Laserfiche WebLink
HANDLING & STORAGE <br /> 2.1.11.2. Chock with sandbags. Figure 2-3 <br /> 2.1.11.3. If high winds are anticipated,tie the tank Liking from Truck with Tank Rotated <br /> down to prevent damage.Do not use <br /> wire ropes or chains,and do not place <br /> straps over collars or reservoirs. <br /> 2.1.11.4. When the tank must be rolled for air/soap <br /> test,roll only on shipping pads or smooth <br /> surface free of protruding rocks or hard <br /> objects. Ensure fittings and/or collars do <br /> not come in contact with the ground. use all lugs straight up on truck to offload tank. <br /> 2.1.11.5. Protect collars from water accumulation <br /> Lifting from Truck/Ground with Tank Upright <br /> in freezing conditions or tank damage <br /> may occur. &ma�60* <br /> — <br /> 2.2. To Avoid Tank Damaae <br /> 2.2.1. Do not allow tank to rotate or swing during <br /> unloading. <br /> 2.2.2. Do not use chains or cables around tanks. <br /> 2.2.3. Do not allow metal hardware to contact the <br /> tank. <br /> 2.2.4. Do not allow fittings,collars,manways, f 1 <br /> reservoirs,or any accessory to contact <br /> ground during rotation. Applies to Both 1&2 <br /> 2.2.5. Do not drop tank. <br /> max 60° <br /> 2.3. Lifting Tanks <br /> r <br /> JL <br /> Do not stand on or under tank while tank is being <br /> Iifted.This could result in personal injury or death. <br /> 2.3.4. Rotate tank after unloading to upright <br /> 2.3.1. To lift the tank,always use the number of lift position for lifting into excavation. <br /> lugs indicated on the label adjacent to the 2.4. Lifting CSI Deadmen <br /> lift lugs.Apply equal tension to all lift lugs <br /> simultaneously.Slings may also be used to lift ! <br /> the tank.Refer to Supplemental Documents <br /> (Section 21)for additional information. Use only the anchor points when lifting and positioning <br /> Slings around the tank must be used if the CSI deadmen.Failure to do so could result in personal <br /> tank is to be handled in a non-level or angled injury or death. <br /> position. 2.4.1. Insure lifting equipment is rated to handle the <br /> 2.3.2. Tanks may be provided with guide lugs for load before lifting.For deadmen sizes and <br /> attachment of guide ropes during lifting and weights use Table 2-1. <br /> positioning operations. Do not use guide lugs <br /> for lifting. Table 2-1 <br /> 2.3.3. Identify the tank lift lug orientation and use Deadmen Anchors <br /> the appropriate method to lift the tank.Lift 12"x 12" 18"x 8" Pounds Kilograms <br /> tank as shown in Figure 2-3. <br /> Length(ft) Weight <br /> 12 1,655 750 <br /> 16 2,250 1,020 <br /> 18 2,550 1,156 <br /> 20 2,850 1,293 <br /> 14 1,686 765 <br /> 18 2,100 952 <br /> 22 2,500 1,134 <br /> s <br />