|
EQUIPMENT DESCRIPTION SUPPLIED
<br /> BY NOTES
<br /> STAGE I RISER —1 _3" _FIBERGLAS`S __ _
<br /> ISLAND MULTI PRODUCT DISPENSER PIPE (FRP)
<br /> A.0, SMITH RED THREAD 11 OR CON-TRACTOR 1 . MAIN VAPOR RETURN LINE IS 3" DIAMETER FRP,
<br /> AMERON DUALLOY 3000 USE 2" DIAMETER FRP PIPE BF-rWEEN MAIN RETURN
<br /> FRP PRODUCTLINES -2" FRP VAPOR 2" FRP VAPOR FILL RISER UNE AND DISPENSER,
<br /> RETURN LATERAL RETURN LATERAL 2 2" FIBERGLASS PIPE (FRP)
<br /> SEE STAGE 11 TANK GAUGE RISER A.O. SMITH RED THREAD 11 OR CONTRACTOR 2�
<br /> PIPING ISOMETRIC AMERON DUALLOY 3000 SLOPE VAPOR RE-TURN LINE NOT LESS THAN 1/8-
<br /> ------- PER FOOT AND NOT MORE THAN 1/4- PER FOOT
<br /> REINFORCED CONCRETE 3 8 FT, LONG DISPENSER HOSE- FROM DISPENSERS TO TANKS, NO AIR OR LIQUID
<br /> OR ASPHALT PAVEMENT DAYCO PETROFLEX 2000 OWNER
<br /> PEA GRAVEL-- FROM
<br /> ARE ACCEPTABLE,
<br /> BACKFILL 3" FRP MAIN VAPO R - 4 STAGE 11 VAPOR RECOVERY NOZZL.E--
<br /> 'TANK PAD RETURN LINE FROM EMCO WHEATON A-4001 (MPD-,-3 ONLY) OWNER
<br /> NEW OR EXISTIING MPD INSTALLATION DISPENSERS 3 FIBERGLASS PIPE AND FITTINGS TO BE A.0. SMITH
<br /> 5 HOSE RETRACTOR ASSEMBLY OR AMERON, FIT-TINGS MAY NOT BE MIXED,
<br /> MAIN VAPOR RETURN LINEQ'lj POMECO HIMAST 73" OWNER
<br /> 7 v CONTRACTOR 4� STEEL PIPE SHALL BE SCHEDULE 40 GALVANIZED,
<br /> 6 GASOLINE CONNECTION HOSE STEEL FITTINGS SHALL BE CLASS 150, USE GASOILA
<br /> b§t KaI5'
<br /> DAYCO
<br /> -PRODUCT 1 SOFT SET FOR PIPE JOINT SEAL,
<br /> 8 BREAKAWAY COUPLING—
<br /> ca LINES 3" FRP VAPOR EMCO, WHEATON COAXIAL. "SAFEBREAK" CONTRACTOR
<br /> 2
<br /> RETURN LINE 5, VAPOR RECOVERY PIPING SHALL BE LAID AND
<br /> Xyl MODEL #A4019--002
<br /> X CONTINUOUSLY SUPPORTED ON A 6" BEDDING OF
<br /> ----------
<br /> IPE NIPPLE
<br /> N
<br /> PEA GRAVEL, TRENCHES SHALL BE BACKFILLED
<br /> SCHEDULE 40 GALVANIZED CONTRACTOR COMPLETELY TO THE UNDERSIDE OF PAVING WITH
<br /> 11(o 2" FRP PCA GRAVEL.
<br /> 10 l STEEL UNION CONTRACTOR
<br /> VENT LINE NO PIPING SHALL BE SUPPORTED BY BLOCKS,
<br /> 0 11 1" STEEL UNION
<br /> 7 -777,77 PLANKS OR OTHER DEBRIS.
<br /> 12 1 1/2" X 3/4" GALVANIZED
<br /> xx 2" FRP VAPOR EXTRACTOR REDUCER NPT FEMALE X NPT MALE CONTRACTOR
<br /> ----------
<br /> RETURN LATERAL FITTING 6, CONNECT UNDERGROUND STAGE U PIPING TO MPD
<br /> CONTRACTOR--- -_ -- -,-
<br /> . 3" FRP VAPOR , Ij:ap 13 3/4'
<br /> DISPENSER PIPING DURING CONSTRUCTION FOR
<br /> RETURN LINE CON-TRACTOR
<br /> 8pl 8" 7" BOTH IMMEDIATE AND FUTURE USE,
<br /> t t SUBMERGED PUMP 5 3/4� STEEL UNION CONTRACTOR
<br /> CONTAINMENT SUMP
<br /> 36' SINGLE OR DUAL 16 STAGE 11 VAPOR RECOVERY NOZZLE-- 7, FOR SINGLE AND DUAL DISPENSERS, STUB UP THE
<br /> 11PI 7LIED
<br /> �TION �y
<br /> z_7
<br /> PF D I
<br /> L I�o
<br /> NES
<br /> DISPENSER EMCO WHEATON A-4005 (ADVANTAGE ONLY) OWNER PIPING AND CAP OFF WHEN PIPING WILL NOT BE
<br /> ____t1l) --------------- USED IMMEDIATELY,
<br /> 2" FR�P VENT LINES 17 12" SPACER HOSE-
<br /> OWNER
<br /> TO VENT RISERS ISLAND DAYCO PETROFLEX 2000 MODEL #7574 8. SAFETY BREAKS ARE TO BE INSTALLED,
<br /> PIPING TRENCH DETAIL NEW OR EXISTING SINGLE DUAL INSTALLAflON STAGE If PIPING ISOMETRIC 1B PUMP HOLD DOWN B-O- --F"-O--R—M—EX,----''----O,WNER--',
<br /> FRP PRODUCT LINES OR MORGAN
<br /> 9, T° 'TI F
<br /> G �RDQL QRL
<br /> NO SCALE
<br /> 19 DISPENSER DRIP BOX--WESTERN„
<br /> FIBERGLASS OWNER
<br /> AIR PRESSURE TEST THE STAGE Ir VAPOR RETURN
<br /> LINE FOR ONE HOUR AT 50 PSI, BRUSH A SOAP
<br /> STAGE 11 PIPING PLAN1 2 3 NOTE:
<br /> AND WATER SOLUTION ON EVERY FIl-TING AND
<br /> NO SCALE REFER TO DRAWINGS 15-CA 1/2 AND 2/2 FOR INSPECT FOR AIR BUBBLES,
<br /> EQUIPMENT DESCRIPTION NOT SHOWN THIS SHEET,
<br /> AFTER BACKFILLING THE TRENCHES, BUT BEFORE
<br /> PAVING AND SETTING THE DISPENSERS, PERFORM
<br /> -THE "PRESSURE DROP DURING FLOW TEST" AND
<br /> CCU7
<br /> THE "BLOCKAGE TEST" ACCORDING TO THE
<br /> -,
<br /> J7 REQUIRED LOCAL PROCEDURES,
<br /> RECORD BACK PRESSURES MEASURED DURING BOTH
<br /> TESTS WITH FLOW RATES OF 60 CFH AND 100 CFFl
<br /> ON THE DATA SHEETS PROVIDED,
<br /> BACK PRESSURE MAY NOT EXCEED 0,45 INCHES OF
<br /> C:l rand ran rond
<br /> WATER AT A FLOW OF 60 CFH OR 0.95 INCHES
<br /> rand ran
<br /> rand rand ESE 1=9 EM, OF WATER AT A FLOW OF 100 CFH. IF LIQUID
<br /> BLOCKAGE IS INDICATED, MAKE NECESSARY REPAIRS
<br /> (4
<br /> OR ADJUSTMENTS TO ELIMINATE THE BLOCKAGE,
<br /> "IN
<br /> REPEAT THE "PRESSURE DROP DURING FLOW TEST"
<br /> AND THE "BLOCKAGE TEST" AFTER COMPLETION OF
<br /> 0 THE YARD WORK AND INSTALLATION OF DISPENSERS.
<br /> SUBMIT COMPLETED TEST DATA SHEET'S TO THE
<br /> @6 FIELD ENGINEER FOR APPROVAL,
<br /> 171
<br /> to z
<br /> 5
<br /> 10. STAGE 11 FLEXIBLE CONNECTOR TO BE CONTAINED
<br /> WITHIN DISPENSER DRIP BOX. FOR SITES WITH NO
<br /> CONTAINMENT BOX, THE FLEXIBLE CONNECTOR MUST
<br /> BE ISOLATED USING AN ISOLATION SLEEVE.
<br /> 00
<br /> ELEVATION ELEVATION -
<br /> IL MPD-3 GI(BARCO ADVANTAGE MPDI NGLS & DUAL DISPENSERS
<br /> 1/2" 1 0"
<br /> X 30 FRP VAPOR
<br /> 3" FRP VAPOR
<br /> RETURN LINE RETURN LINE
<br /> ot
<br /> ISLAND DISPENSIR ISLAND & DISPENSER
<br /> ISLAND & DISPENSER
<br /> z z
<br /> uj uj
<br /> 0
<br /> a. CL
<br /> V) ------
<br /> "
<br /> "Y'. SIDE 2" ",RP VAPOR 3 2 FRP VAPOR, S I D E 3" FRF' VAPOR �o
<br /> 3/4CONDUIT RE RN LATERAL. RETURN LATERAL, RE-TURN LINE
<br /> FOR SPEAKER to ui
<br /> 3 1/8" 7' PRODUCT LINES 2" FRP VAPOR -'_
<br /> z z C) Z
<br /> "I-,\ Z uj
<br /> mo, 18 RE,T'URN LATERAL
<br /> P
<br /> PRODUCT LINES (A
<br /> ------- (1) 1" CONDUIT
<br /> FOR DISPENSER
<br /> 4 1 111 3/4!' 5_1
<br /> (1) 1- CONDUIT -1� 3/4- CONDUIT 14 (l)--l" CONDUIT
<br /> FOR DISPENSER FOR SPEAKER
<br /> "A" SIDEA7 SIDE
<br /> (J BOX SIDE)
<br /> (J B OX SIDE)
<br /> 4",
<br /> PIPING PLAN
<br /> PIPING PLAN PIPING PLAN
<br /> GILBARCO MPD—
<br /> GILBARCO ADVANTAGE MPD SINGLE & DUAL DIPENSERS
<br /> i/z,=v_o" 1/2"=l '-Op# rem. pxzam
<br /> 3" 42" 3"
<br /> Pp 42" 3'v 21"
<br /> 7" 7-1 7" B P OIL COO
<br /> 9 ZZ 15" 13 1 2" 18 ll � 5"
<br /> b 1 7/8" 8 5 1 STAGE 11 PIPING (15) @3
<br /> STAGE 11 PIPING
<br /> CONNECTION KIT CONNECTION KIT PIPING UNIONS
<br /> PIPING UNI
<br /> ONS [—A IBSIODX11] 1,0sigRETAIL MARKETING
<br /> BY ILRco '1� BY GILBA,RCO BY GILBARC0 k SIDE BY GILBARCO A
<br /> J_Box J-pox
<br /> J_Box DESIGN AND ENGINEERING
<br /> 0
<br /> 1 h, 200 PUBLIC SQUARE
<br /> F_ CLEVELAND, OHIO 44114
<br /> "VO
<br /> (l)--l" CONDUIT 15
<br /> FOR DISPENSER,/ " F' CALIFORNIA
<br /> 102
<br /> SAWCUT 4 1/4!'
<br /> STAGE 11 VAPOR RECOVERY
<br /> CONDUIT DIA, HOLIE FOR SAWCUT 4 1/4
<br /> A
<br /> FOR DISPENSER ANT VIRON( (OOT XIBLPE�) N�IR�
<br /> FRRY BTYEN FLEXIBLE
<br /> ENTRY BOOT (TYP,) 7"
<br /> U000,
<br /> to DWG. NO. : 15R--S2VR--CA 2/2
<br /> _T
<br /> BY: _AVCF
<br /> SCALE:_iz�nfm
<br /> z
<br /> DATE. 4--25--91 CHECKED BY:
<br /> —J DATE DWN CKD
<br /> STAG E II PIPING CONNECTION /A\ STAGE 11 PIPING CONNECTION STAG E I1 PIPING CONNECTION
<br /> GILBARCO MPD-3GILBARCO ADVANTAGE —------
<br /> zfiA MPD SINGLE & DUAL DISPENSERS
<br /> I" = v–o" _l_ = 1 , o" .,__._._.-_m.._,.-_...____.»_..._._.
<br /> 15S2VRCA
<br />
|