|
NOT USED
<br />E-4 NOT TO SCALE:
<br />INSTRUCTIONS:
<br />NOTE: WHEN TEMPERATURE IS BELOW 50-F (10'C), KEEP RESIN IN A WARM PLACE PRIOR
<br />TO MIXING (e.g., IN AN INSIDE POCKET NEXT TO BODY).
<br />1. REMOVE GUARD BAG, USING CAUTION NOT TO DAMAGE INNER BAG.
<br />2. GRIP BOTH EDGES OF BAG AT THE CENTER BARRIER, WHILE YOU FLEX AND
<br />WRINKLE THE BAG ACROSS THE BARRIER, THIS WILL WEAKEN THE BARRIER.
<br />3. SQUEEZE THE CLEAR SIDE OF THE RESIN, FORCING THE RESIN THROUGH THE
<br />CENTER BARRIER.
<br />4. MIX THOROUGHLY TO A UNIFORM COLOR BY SQUEEZING CONTENTS BACK AND
<br />FORTH 25-30 TIMES,
<br />5. SQUEEZE RESIN TO ONE END OF BAG, AND CUT-OFF OTHER END.
<br />6. SLOWLY INSERT CONNECTION INTO SEALING PACK UNTIL IT FITS SNUGLY AGAINST
<br />THE OPPOSITE END.
<br />7. TWIST OPEN END OF BAG AND USE TIE WRAP TO CLOSE IT OFF, OR 'WRAP OPEN
<br />END OF BAG WITH VINYL ELECTRICAL TAPE AND POSITION THE TAPED END UP
<br />UNTIL THE RESIN JELLS.
<br />OUTER B
<br />TO CONSOLE
<br />TO SENSOR/PROBE
<br />IP TIE
<br />EALED
<br />B Veeder Root Splicing Detail
<br />:_4 NOT TO SCALE:
<br />GROUNDING
<br />ELECTRODE
<br />CONDUCTOR
<br />TO MAIN PANEL
<br />GROUNDING ELECTRODE
<br />3" MINIMUM
<br />PER STEEL
<br />REBAR
<br />DIRECT CONTACT
<br />WITH EARTH
<br />FOUNDATION
<br />n 11
<br />20'-0" MINIMUM
<br />c\ Electrode Groundi
<br />NOT TO SCALE:
<br />BOLT -TYPE CONNECTION
<br />DEVICE OR EXOTHERMIC
<br />WELD
<br />NON-METALLIC
<br />PROTECTIVE SLEEVE
<br />° f 1
<br />a
<br />a v
<br />4 AWG OR LARGER
<br />BARE COPPER
<br />CONDUCTOR OR STEEL
<br />REINFORCING BAR OR
<br />ROD NOT LESS THAN
<br />1/2 INCH DIAMETER
<br />Detail
<br />AC LINE
<br />AC NEUTRAL
<br />CHASSIS GROUND
<br />BARRIER
<br />GROUND
<br />POWER
<br />AREA INTRINSICALLY SAFE AREA
<br />'VEEDER-ROOT" TLS
<br />0 ® O
<br />(WITH THE FOLLOWING CONFIGURATION)
<br />(1) VR -330160-160
<br />FED E®
<br />(2 1VR-329260-001
<br />EXPANSION MODULE FOR 35DR
<br />(4) VR -329358-001
<br />EIGHT INPUT INTERSTITUAL/LIQUID
<br />(73 VR -330149-002
<br />SITEFAX MODULE
<br />SENSOR INTERFACE MODULE
<br />(1) VR -330843-001
<br />6 INPUT PLIED MODULE
<br />(1) VR -329356-002
<br />FOUR INPUT PROBE INTERFACE MODULE
<br />(1) VR -329356-004
<br />SEVEN INPUT SMART CARD
<br />1 VR -329359-001
<br />FOUR RELAY OUTPUT MODULE
<br />r.' r 2-7+3 -1 °� sT 67 ,�+Ba.
<br />5E,,
<br />(1) VR -330280-001
<br />BIR PROTOCOL DIM
<br />(2) VR -329356-004
<br />EIGHT INPUT SMART CARD
<br />1 VR -330532-001
<br />SENSOR—
<br />1
<br />WrvIm
<br />,5 w
<br />6
<br />17
<br />5 SPARE
<br />SPARE
<br />4
<br />6 SPARE
<br />18
<br />,I
<br />SPARE
<br />MODULE
<br />6
<br />TYPE
<br />RED
<br />8
<br />mmm10101000
<br />POSITION
<br />DEVICES,
<br />RECORD_
<br />•
<br />2 REG. UNL A FILL SUMP 1 6 PREMIUM UNL, T RB SUMP
<br />,
<br />•
<br />1
<br />pINICN ER
<br />ALARM
<br />MODULE TYPE: SMART SENSORS
<br />2
<br />POSITION RECORD: `✓ACUUM MAG SENSORS
<br />RED
<br />1 PRIM UNL PROD LINE V 5 REG. UNL B NRB SUMP M
<br />INTERSTITIAL SENSOR INTERFACE MODULE
<br />SENSORS
<br />YELLOW
<br />7
<br />30
<br />[4:REG. UNL A FILL SUMP Mj 1 8 PREM JILL FILL SUMP M
<br />4
<br />MODULE TYPE: SMART SENSORS 7 -SLOT
<br />8
<br />� N
<br />ALARM
<br />MODULE
<br />TYPE:
<br />2 REG UNL A VAPOR UNE V 6 REG. UNL B VENT LINE AA
<br />V
<br />NOT USED
<br />ENSOR—+
<br />POSITION
<br />N�
<br />METER SET UP OR DETECTED.
<br />MODULE TYPE: SMART SENSORS
<br />14
<br />SPARE
<br />FAILURE OF VOLUME MEASURE
<br />1 DISPENSER 1 2 5 DLSPENSF-_R 9 10
<br />2
<br />f
<br />2
<br />3 DISPENSER 546 1 7 DISPENSER 13/14
<br />15
<br />4 DISPENSER 7/8 18 DISPENSER
<br />15/16
<br />7
<br />mem mme
<br />7
<br />YES
<br />POSITION RECORD: TANK LEVEL GAUGES
<br />•
<br />1 REG. UNLEADED A
<br />•
<br />•
<br />2 REG. UNLEADED B
<br />W ENSER
<br />TYPE:
<br />3 PREM. UNLEADED
<br />INTERSTITNL SENSOR INTERFACE MODULE
<br />SENSORSSP
<br />POSITION
<br />RECORD:
<br />GROUND p
<br />COLLECTIONYELLOW
<br />7 -DAY DEGREDATION A/L TEST
<br />7
<br />t'�� +3 +4T5LB�
<br />135
<br />2
<br />WARNING
<br />6
<br />ONLY
<br />PRESSURE---
<br />3
<br />anwn,SPwo
<br />17
<br />I
<br />SITE SHUTDOWN
<br />SPARE
<br />VISUAL &
<br />XMIT
<br />WARNING 2ND CONSECUTIVE FAILURE
<br />MODULE
<br />TYPE:
<br />14
<br />NOT USED
<br />ISD SENSOR OUT SELF -TEST
<br />6
<br />000000
<br />PLLD
<br />TANK PRODUCT LEVEL BELOW 10 -INCH
<br />WARNING
<br />•
<br />•
<br />125
<br />TURBINE
<br />ISD SENSOR OUT SELF -TEST
<br />6
<br />PRESSURE LINE LEAN INTERFACE MODULE
<br />SUMPS
<br />7
<br />THE DEFAULT LINE LENGTH WAS NOT CHANGED TOP
<br />4
<br />SELF -TEST
<br />18
<br />r'--T-,'T+3T4-+ T+G�'�+Ra
<br />F.mmM.,
<br />MODULE
<br />TYPE:
<br />OPEN ALARM
<br />NOT USED
<br />YES
<br />POSITION
<br />RECORD:
<br />ISD SETUP FAILURE
<br />SELF -TEST
<br />RED
<br />1
<br />SPARE
<br />5
<br />SENSOR �
<br />1414 ....
<br />_. ;s w;"`
<br />87H CONSECUTIVE FAILURE
<br />6
<br />13
<br />3
<br />mmm mmm 0000
<br />14
<br />•
<br />8
<br />•
<br />•
<br />MODULE
<br />TANK SUMP
<br />POSITION
<br />RECORD:
<br />PLLD
<br />INIERSTRIAL '3fNSOR INTERFA4E MODULE
<br />.5 SPARE
<br />10
<br />2 REG. UNLEADED
<br />2 6 SPARE
<br />I+'
<br />--i +2T+'-T+°�+'T+sem+'�+e�
<br />wm,o°
<br />UNLEADED
<br />#117 SPARE
<br />SPARE
<br />4 SPARE
<br />SENSOR--
<br />18 SPARE
<br />na
<br />MODULE
<br />12
<br />OUTPUT
<br />MODULE
<br />4
<br />m m m m 0 m m
<br />VACUUM & MAG
<br />•
<br />-
<br />1 COM, ENCLSK VR PEEPF ALARM 5 SPARE
<br />•
<br />•
<br />2 SPARE
<br />SUMP SENSORS
<br />6 SPARE
<br />.3 SPARE
<br />17 SPARE
<br />5 T ENSOR INTERFACE F1000LE
<br />4 SPARE
<br />18 SPARE
<br />GROUND
<br />i'i�+RT+'-7+4�q +G�+'
<br />❑0 ❑0
<br />SENSOR—_
<br />03
<br />SPARE
<br />1 1
<br />3 1101011
<br />m m m
<br />VACUUM
<br />.
<br />•
<br />.
<br />SENSORS
<br />t4 SMART INSIDEINIERP CE M CULE
<br />r'NO'Tc�Ro cT �3T4—rro ` RELAY TO EXTERNAL DEUCE
<br />F +0 -r+5 -r 4�ST `�+/�+0�,ucl
<br />cl
<br />EAU, AN�11
<br />SENSOR14
<br />M_
<br />14 14 1414141
<br />-J
<br />1 L�
<br />m m 0 m m 0 0 0 0 0 0 0I 1LVKK' M WR
<br />0 0 0 0 0 0
<br />•
<br />•
<br />.2
<br />60 V4POfl Ah
<br />SMART SENSOR INTERFACE MOOULE
<br />1. MCINA
<br />R SLI
<br />PRDBE
<br />r PROBE TINTFASEBUAL�
<br />U PR L1 ED >I >R Lt Po PI GA TC
<br />1T T T l
<br />rY 2-I+,-1 4Y Si Di '-I,B-4
<br />.
<br />it 14 it 14 14 1
<br />Ir
<br />gease
<br />`deeeeeee ee ee
<br />1
<br />0 0.0 mmm
<br />0
<br />mm
<br />TANK LPEL
<br />PRESSURE LINE LEAK CONTROLLER
<br />COMBO PROBE/IMERSETNL INTERFACE MODULE
<br />GAUGES
<br />'VEEDER-ROOT" TLS
<br />-350 W/ PRINTER MODEL )TVR -848290-122
<br />(WITH THE FOLLOWING CONFIGURATION)
<br />(1) VR -330160-160
<br />RISK MANAGEMENT SOFTWARE
<br />(2 1VR-329260-001
<br />EXPANSION MODULE FOR 35DR
<br />(4) VR -329358-001
<br />EIGHT INPUT INTERSTITUAL/LIQUID
<br />(73 VR -330149-002
<br />SITEFAX MODULE
<br />SENSOR INTERFACE MODULE
<br />(1) VR -330843-001
<br />6 INPUT PLIED MODULE
<br />(1) VR -329356-002
<br />FOUR INPUT PROBE INTERFACE MODULE
<br />(1) VR -329356-004
<br />SEVEN INPUT SMART CARD
<br />1 VR -329359-001
<br />FOUR RELAY OUTPUT MODULE
<br />SHUTDOWN
<br />5
<br />(1) VR -330280-001
<br />BIR PROTOCOL DIM
<br />(2) VR -329356-004
<br />EIGHT INPUT SMART CARD
<br />1 VR -330532-001
<br />TLS -350 MEMORY EXPANSION MODULE
<br />1
<br />3
<br />INTRINSICALLY -SAFE AREA
<br />POWER
<br />AREA
<br />MODULE TYPE: INTERSTITIAL SENSOR INTERFACE
<br />GROUND
<br />POSITION RECORD: DISPENSER SENSORS - BRINE
<br />Le Im
<br />1 DISPENSER 1 2 5 Dl.SPENSER 9 10
<br />LIGHT
<br />MODULE
<br />TYPE:
<br />NOT USED
<br />4 DISPENSER 7/8 18 DISPENSER 15/16
<br />POSITION
<br />RECORD:
<br />7
<br />POSITION RECORD: DISPENSER SENSORS - STD
<br />16
<br />1
<br />SHUTDOWN
<br />5
<br />DEVICES,
<br />3 DISPENSER b46 I 7 DISPENSER 13/14
<br />2
<br />DISPENSER 7/8 Id DISPENSER 15/16
<br />6
<br />MODULE TYPE: PLIED INTERFACE MODULE
<br />1
<br />3
<br />6
<br />17
<br />5 SPARE
<br />8TH CONSECUTIVE FAILURE
<br />4
<br />6 SPARE
<br />18
<br />3 PREM. UNLEADED #11/
<br />SPARE
<br />MODULE
<br />4 PREM. UNLEADED #2[d
<br />TYPE
<br />RED
<br />NOT USED
<br />SHUTDOWN
<br />POSITION
<br />DEVICES,
<br />RECORD_
<br />ISD GROSS PRESSURE FAILURE
<br />2 REG. UNL A FILL SUMP 1 6 PREMIUM UNL, T RB SUMP
<br />15
<br />3 REG. UNL B TURB SUMP 7 PREMIUM UNL FILL SUMP
<br />1
<br />4 SPARE 8 SPARE
<br />ALARM
<br />MODULE TYPE: SMART SENSORS
<br />2
<br />POSITION RECORD: `✓ACUUM MAG SENSORS
<br />RED
<br />1 PRIM UNL PROD LINE V 5 REG. UNL B NRB SUMP M
<br />4
<br />3
<br />YELLOW
<br />7
<br />30
<br />[4:REG. UNL A FILL SUMP Mj 1 8 PREM JILL FILL SUMP M
<br />4
<br />MODULE TYPE: SMART SENSORS 7 -SLOT
<br />8
<br />POSITION RECORD: VACUUM SENSORS
<br />ALARM
<br />MODULE
<br />TYPE:
<br />2 REG UNL A VAPOR UNE V 6 REG. UNL B VENT LINE AA
<br />V
<br />NOT USED
<br />3 REG. UNL A VENT LINE V 71SD PRESSURE SYSTEM PRESSURE KNESOR
<br />POSITION
<br />RECORD:
<br />METER SET UP OR DETECTED.
<br />MODULE TYPE: SMART SENSORS
<br />14
<br />1
<br />FAILURE OF VOLUME MEASURE
<br />1 DISPENSER 1 2 5 DLSPENSF-_R 9 10
<br />2
<br />2 DISPENSER 3 4 6 DISPENSER 11/12
<br />2
<br />3 DISPENSER 546 1 7 DISPENSER 13/14
<br />i5
<br />6
<br />4 DISPENSER 7/8 18 DISPENSER
<br />15/16
<br />3
<br />MODULE TYPE: COMBO PROBE INTERSTITW. INTERFACE
<br />7
<br />YES
<br />POSITION RECORD: TANK LEVEL GAUGES
<br />4
<br />1 REG. UNLEADED A
<br />18
<br />1
<br />2 REG. UNLEADED B
<br />MODULE
<br />TYPE:
<br />3 PREM. UNLEADED
<br />NOT USED
<br />2ND CONSECUTIVE FAILURE
<br />POSITION
<br />RECORD:
<br />GROUND p
<br />COLLECTIONYELLOW
<br />7 -DAY DEGREDATION A/L TEST
<br />7
<br />WARNING LIGHT
<br />135
<br />2
<br />WARNING
<br />6
<br />ONLY
<br />HNN: DEGRD COLLECTION FAILURE
<br />3
<br />RED
<br />17
<br />I
<br />SITE SHUTDOWN
<br />4
<br />VISUAL &
<br />18
<br />WARNING 2ND CONSECUTIVE FAILURE
<br />MODULE
<br />TYPE:
<br />SELF -TEST
<br />NOT USED
<br />ISD SENSOR OUT SELF -TEST
<br />POSITION
<br />RECORD:
<br />AUDIO,
<br />TANK PRODUCT LEVEL BELOW 10 -INCH
<br />WARNING
<br />ONLY
<br />ISD SENSOR OUT FAILURE
<br />125
<br />2
<br />ISD SENSOR OUT SELF -TEST
<br />6
<br />SITE SHUTDOWN
<br />YESAUDIO,
<br />7
<br />THE DEFAULT LINE LENGTH WAS NOT CHANGED TOP
<br />4
<br />SELF -TEST
<br />18
<br />SYSTEM SETUP SELF -TEST WARNING
<br />7
<br />MODULE
<br />TYPE:
<br />OPEN ALARM
<br />NOT USED
<br />YES
<br />POSITION
<br />RECORD:
<br />ISD SETUP FAILURE
<br />SELF -TEST
<br />RED
<br />1
<br />I
<br />5
<br />VISUAL &
<br />11
<br />2
<br />87H CONSECUTIVE FAILURE
<br />6
<br />3
<br />14
<br />8
<br />MODULE
<br />TYPE: PLLD CONTROLLER MODULE
<br />POSITION
<br />RECORD:
<br />PLLD
<br />1 REG. UNLEADED1
<br />.5 SPARE
<br />10
<br />2 REG. UNLEADED
<br />2 6 SPARE
<br />3 PREM.
<br />UNLEADED
<br />#117 SPARE
<br />4 SPARE
<br />18 SPARE
<br />MODULE
<br />TYPE: 4 -RELAY
<br />OUTPUT
<br />MODULE
<br />POSITION
<br />RECORD
<br />-
<br />1 COM, ENCLSK VR PEEPF ALARM 5 SPARE
<br />2 SPARE
<br />6 SPARE
<br />.3 SPARE
<br />17 SPARE
<br />4 SPARE
<br />18 SPARE
<br />GROUND
<br />❑0 ❑0
<br />INTRINSICALLY -SAFE AREA
<br />GROUND ❑m 0
<br />INDICATOR
<br />MODULE TYPE: INTERSTITIAL SENSOR INTERFACE
<br />DAYS TO
<br />POSITION RECORD: DISPENSER SENSORS - BRINE
<br />g
<br />1 DISPENSER 1 2 5 Dl.SPENSER 9 10
<br />LIGHT
<br />2 DISPENSER 3/4 15 DISPENSER 11/12
<br />ALARM
<br />3 DISPENSER 546 1 7 BISPENSER 13/14
<br />ISD VAPOR LEAKAGE WARNING
<br />4 DISPENSER 7/8 18 DISPENSER 15/16
<br />YELLOW
<br />MODULE TYPE: INTERSTITIAL SENSOR INTERFACE
<br />7
<br />POSITION RECORD: DISPENSER SENSORS - STD
<br />7
<br />1 DISPENSER 7 2 5 DISPENSER 9/10
<br />SHUTDOWN
<br />2 DISPENSER 3 4 16 DISPENSER 11112
<br />DEVICES,
<br />3 DISPENSER b46 I 7 DISPENSER 13/14
<br />ISD VAPOR LEAKAGE FAILURE
<br />DISPENSER 7/8 Id DISPENSER 15/16
<br />RED
<br />MODULE TYPE: PLIED INTERFACE MODULE
<br />1
<br />POSITION RECORD: TURBINE PLLD
<br />6
<br />11 UNLEADED 1
<br />5 SPARE
<br />8TH CONSECUTIVE FAILURE
<br />2 REG. UNLEADED '2
<br />6 SPARE
<br />ISD GROSS PRESSURE WARNING
<br />3 PREM. UNLEADED #11/
<br />SPARE
<br />GROSS OVER PRESSURE TEST7
<br />4 PREM. UNLEADED #2[d
<br />SPARE
<br />RED
<br />MODULE TYPE: INTERSTITIAL SENSOR INTERFACE
<br />SHUTDOWN
<br />POSITION RECORD: TANK SUMPS - BRINE SENSORS
<br />DEVICES,
<br />1 REG. UNL A TUR SUMP 5 REG UNE B FILL SUMP
<br />ISD GROSS PRESSURE FAILURE
<br />2 REG. UNL A FILL SUMP 1 6 PREMIUM UNL, T RB SUMP
<br />RED
<br />3 REG. UNL B TURB SUMP 7 PREMIUM UNL FILL SUMP
<br />1
<br />4 SPARE 8 SPARE
<br />ALARM
<br />MODULE TYPE: SMART SENSORS
<br />PROPERLY.
<br />POSITION RECORD: `✓ACUUM MAG SENSORS
<br />RED
<br />1 PRIM UNL PROD LINE V 5 REG. UNL B NRB SUMP M
<br />4
<br />2 PREM UNL VENT LINE V 6 REG, UNL B FILL SUMP M
<br />YELLOW
<br />3 REG. UNL A TURB SUMP (Efl 7 PREM UNL NRB SUMP M
<br />30
<br />[4:REG. UNL A FILL SUMP Mj 1 8 PREM JILL FILL SUMP M
<br />THERE IS NO VAPOR PRESSURE
<br />MODULE TYPE: SMART SENSORS 7 -SLOT
<br />VISUAL &
<br />POSITION RECORD: VACUUM SENSORS
<br />ALARM
<br />1 REG. UNL A PROD LINE 5 REO. UNL B SIPHON LINE V
<br />3
<br />2 REG UNL A VAPOR UNE V 6 REG. UNL B VENT LINE AA
<br />V
<br />RED
<br />3 REG. UNL A VENT LINE V 71SD PRESSURE SYSTEM PRESSURE KNESOR
<br />I
<br />4 REG, UNL B PRODUCT LINE IVA 8AM8. COLD BUNK - DONN USE
<br />METER SET UP OR DETECTED.
<br />MODULE TYPE: SMART SENSORS
<br />WARNING
<br />POSITION RECORD: ISO VAPOR FLOW SENSORS
<br />FAILURE OF VOLUME MEASURE
<br />1 DISPENSER 1 2 5 DLSPENSF-_R 9 10
<br />2
<br />2 DISPENSER 3 4 6 DISPENSER 11/12
<br />YELLOW
<br />3 DISPENSER 546 1 7 DISPENSER 13/14
<br />PRESSURIZED LINE
<br />4 DISPENSER 7/8 18 DISPENSER
<br />15/16
<br />METER DECONFIGURED OR
<br />MODULE TYPE: COMBO PROBE INTERSTITW. INTERFACE
<br />NODULE
<br />YES
<br />POSITION RECORD: TANK LEVEL GAUGES
<br />HNN: GROSS COLLECTION FAILURE
<br />1 REG. UNLEADED A
<br />11 REG. UNL A ANNULAR
<br />1
<br />2 REG. UNLEADED B
<br />6 REG. UNL B ANNULAR
<br />3 PREM. UNLEADED
<br />7 PREM. UNL ANNULAR
<br />2ND CONSECUTIVE FAILURE
<br />4 SPARE
<br />8 SPARE
<br />GROUND p
<br />G Veeder Root Console Module
<br />:-4NOT TO SCALE:
<br />ISD ALARM SUMMARY
<br />ation
<br />ISD MONITORING TESTS OPERATE ONCE EACH
<br />DAY. WARNING AND FAILURE CONDITIONS
<br />ARE CASED AT THE DESIGNATED POSTING TIME
<br />AFTER THE TESTS ARE COMPLETE.
<br />WARNINGS:
<br />WARNINGS INDICATE WHEN ATTENTION IS
<br />REQUIRED. WHEN A WARNING IS POSTED A
<br />WARNING ALARM EVENT IS LOGGED IN THE ISD
<br />REPORTS, POSTED ON THE FOREST
<br />PANEL DISPLAY AND PRINTED TO THE PRINTER.
<br />IF CONDITIONS PERSISTS, A WARNING WILL
<br />REMAIN ACTIVE FORA 1 7 OR 30 DAY
<br />WARNING PERIOD DEPENDEING ONT THE TEST
<br />TYPE „EE ALARM TABLE ON REVERSE SIDE.
<br />FAILURES:
<br />IF A WARNING CONDITION PERSISTS, A FAILURE
<br />ALARM WILL BE POSTED AFTER THE YARNING
<br />PERIOD AND THE SITE DISPENSING UIP
<br />E MENT
<br />Q
<br />IS SHUTDOWN (SEE RESTARTING STATION AFTER
<br />ISD SHUTDOWN FOR INSTRUCTIONS ON
<br />RESTARTING DISPENSING).
<br />WHEN A FAILURE IS POSTED A FAILURE ALARM
<br />EVENT IS LOGGED IN THE ISD
<br />REPORTS, POSTED ON THE FRONT PANEL
<br />DISPLAY AND PRINTED TO THE PRINTER.
<br />RESTARTHNG STATION AFTER
<br />ISD SHUTDOWN
<br />CONSULT STATE AND LOCAL REGULATIONS
<br />PRIOR TO RESTARTING EQUIPMENT.
<br />SENSOR ALARM SUMMARY OTHER ALARM
<br />DISPLAYED
<br />ISD MONITORING
<br />INDICATOR
<br />ACTIVATION RESULTS
<br />DAYS TO
<br />SYSTEM
<br />DISPLAYED MESSAGE
<br />CATAGORY
<br />LIGHT
<br />CAUSE
<br />ALARM
<br />STATUS
<br />ISD VAPOR LEAKAGE WARNING
<br />CONTAINMENT
<br />YELLOW
<br />VAPOR LEAKAGE DETECTION TEST
<br />7
<br />WARNING LIGHT
<br />RED
<br />YES
<br />SHUTDOWN
<br />WARNING
<br />DEVICES,
<br />ONLY
<br />ISD VAPOR LEAKAGE FAILURE
<br />CONTAINMENT
<br />RED
<br />VAPOR LEAKAGE DETECTION TEST
<br />1
<br />SITE SHUTDOWN
<br />ALARM
<br />DETECTS LIQUID IN A TANK'S INTERSTITIAL SPACE OR
<br />8TH CONSECUTIVE FAILURE
<br />HAS NOT BEEN ASSIGNEDTOA
<br />SETUP.
<br />ISD GROSS PRESSURE WARNING
<br />CONTAINMENT
<br />YELLOW
<br />GROSS OVER PRESSURE TEST7
<br />PIPING SUMP.
<br />WARNING LICHT
<br />RED
<br />YES
<br />SHUTDOWN
<br />WARNING
<br />DEVICES,
<br />ONLY
<br />ISD GROSS PRESSURE FAILURE
<br />CONTAINMENT
<br />RED
<br />GROSS OVER PRESSURE TEST
<br />1
<br />SITE SHUTDOWN
<br />ALARM
<br />CONFIGURE VAPOR FLOW
<br />PROPERLY.
<br />WARNING -8111 CONSECUTIVE FAILURE
<br />RED
<br />YES
<br />_
<br />ISD DEGRD PRESSURE WARNING
<br />CONTAINMENT
<br />YELLOW
<br />DEGRADATION OVER -PRESSURE
<br />30
<br />WARNING LIGHT
<br />THERE IS NO VAPOR PRESSURE
<br />COMPLETE VAPOR PRESSURE
<br />VISUAL &
<br />TEST WARNING
<br />ALARM
<br />ONLY
<br />ISD DEGRD PRESSURE FAILURE
<br />CONTAINMENT
<br />RED
<br />DEGREDATION OVER PRESSURE TEST
<br />I
<br />SITE SHUTDOWN
<br />METER SET UP OR DETECTED.
<br />PROGRAMING ERROR
<br />WARNING
<br />WARNING- 30TH CONSECUTIVE FAILURE
<br />FAILURE OF VOLUME MEASURE
<br />VOLUME MEASURE TEST
<br />HNN: GROSS COLLECTION WARNING
<br />COLLECTION
<br />YELLOW
<br />1 -DAY GROSS A/1_ TEST1
<br />PRESSURIZED LINE
<br />WARNING LIGHT
<br />-VAPOR FLOW METER.
<br />METER DECONFIGURED OR
<br />SHUTDOWN
<br />WARNING
<br />YES
<br />ONLY
<br />HNN: GROSS COLLECTION FAILURE
<br />ION
<br />RED
<br />1 -DAY GROSS A L TEST WARNING-CGLLEC
<br />7
<br />SITE SHUTDOWN
<br />VISUAL &PRINTED
<br />COPY OF
<br />2ND CONSECUTIVE FAILURE
<br />LEAK TEST, OR AN ALARM ASSIGNED TO DISABLE LINE
<br />HNN: DEGRD COLLECTION WARNING
<br />COLLECTIONYELLOW
<br />7 -DAY DEGREDATION A/L TEST
<br />7
<br />WARNING LIGHT
<br />IN ACTIVE.
<br />GROSS LINE
<br />WARNING
<br />YES
<br />ONLY
<br />HNN: DEGRD COLLECTION FAILURE
<br />COLLECTION
<br />RED
<br />DEGREDATION A L TESTkE
<br />I
<br />SITE SHUTDOWN
<br />VISUAL &
<br />PRINTED COPY OF
<br />WARNING 2ND CONSECUTIVE FAILURE
<br />HALTS WHILE ALARM IS ACTIVE.
<br />ISD SENSOR OUT WARNING
<br />SELF -TEST
<br />YELLOW
<br />ISD SENSOR OUT SELF -TEST
<br />7
<br />WARNING LIGHT
<br />AUDIO,
<br />TANK PRODUCT LEVEL BELOW 10 -INCH
<br />WARNING
<br />ONLY
<br />ISD SENSOR OUT FAILURE
<br />SELF -TEST
<br />RED
<br />ISD SENSOR OUT SELF -TEST
<br />1
<br />SITE SHUTDOWN
<br />YESAUDIO,
<br />8TH CONSECUTIVE FAILURE
<br />THE DEFAULT LINE LENGTH WAS NOT CHANGED TOP
<br />ISD SETUP WARNING
<br />SELF -TEST
<br />YELLOW
<br />SYSTEM SETUP SELF -TEST WARNING
<br />7
<br />WARNING LIGHT
<br />REFLECT THE ACTUAL LINE LENGTH.
<br />OPEN ALARM
<br />RED
<br />YES
<br />SHUTDONiN
<br />ONLY
<br />ISD SETUP FAILURE
<br />SELF -TEST
<br />RED
<br />SYSTEM SETUP SELF -TEST FAILURE
<br />I
<br />SITE SHUTDOWN
<br />VISUAL &
<br />PRINTED COPY OF
<br />ALARM
<br />87H CONSECUTIVE FAILURE
<br />KPA) ONLY TESTED WHILE PUMP IS RUNNING.
<br />ation
<br />ISD MONITORING TESTS OPERATE ONCE EACH
<br />DAY. WARNING AND FAILURE CONDITIONS
<br />ARE CASED AT THE DESIGNATED POSTING TIME
<br />AFTER THE TESTS ARE COMPLETE.
<br />WARNINGS:
<br />WARNINGS INDICATE WHEN ATTENTION IS
<br />REQUIRED. WHEN A WARNING IS POSTED A
<br />WARNING ALARM EVENT IS LOGGED IN THE ISD
<br />REPORTS, POSTED ON THE FOREST
<br />PANEL DISPLAY AND PRINTED TO THE PRINTER.
<br />IF CONDITIONS PERSISTS, A WARNING WILL
<br />REMAIN ACTIVE FORA 1 7 OR 30 DAY
<br />WARNING PERIOD DEPENDEING ONT THE TEST
<br />TYPE „EE ALARM TABLE ON REVERSE SIDE.
<br />FAILURES:
<br />IF A WARNING CONDITION PERSISTS, A FAILURE
<br />ALARM WILL BE POSTED AFTER THE YARNING
<br />PERIOD AND THE SITE DISPENSING UIP
<br />E MENT
<br />Q
<br />IS SHUTDOWN (SEE RESTARTING STATION AFTER
<br />ISD SHUTDOWN FOR INSTRUCTIONS ON
<br />RESTARTING DISPENSING).
<br />WHEN A FAILURE IS POSTED A FAILURE ALARM
<br />EVENT IS LOGGED IN THE ISD
<br />REPORTS, POSTED ON THE FRONT PANEL
<br />DISPLAY AND PRINTED TO THE PRINTER.
<br />RESTARTHNG STATION AFTER
<br />ISD SHUTDOWN
<br />CONSULT STATE AND LOCAL REGULATIONS
<br />PRIOR TO RESTARTING EQUIPMENT.
<br />SENSOR ALARM SUMMARY OTHER ALARM
<br />DISPLAYED
<br />INDICATOR
<br />AUDIBLE
<br />ACTIVATION RESULTS
<br />J
<br />CAUSE
<br />MESSAGE
<br />LIGHT
<br />ALARM
<br />RED
<br />ONE OR MORE REQUIRED SHUT
<br />SET UP REQUIRED. SHUT DOW
<br />\
<br />LIQUID SENSOR
<br />STATUS INDICATORS -
<br />PIPING SUMP SENSORS & TANK INTERSTITAL SENSORS
<br />FUEL ALARM
<br />RED
<br />YES
<br />SHUTDOWN
<br />OF PROGRAMMED
<br />DEVICES,
<br />AUDIO,
<br />AN INTERSTITIAL OR PIPING SUMP LIQUID SENSOR
<br />RED
<br />RECOVERY (GASOLINE) TANKS
<br />COMPLETE GASOLINE TANK
<br />VISUAL &
<br />PRINTED COPY OF
<br />ALARM
<br />DETECTS LIQUID IN A TANK'S INTERSTITIAL SPACE OR
<br />>-Z
<br />HAS NOT BEEN ASSIGNEDTOA
<br />SETUP.
<br />I+)
<br />W
<br />CONTROL (SHUT DOWN) DEVICE
<br />OR
<br />PIPING SUMP.
<br />SENSOR OUT
<br />RED
<br />YES
<br />SHUTDOWN
<br />OF PROGRAMMED
<br />DEVICES,
<br />AUDIO,
<br />A SENSOR IS DISCONNECTED OR IS NOT FUNCTIONING
<br />ALARM
<br />METERS ASSIGNED TO A HOSE
<br />PRODUCT LINE.
<br />VISUAL &
<br />PRINTED COPY OF
<br />ALARM
<br />CONFIGURE VAPOR FLOW
<br />PROPERLY.
<br />SHORT ALARM
<br />RED
<br />YES
<br />SHUTDOWN
<br />OF PROGRAMMED
<br />DEVICES,
<br />AUDIO,
<br />AN INTERNAL SNORT HAS OCCURED IN THE SENSOR.
<br />RED
<br />THERE IS NO VAPOR PRESSURE
<br />COMPLETE VAPOR PRESSURE
<br />VISUAL &
<br />PRINTED COPY OF
<br />ALARM
<br />SETUP.
<br />VAPOR FLOW METER
<br />SETUP DATA
<br />RED
<br />YES
<br />AUDIO, VISUAL
<br />& PRINTED COPY OF ALARM
<br />METER SET UP OR DETECTED.
<br />PROGRAMING ERROR
<br />WARNING
<br />RED
<br />FAILURE OF VOLUME MEASURE
<br />VOLUME MEASURE TEST
<br />O
<br />TEST. POSSIBLE PROBLEM
<br />PASSES OR VAPOR FLOW
<br />PRESSURIZED LINE
<br />LEAK DETECTOR STATUS INDICATORS - PLLD SENSORS
<br />-VAPOR FLOW METER.
<br />METER DECONFIGURED OR
<br />SHUTDOWN
<br />RED
<br />YES
<br />SHUTDOWN
<br />OF PROGRAMMED
<br />DEVICES
<br />AUDIO
<br />SYSTEM SHUT DOWN LINE BECAUSE OF FAILED LINE
<br />ALARM
<br />P
<br />VISUAL &PRINTED
<br />COPY OF
<br />ALARM
<br />LEAK TEST, OR AN ALARM ASSIGNED TO DISABLE LINE
<br />IN ACTIVE.
<br />GROSS LINE
<br />RED
<br />YES
<br />SHUTDOWN
<br />OF PROGRAMMED
<br />DEVICES,
<br />AUDIO,
<br />A 3 GPM (11.3 LGH) LINE TEST FAILURE. DISPENSING
<br />FAIL
<br />VISUAL &
<br />PRINTED COPY OF
<br />ALARM
<br />HALTS WHILE ALARM IS ACTIVE.
<br />FUEL OUT
<br />RED
<br />YES
<br />SHUTDOWN
<br />OF PROGRAMMED
<br />DEVICES,
<br />AUDIO,
<br />TANK PRODUCT LEVEL BELOW 10 -INCH
<br />VISUAL &
<br />PRINTED COPY OF
<br />ALARM
<br />LEVEL. CAN NOT PUMP WHEN ACTIVE, DELIVERY NEEDED.
<br />SETUP DATA
<br />RED
<br />YESAUDIO,
<br />THE DEFAULT LINE LENGTH WAS NOT CHANGED TOP
<br />WARNING
<br />VISUAL
<br />&PRINTED COPY OF ALARM
<br />REFLECT THE ACTUAL LINE LENGTH.
<br />OPEN ALARM
<br />RED
<br />YES
<br />SHUTDONiN
<br />OF PROGRAMMED
<br />DEVICES,
<br />AUDIO,
<br />PRESSURE SENSGR READING IS LESS THAN 8 PSI (51.2
<br />VISUAL &
<br />PRINTED COPY OF
<br />ALARM
<br />KPA) ONLY TESTED WHILE PUMP IS RUNNING.
<br />LIT
<br />ROSTATIC
<br />SOR
<br />ECSTATIC
<br />SOR
<br />DISPLAYED MESSAGE
<br />INDICATOR
<br />SET CONDITIONS
<br />CLEAR CONDITIONS
<br />J
<br />LIGHT
<br />Q
<br />MISSING RELAY SETUP
<br />RED
<br />ONE OR MORE REQUIRED SHUT
<br />SET UP REQUIRED. SHUT DOW
<br />\
<br />DOWN ALARMS HAVE NOT BEEN
<br />ALARMS.
<br />W
<br />z
<br />ASSIGNED TO A RELAY
<br />z
<br />N
<br />THERE ARE NO VAPOR
<br />x
<br />MISSING TANK SETUP
<br />RED
<br />RECOVERY (GASOLINE) TANKS
<br />COMPLETE GASOLINE TANK
<br />Q
<br />aw
<br />DEFINED, OR A GASOLINE PUMP
<br />H
<br />>-Z
<br />HAS NOT BEEN ASSIGNEDTOA
<br />SETUP.
<br />I+)
<br />W
<br />CONTROL (SHUT DOWN) DEVICE
<br />OR
<br />W
<br />�
<br />IN AT LEAST ONE TANK.
<br />Z
<br />MISSING HOSE SETUP
<br />RED
<br />T
<br />THERE ARE NO PRODUCT
<br />ASSIGNED AT LEAST ON
<br />CO
<br />METERS ASSIGNED TO A HOSE
<br />PRODUCT LINE.
<br />HEN: VAPOR FLOW METER SETUP
<br />RED
<br />INCOMING TRANSACTION FROM
<br />CONFIGURE VAPOR FLOW
<br />�
<br />w
<br />A HOSE WITH AN UNAVAILABLE
<br />METER (SMART SENSOR) AND
<br />VAPOR FLOW METER ER
<br />ENABLE IT IN ISD.
<br />MISSING VAPOR PRESSURE SENSOR
<br />RED
<br />THERE IS NO VAPOR PRESSURE
<br />COMPLETE VAPOR PRESSURE
<br />O
<br />Z
<br />SENSOR SET UP OR DETECTED.
<br />SETUP.
<br />VAPOR FLOW METER
<br />RED
<br />THERE IS NO VAPOR FLOW
<br />COMPLETE VAPOR FLOW METER
<br />H
<br />.moi
<br />METER SET UP OR DETECTED.
<br />SETUP.
<br />HNN: CHECK VAPOR FLOW METER
<br />RED
<br />FAILURE OF VOLUME MEASURE
<br />VOLUME MEASURE TEST
<br />O
<br />TEST. POSSIBLE PROBLEM
<br />PASSES OR VAPOR FLOW
<br />'U^
<br />VJ
<br />-VAPOR FLOW METER.
<br />METER DECONFIGURED OR
<br />TEST CLEARED
<br />W
<br />J
<br />N
<br />�W00
<br />W rc 0)
<br />0pa
<br />=W3
<br />a
<br />a
<br />V
<br />O°'�
<br />U D)
<br />RR°E E S S! ONq
<br />HAL P
<br />I
<br />6/30/0
<br />CIV IV.'p,�/O
<br />J
<br />H
<br />Q
<br />d
<br />Z5
<br />0
<br />\
<br />Y
<br />z
<br />W
<br />z
<br />z
<br />N
<br />d'
<br />x
<br />_aw
<br />z
<br />04
<br />o
<br />Q
<br />aw
<br />wNNN
<br />H
<br />>-Z
<br />Sz
<br />LL'
<br />I+)
<br />W
<br />�
<br />OR
<br />W
<br />�
<br />®
<br />Z
<br />z
<br />o
<br />CO
<br />z
<br />E
<br />09
<br />Q
<br />UJ
<br />�
<br />w
<br />U
<br />Q
<br />UO
<br />®
<br />O
<br />Z
<br />co
<br />OJ
<br />J
<br />J>
<br />Of
<br />J
<br />H
<br />.moi
<br />.moi
<br />U L'I
<br />O
<br />'U^
<br />VJ
<br />w`
<br />W
<br />P
<br />W
<br />J
<br />N
<br />�W00
<br />W rc 0)
<br />0pa
<br />=W3
<br />a
<br />a
<br />V
<br />O°'�
<br />U D)
<br />RR°E E S S! ONq
<br />HAL P
<br />I
<br />6/30/0
<br />CIV IV.'p,�/O
<br />S
<br />o
<br />H
<br />d
<br />Z5
<br />0
<br />\
<br />Y
<br />z
<br />-
<br />z
<br />z
<br />N
<br />>
<br />x
<br />°J
<br />F
<br />z
<br />S
<br />DO
<br />U
<br />H
<br />Z5
<br />Z EC
<br />O
<br />m
<br />Eli
<br />x
<br />°J
<br />F
<br />z
<br />Q
<br />aw
<br />wNNN
<br />Sz
<br />I+)
<br />N
<br />0p
<br />OR
<br />3
<br />�
<br />z
<br />o
<br />CO
<br />z
<br />E
<br />ww
<br />O
<br />¢
<br /><
<br />U
<br />Q
<br />O
<br />S
<br />DO
<br />U
<br />H
<br />Z5
<br />Z EC
<br />O
<br />z�
<br />s
<br />Eli
<br />x
<br />°J
<br />F
<br />z
<br />Q
<br />aw
<br />wNNN
<br />Sz
<br />I+)
<br />N
<br />m
<br />OR
<br />�
<br />�
<br />z
<br />o
<br />CO
<br />z
<br />m
<br />ww
<br />N
<br />¢
<br /><
<br />In
<br />N
<br />In
<br />N
<br />z
<br />Z
<br />UO
<br />nn
<br />w
<br />Nz
<br />00
<br />OJ
<br />J>
<br />Of
<br />Y
<br />.moi
<br />.moi
<br />U L'I
<br />
|