INSTALL_2002 DIESEL - Laserfiche WebLink

Home Browse Search

nTank Institute APRIL 1999 Owner of Tank: ACT-100' Label No. Location of Tank: Date: CHECK() CHECK() HANDLING When anchoring with a concrete hold down pad, The handling equipment is of adequate size and a minim, 6 inch(152.4 mm)layer of pea capacity to lift and lower the tank without dragging over the concrete pad dimensions to separate or dropping. tank from pad T The repair of any damaged laminate areas has been When deadman anchors or hold down pads are used, made in accordance with installation instructions. i hold down straps have been separated from the tank by an inert insulating dielectric material at least Prior to storage,the tank has been chocked with 1 inch(25.4 mm)wider than the steel hold wood blocks or tires. _.w. down straps. EXCAVATION Tank is electrically isolated from the hold When no anchoring is required,the site has been down strap. excavated deep enough to enable 1 foot of clean sand or gravel to act as bedding material between BACKFILL native soil and tank Homogenous backfill consisting of clean sand, pea gravel or#8 crushed stone bas been used. Burial depths meet minimum code requirements Backfill has been placed along sides of tank to ensure (such as NFPA 30). full support along the tank's bottom quadrant. TESTING PIPE CONNECTIONS The tank has been air-tested at 5 psig(kPa)while Nonconductive piping used. applying soap solution onto weld seams and fittings to check or leaks. _ _ Metallic piping used. OR on a double wall tank,a vacuum test has been Dielectric bushings or flanges installe& performed in accordance with the fabricator's instructions. All local and state testing requirements have Signature and Title of Installing Foreman and/or Project been performed. Engineer ANCHORING Not applicable to this site. Deadman anchors used. _ Concrete pad. Installing Contractor Soil and pavement overburden will hold down tank (reference PEI/RP 100), 570 Oakwood Pond Note:This rhecklist includes certain key steps In the proper fake Zurich IL 60047 installation of the ACT-100-Urs'tank and b Intended only as an aid to task Installers who are knowtedgab-e and experienced to Phone:847438-8265 underground tank imtallatlon. Compliance herewltb does not Fax:847-x78.9766 oaenar4y meet the requirements of&U applicable federal,sum and -oral Iawt,retu-adorn stud ordldaneea concerning tank Installation.