALL BE RIGID GALVANIZED
<br />STEEL (RGS) WITH A BONDED .040' MIN. PVC JACKET.
<br />RONAN
<br />9. ;-WARNING - THIS IS INTRINSICALLY SAFE WIRING AND MUST BE SEPARATED
<br />FROM ALL OTHER WIRING AND INSTALL IN CONDUIT. MAXIMUM CABLE
<br />! LENGTH BETWEEN MONITOR AND SENSORS IS 1,165 FEET,
<br />I; 10, THIS WIRING MUST BESEPARATEDFROM ALL OTHER WIRING AND
<br />' - INSTALLED IN CONDUIT.
<br />;(
<br />1L WARNING TO MAINTAIN INTRINSIC SAFETY, THIS WIRING MUST BE
<br />' SEPARATED FROM ALL OTHER WIRING AND INSTALL IN CONDUIT.
<br />t'lr 12 WARNING - TO MAINTAIN INTRINSIC SAFETY, THE JUNCTION BOX MUST
<br />f1 CONTAIN ONLY WIRE SPLICES. -
<br />'.
<br />13, SPECIAL NOTE - IT IS THE INTENT OF THIS DESIGN THAT MANY FAILURE
<br />, y' .OF THE LEAK DETECTION SYSTEM, THAT ALL POWER TO THE PRODUCT
<br />PUMPS WILL. BE INTERRUPTED.
<br />W
<br />$ i ,•
<br />f Ser f'$i� 1ji i".
<br />f' 3
<br />Control Box
<br />.
<br />O
<br />OOOO
<br />C
<br />NC
<br />3NC.
<br />NO
<br />Q►�
<br />NO
<br />000►�OOQ
<br />a
<br />a
<br />214C
<br />>
<br />000
<br />J
<br />m
<br />O�
<br />5
<br />►
<br />v�v�
<br />M
<br />:�
<br />1�•0aa®0®e®©�oeoa©0®�®•.
<br />I
<br />I
<br />I
<br />I
<br />I
<br />I 3/4"C, 8,12
<br />SEE N07E 7
<br />I
<br />3/4"C, 13,12
<br />I
<br />I
<br />I
<br />AC Wirewav
<br />y
<br />Pumps
<br />nO
<br />3/4"C, 2#12
<br />::quj#10
<br />3/4"C, 2,12
<br />u #2 0
<br />WHEN REQUIRED ONLY
<br />r- 3/4"C, 2,12 SEE SPECIAL N07E ,1
<br />FOR DUAL SINGLE
<br />�
<br />PRODUCT DISPENSERS
<br />I \ S / O
<br />39
<br />Tokheim Model 67/67A Interface Box
<br />A COMBINATION FO
<br />ACH AND ACC USING
<br />TWO (2) EMERGENCY
<br />STOP RELAY CONTACTS
<br />WILL BE CONSIDERED
<br />AS ONE (1) CONTACT
<br />HAVING A MAX RATING
<br />OF 25 AMPS
<br />EMERGENCY RELAY ---------\
<br />MAX 25 AMPS
<br />PER CONTACT
<br />N. C.
<br />COMMON
<br />SIDE VIEW OF EMERGENCY
<br />STOP RELAY ILLUSTRATING
<br />3/4'C, 2,12 CONTACT LOCATIONS
<br />TYP 4 PLACES
<br />3/4'C, 9#12-
<br />I � I
<br />I i i I
<br />-----------------------------------------------------------------J---J
<br />Ronan
<br />Series X76S
<br />Leak Detection Monitor
<br />38 F
<br />JUMPER USED TO MONITOR
<br />SIPHONED UNLEADED TANK
<br />WHEN WASTE OIL TANK
<br />NOT USED
<br />INTRINSICALLY
<br />SAFE INPUTS
<br />(SEE NOTE ,12)
<br />KV -700 -NO -24
<br />44 AUX. NO. 4 RELAY
<br />0
<br />SUPREME UNL./ X1 V+
<br />X2 Al
<br />EC -PREM.
<br />aKV-700-NO-24
<br />q2 AUX. NO, 3 RELAY
<br />.1
<br />KV -700 -NO -24
<br />42 AUX. N0, 2 RELAY
<br />UNLEADED +,2 X1 V+
<br />(WHEN REO -D) XZ Al
<br />3/4"C, 4((14 -
<br />(SEE NOTE ,10)
<br />7
<br />3
<br />3/4"C, 2,12 &
<br />1,12 GRD.
<br />4NC
<br />NV
<br />AUX 4
<br />I -�
<br />-�
<br />AUX 3
<br />AUX 2
<br />-�
<br />AUX 1
<br />--J
<br />C
<br />NC
<br />3NC.
<br />NO
<br />C
<br />NO
<br />214C
<br />a
<br />a
<br />214C
<br />>
<br />000
<br />J
<br />m
<br />m
<br />JUNCTION
<br />BOX
<br />44
<br />POWER INPUT '
<br />,I
<br />H,
<br />. G
<br />I
<br />r--
<br />I.....
<br />I
<br />I
<br />SEE NOTE #9
<br />II
<br />...........................".
<br />ij
<br />TO U/G TANK AREA
<br />(LEAK DETECTION SENSORS)
<br />SEE SHEET 7K4-2
<br />1.
<br />3�'V' C,12
<br />V
<br />G
<br />U
<br />o
<br />�
<br />G
<br />!V
<br />N
<br />^-
<br />a
<br />a
<br />a
<br />a
<br />>
<br />000
<br />J
<br />m
<br />m
<br />5
<br />UIHa@I3[9a91MI.1 %
<br />_____________-___- Ie
<br />3/4 C. 8,20
<br />(SEE NOTE ,B) Typical Tokeim Dis enser 26
<br />3/4'C, 8,20
<br />(SEE NOTE ,8)
<br />KV -700 -NO -24 �- SEE NOTE ,11
<br />42 AUX. NO. 1 RELAY
<br />a
<br />X1 V+ 1NC L 3'-3/4"C, 2114 EACH
<br />K2 Al
<br />EC -1 REGULAR y_ (SEE NOTE #10)
<br />Model #262A (Dual Single Product)
<br />Unleaded
<br />(SEE DWG. TK1-1 FOR DISPENSER TYPES & COUNT)
<br />ADDITIONAL DISPENSERS WIRED SIMILAR
<br />Special Note #1
<br />FOR FAC181TIES THAT HAVE MORE THAN (4) UNLEADED DISPENSERS (8 HOSES)
<br />A SECOND UNLEADED TURBINE WILL BE INSTALLED IN THE PASSIVE UNLEADED
<br />UNLEADED TANK. HALF OF UNLEADED HOSES SHALL BE WIRED TO ACTIVATE
<br />1st UNLEADED TURBINE. THE OTHER HALF OF THE UNLEADED HOSES SHALL
<br />BE WIRED TO ACTIVATE 2nd UNLEADED TURBINE.
<br />ONE OF FOUR
<br />BOARDS SHOWN
<br />Gko kKo GGA tGo
<br />SEE N07E 5
<br />3/4"C, 12,14 (DC)
<br />DC WI
<br />LL --------------1 I
<br />I I
<br />I I
<br />I I
<br />I
<br />3/4'C, 6,14 (D.C.) I I
<br />3/4"C,
<br />THIS DRAWING USED IN RETANKING/REPIPING PROJECTS WHEN
<br />EXISTING BUILDING IS TO REMAIN
<br />3/4"C, 6,14 (D.C.)
<br />1
<br />T4
<br />N 3 2 1
<br />m �
<br />m 3
<br /><
<br />a s a s o Fo x c0�
<br />a .. 0 0 U a
<br />m ° m m S
<br />(Do CDQ CDC)J
<br />CONNECTION BOX
<br />Typical Tokeim Dispenser 26
<br />Model #262A (Dual Two Product)
<br />EC -1 Regular/Mid-Grade Extra and
<br />EC-Premimum/Supreme Unleaded
<br />ADDITIONAL DISPENSERDWG. TK1-1 S WIS ED NSER SIMILAR EPES &COUNT)
<br />A iDATEREVISIONS
<br />ISSUED FOR PLAN CHECK
<br />jj &
<br />IF
<br />CEc��
<br />td 00 m O
<br />D.N C
<br />E 0'O > O
<br />O 0C W 0
<br />(, -rc- W O
<br />a od N Q
<br />some
<br />o mU
<br />V2°��vi
<br />•0)
<br />to Z
<br />O 00C
<br />LM a
<br />a N
<br />0 C J
<br />V � Q
<br />Q CCN
<br />X
<br />O
<br />Co
<br />IM
<br />0
<br />a
<br />m
<br />m
<br />o
<br />4
<br />w
<br />z
<br />V W
<br />IZW O
<br />�a0
<br />cc
<br />LL N
<br />a I I �N mm
<br />C
<br />C NO
<br />N N
<br />0
<br />M/i<
<br />W
<br />C
<br />C
<br />.� X m
<br />V
<br />LL 0
<br />.14
<br />cE
<br />E 02
<br />Of C
<br />M3 Cr. ,r
<br />W
<br />1.1.�
<br />Z Q3:
<br />Appr. 3194
<br />L.S. ANDREWS
<br />date drawn by
<br />3-1-94 SHK
<br />Sheet / Nle
<br />TK4 f1
<br />U
<br />N
<br />N
<br />-
<br />a
<br />a
<br />a
<br />a
<br />S
<br />m
<br />M
<br />S
<br />3/4 C. 8,20
<br />(SEE NOTE ,B) Typical Tokeim Dis enser 26
<br />3/4'C, 8,20
<br />(SEE NOTE ,8)
<br />KV -700 -NO -24 �- SEE NOTE ,11
<br />42 AUX. NO. 1 RELAY
<br />a
<br />X1 V+ 1NC L 3'-3/4"C, 2114 EACH
<br />K2 Al
<br />EC -1 REGULAR y_ (SEE NOTE #10)
<br />Model #262A (Dual Single Product)
<br />Unleaded
<br />(SEE DWG. TK1-1 FOR DISPENSER TYPES & COUNT)
<br />ADDITIONAL DISPENSERS WIRED SIMILAR
<br />Special Note #1
<br />FOR FAC181TIES THAT HAVE MORE THAN (4) UNLEADED DISPENSERS (8 HOSES)
<br />A SECOND UNLEADED TURBINE WILL BE INSTALLED IN THE PASSIVE UNLEADED
<br />UNLEADED TANK. HALF OF UNLEADED HOSES SHALL BE WIRED TO ACTIVATE
<br />1st UNLEADED TURBINE. THE OTHER HALF OF THE UNLEADED HOSES SHALL
<br />BE WIRED TO ACTIVATE 2nd UNLEADED TURBINE.
<br />ONE OF FOUR
<br />BOARDS SHOWN
<br />Gko kKo GGA tGo
<br />SEE N07E 5
<br />3/4"C, 12,14 (DC)
<br />DC WI
<br />LL --------------1 I
<br />I I
<br />I I
<br />I I
<br />I
<br />3/4'C, 6,14 (D.C.) I I
<br />3/4"C,
<br />THIS DRAWING USED IN RETANKING/REPIPING PROJECTS WHEN
<br />EXISTING BUILDING IS TO REMAIN
<br />3/4"C, 6,14 (D.C.)
<br />1
<br />T4
<br />N 3 2 1
<br />m �
<br />m 3
<br /><
<br />a s a s o Fo x c0�
<br />a .. 0 0 U a
<br />m ° m m S
<br />(Do CDQ CDC)J
<br />CONNECTION BOX
<br />Typical Tokeim Dispenser 26
<br />Model #262A (Dual Two Product)
<br />EC -1 Regular/Mid-Grade Extra and
<br />EC-Premimum/Supreme Unleaded
<br />ADDITIONAL DISPENSERDWG. TK1-1 S WIS ED NSER SIMILAR EPES &COUNT)
<br />A iDATEREVISIONS
<br />ISSUED FOR PLAN CHECK
<br />jj &
<br />IF
<br />CEc��
<br />td 00 m O
<br />D.N C
<br />E 0'O > O
<br />O 0C W 0
<br />(, -rc- W O
<br />a od N Q
<br />some
<br />o mU
<br />V2°��vi
<br />•0)
<br />to Z
<br />O 00C
<br />LM a
<br />a N
<br />0 C J
<br />V � Q
<br />Q CCN
<br />X
<br />O
<br />Co
<br />IM
<br />0
<br />a
<br />m
<br />m
<br />o
<br />4
<br />w
<br />z
<br />V W
<br />IZW O
<br />�a0
<br />cc
<br />LL N
<br />a I I �N mm
<br />C
<br />C NO
<br />N N
<br />0
<br />M/i<
<br />W
<br />C
<br />C
<br />.� X m
<br />V
<br />LL 0
<br />.14
<br />cE
<br />E 02
<br />Of C
<br />M3 Cr. ,r
<br />W
<br />1.1.�
<br />Z Q3:
<br />Appr. 3194
<br />L.S. ANDREWS
<br />date drawn by
<br />3-1-94 SHK
<br />Sheet / Nle
<br />TK4 f1
<br />
|