|
PROPERTY LINE 175.00' S88° OS' 30"W�
<br />r
<br />r .• r/rrr r r r••��• r •r•r�r �-•'-� r r rr�re -® o F�l o
<br />r r
<br />' EXISTING VENT RISERS TO -
<br />REMAIN. REMOVE ANY
<br />' RISERS NO LONGER IN USE
<br />NEW 2"0 SINGLE-WALL
<br />FIBERGLASS VENT LINE
<br />(SLOPE 1/4" PER FOOT
<br />MINIMUM UPWARD FROM
<br />' TANK)
<br />(2) NEW NDERGROUND DOUBLE-WALL /
<br />�FIBERGLA S STORAGE TANKS 10' DIAMETER
<br />& 8' RE INFORCED CONCRETE SLAB )
<br />(TANKS RNISHED BY THE DEALER
<br />ED BY THE DEALER'S
<br />3 GENERAL CONTRACTOR). ONE TANK
<br />IS TO BE A 16,000 GALLON TANK
<br />M DIVIDED INTO 10,000 GALLON REGULAR
<br />UNLEADED & 6,000 GALLON PREMUM
<br />UNLEADED. THE OTHER TANK IS TO BE//
<br />41A 15,000 GALLON TANK DIVIDED INTO//
<br />8,000 GALLON UNLEADED PLUS & //
<br />b177,000 GALLON DIESEL FUEL
<br />,000
<br />F
<br />t
<br />p / N
<br />V)
<br />O
<br />P Q
<br />In'ul
<br />LLJ
<br />:i
<br />u /x
<br />u
<br />3"0 VAPOR 4�
<br />RECOVERY
<br />1 MANIFOLD R�
<br />u�
<br />I
<br />'NEW 2"0 DOUBLE-WALL FIBER-
<br />GLASS PRODUCT PIPING LINES
<br />w/ 3"0 FIBERGLASS SECONDARY
<br />u(
<br />CONTAINMENT PIPE UP SOPE1J 4"
<br />PER FOOT MINIMUM UPWARD
<br />FROM TANKS) (TYPICAL)
<br />M.W.
<br />b
<br />E'tiS�NG t0 R
<br />\O
<br />EXISTING EASEMENT & WATER SAN JOAQUIN COUNTY ENVIRONMENTAL HEALTH DEPARTMENT UNDERGROUND PIPING GENERAL NOTES
<br />WELL EQUIPMENT TO REMAIN REQUIRED INSPECTIONS.
<br />1. SHELL SERVICE STATION SPECIFICATIONS ARE TO BE FOLLOWED
<br />FOR ALL WORK PERFORMED AT THIS SITE
<br />ALL APPOINTMENTS FOR INSPECTIONS MUST BE MADE AT LEAST 48 HOURS IN ADVANCE 2. ALL WORK, INCLUDING PLUMBING AND ELECTRICAL, SHALL BE
<br />FOR THE FOLLOWING: PERFORMED IN ACCORDANCE WITH LOCAL ADOPTED BUILDING
<br />CODES AND SUPPLEMENTARY ORDINANCES, ALL AS DIRECTED BY
<br />--' - - PRIMARY AND SECONDARY TANK(S) SHALL BE TESTED PNEUMATICALLY AT 3-5 P.S.I. COMPANY REPRESENTATIVE.
<br />FOR ONE HOUR; ONE-HALF HOUR FOR PRIMARY TANK AND ONE-HALF HOUR FOR 3. CONTRACTOR IS TO VERIFY ALL DIMENSIONS AND CONDITIONS AT
<br />SECONDARY TANK. DOUBLE WALLED TANKS ARE EXEMPT IF ANNULAR SPACE IS THE SITE. NOTIFY COMPANY REPRESENTATIVE OF ANY DISCREPANCIES
<br />EXISTING CATCH BASIN TO BE I
<br />RETROFITTED TO INCLUDE NEW
<br />1.STREAMGUARD" CATCH BASIN
<br />OIL/SEDIMENT FILTER TYPE 11-0.
<br />O (TYPICAL OF 4 CATCH BASINS)
<br />- - _ (FURNISHED & INSTALLED BY THE
<br />--
<br />----------- ----------- - - -- STATION DEALER'S CONTRACTORS)
<br />-(
<br />EXISTING UNDERGROUND II
<br />WASTE OIL TANK &
<br />CONCRETE SLAB TO REMAIN II '
<br />it
<br />II �
<br />11
<br />I O
<br />P51
<br />,d 11 EXISTING CANOPY
<br />GPq0N�p,�N I I TO REMAIN '
<br />ZO P II f
<br />III I
<br />E
<br />GON MPtJ
<br />Ey,S�O ZO V�
<br />5
<br />EXISTING CANOPY -
<br />COLUMN TO REMAIN
<br />NEW DIESEL DISPENSER -
<br />(FURNISHED BY THE DEALER
<br />& INSTALLED BY THE DEALE
<br />GENERAL CONTRACTOR
<br />NEW GUARD POST (FURNISHED -
<br />EXISTING CONCRETE DRIVE SLAB & INSTALLED BY THE DEALER'S
<br />GENERAL CONTRACTOR) (TYPICAL
<br />�p TO BE REMOVED .& REPLACED OF 20)
<br />II '
<br />K'Cq w/ NEW 6" REINFORCED
<br />F CONCRETE DRIVE SLAB -SLOPE II �
<br />T ENTIRE SLAB TO DRAIN TO NEW
<br />EXSTNG�ANGPY COLUMN TO II
<br />2 �S REMAIN (TYPICAL OF 2) CATCH BASIN. II
<br />NEW 2"0 SINGLE-WALL FIBERGLASS
<br />/ �O OF,yry VAPOR RECOVERY PIPING (SLOPE II
<br />1/4' PER FOOT MINIMUM UPWARD
<br />4 FROM TAN D II
<br />D I I
<br />4 ° NEW 2"0 DOUBLE-WALL FIBERGLASS II
<br />R - 4 PRODUCT PIPING LINES w/ 3"0
<br />-VR-O FIBERGLASS SECONDARY CONTAINMENT II
<br />O Tp O PIPE (SLOPE 1/4" PER FOOT MINIMUM
<br />+ II
<br />4\ R+ UPWARD FROM TANKS) (TYPICAL)
<br />]]]] e 4 O I% EXISTING 10" STORM DRAIN
<br />�4 O I °\. a 8 I 4 II PIPE TO REMAIN
<br />° N 3 x 2" REDUCERI- 0
<br />° P - FIIQING (TYPICAL) SEE.1 I1
<br />4.DE IL THIS PAGE
<br />°4 e°I NEW 24" SQUARE CATCH BASIN II
<br />4 w/ TRAFFIC RATED GRATE &
<br />xI- \ .I SAND/GREASE TRAP PER CITY II
<br />OF LODI STANDARD PLAN #205
<br />/ O..I4 a .' e (FURNISHED & INSTALLED BY I I
<br />THE STATION DEALER'S II EXISTING STORM DRAIN-
<br />- °_ _ ! - - - - _ _ 4 _ CONTRACTORS) MANHOLE TO REMAIN
<br />1----J/_Yq_---1
<br />NEW 3"0 SINGLE -WALL -
<br />FIBERGLASS VAPOR
<br />RECOVERY PIPING (SLOPE
<br />1/4" PER FOOT MINIMUM
<br />UPWARD FROM TANK)
<br />0
<br />_'_II-- -
<br />I _ ---------------
<br />_ _ - - - Z = =
<br />R=
<br />.O O O
<br />I'.
<br />° T
<br />4 e
<br />a.4 °
<br />(1 e
<br />EXISTING L
<br />TO REMAIN
<br />B]
<br />I
<br />-----KEIT
<br />EXISTING UNDERGROUND
<br />SANITARY SEWER LINE
<br />TO REMAIN
<br />w
<br />N
<br />RELOCATED "DRESSER WAYNE" 3 -PRODUCT Q
<br />GASOLINE DISPENSER w/ CARD READERS,
<br />3 -HOSES EACH SIDE, & BALANCE SYSTEM r
<br />(INSTALLED BY THE DEALER'S GENERAL
<br />CONTRACTOR) (TYPICAL OF 4 DISPENSERS) I�
<br />i' 30" E Q /
<br />l
<br />_ r r �� r r •�•r- - - �r�r�•
<br />EMAN_
<br />71m�7 NOTE! ALL EXISTING ITEMS ARE TO REMAIN
<br />0 5 10 15 UNLESS NOTED OTHERWISE.
<br />GRAPHIC SCALE
<br />+ UNLEADED PLUS
<br />D DIESEL
<br />I I NEW CONCRETE
<br />a
<br />© SHELL OIL COMPANY, ALL RIGHTS RESERVED 1995.
<br />MONITORED USING EITHER PRESSURE OR VACUUM TESTING. (ALL EXTERNAL CONNECTIONS
<br />BETWEEN SITE CONDITIONS AND INFORMATION SHOWN ON DRAWINGS,
<br />SHALL BE SOAP TESTED WHILE UNDER PRESSURE).
<br />PRIOR TO COMMENCING WORK.
<br />PRESSURE PIPING SHALL BE HYDROSTATICALLY TESTED TO 1509 OR PNEUMATICALLY TESTED
<br />4.
<br />ALL BACKFILL OF UTILITY TRENCHES TO BE CLEAN WASHED SAND.
<br />TO 1109 OF MAXIMUM ANTICIPATED SYSTEM PRESSURE BUT NOT LESS THAN 5 LBS.
<br />5.
<br />PIPING: A.O. SMITH RED THREAD 11 DOUBLE-WALL (PRODUCT).
<br />PER SQUARE INCH AT THE HIGHEST POINT OF THE SYSTEM FOR A MINIMUM OF 20 MINUTES.
<br />SINGLE-WALL (VENT/VAPOR).
<br />ALL LINES OTHER THAN PRESSURE PIPING SHALL BE PRESSURE TESTED AT NOT LESS THAN
<br />6.
<br />CONTRACTOR SHALL PROVIDE A COMPLETE FUNCTIONING FUEL
<br />3 P.S.I. AND NOT MORE THAN 5 P.S.I. FOR A MINIMUM OF 20 MINUTES AND SOAP TESTED
<br />DISPENSING SYSTEM MEETING THE LETTER AND INTENT OF THESE
<br />WHILE UNDER PRESSURE.
<br />PLANS AND SPECIFICATIONS.
<br />CONTAINMENT SUMPS SHALL PASS A 24 HOUR LEAK TEST.
<br />7.
<br />TANKS: 2-15,000 GALLON XERXES UNDERGROUND DOUBLE-
<br />WALL FIBERGLASS TANKS (TANKS 10' DIAMETER)
<br />OVERFILL PROTECTION SHALL BE CAPABLE OF DRAINING LIQUID BACK INTO FUEL TANKS.
<br />8,
<br />INSTALL B" REINFORCED CONCRETE SLAB OVER TANKS, SET MANHOLE
<br />MONITORING SYSTEM SHALL PASS A FUNCTIONAL TEST. THE FUNCTIONAL TEST SHALL CONSIST
<br />COVERS 1 1/2" ABOVE SLAB. GRADE TO DRAIN.
<br />OF THE ACTNATION OF THE ALARM VIA THE MONITORING PROBES/SENSORS.
<br />9,
<br />ALL FITTINGS AND OPENINGS SHALL BE SECONDARILY CONTAINED
<br />FINAL INSPECTION AND APPROVAL TO OPERATE WILL BE GRANTED AFTER THE ABOVE
<br />PER TANK MANUFACTURERS SPECIFICATIONS.
<br />REQUIREMENTS ARE SATISFIED AND A HARD COPY OF THE PRECISION TEST IS SUBMITTED
<br />10.
<br />ALL FILL BOXES TO BE 5 GALLONS MINIMUM & WATERTIGHT,
<br />TO INSPECTOR AT SITE.
<br />1" ABOVE SURFACE. (TYPICAL FOR PHASE i VAPOR RECOVERY)
<br />THE CONTRACTOR'S APPROVED PRINTSET OF THE UST INSTALLATION SHALL BE KEPT AT THE JOB SITE AND
<br />11.
<br />ALL MANHOLE COVERS TO BE WATERTIGHT.
<br />MUST BE SHOWN TO THE INSPECTOR UPON REQUEST. IN ADDITION, THE LOCAL FIRE DEPARTMENT SHALL
<br />APPROVE UST INSTALLATION PRIOR TO COMMENCEMENT OF WORK. 12,
<br />IF YOU NEED FURTHER ASSISTANCE, OR WISH TO SCHEDULE AN APPOINTMENT TO DISCUSS THE PLAN REVIEWI3.
<br />INSTALL 4-3/4 H.P. SUB -PUMPS WITH A.P.I. DETECTORS,
<br />INSTALL 4-2"0 DOUBLEWALL FIBERGLASS UNDERGROUND PRODUCT
<br />OR FIELD INSPECTION, PLEASE CONTACT OUR UNDERGROUND STORAGE TANK STAFF AT (209) 463-3427.
<br />LINES WITH PRESSURE MONITOR (FOR QUICK SHUT -DOWN), SEE
<br />EQUIPMENT LIST & SPECIFICATIONS FOR COMPLETE EQUIPMENT
<br />LISTING. ATTACH LIQUID PROBE LEAK MONITOR, WITH PIPING SUMP
<br />TO TANKS.
<br />I
<br />14.
<br />INSTALL 1-3"0 UNDERGROUND SINGLE-WALL FIBERGLASS VAPOR
<br />RECOVERY LINE, MANIFOLD FROM MULTI -PRODUCT DISPENSERS
<br />LJ
<br />TO REGULAR UNLEADED TANK.
<br />0
<br />15.
<br />INSTALL 2-2"0 UNDERGROUND SINGLEWALL FIBERGLASS VENT
<br />LINES (ONE FROM EACH TANK TO VENT RISERS.)
<br />-_
<br />SLOPE 1/4" PER FOOT MINIMUM BACK TO TANKS.
<br />16.
<br />SLOPE ALL NEW PRODUCT/VAPOR RECOVERY PIPING 1/4"
<br />PER FOOT MINIMUM BACK TO TANKS.
<br />O
<br />Z
<br />17.
<br />EXCAVATION FOR TANKS SHALL BE PER OSHA REQUIRMENTS.
<br />18.
<br />PROVIDE DEADMEN & STRAPS PER SHELL STANDARDS.
<br />'
<br />pC)
<br />19.
<br />PROVIDE TANK SHORING. (NOTE, 10' DIAMETER TANKS)
<br />1
<br />M
<br />20.
<br />GENERAL CONTRACTOR SHALL FURNISH & INSTALL DEADMAN
<br />HOLD DOWNS FOR ALL TANKS IN ACCORDANCE WITH DETAILS
<br />r
<br />!�
<br />ON TANK DRAWINGS. IT IS CRITICAL THAT YOU MEET THE CROSS
<br />SECTIONAL DESIGN & REINFORCEMENT REQUIREMENTS. IF YOU
<br />W
<br />W
<br />ELECT TO USE PRE -FABRICATED CONCRETE DEADMAN HOLD DOWN
<br />Z
<br />UNITS, SHELL REQUIRES ENGINEERING CALCULATIONS TO CONFIRM
<br />THAT SYSTEM IS EQUAL TO SHELL'S DESIGN.
<br />J
<br />W i
<br />21.
<br />ALL TESTING REQUIREMENTS (TANKS, LINES, BLOCKAGE TEST,
<br />H
<br />PRESSURE DECAL, CALIBRATION, ETC.) SHALL BE THE RESPONSIBILITY
<br />cr.
<br />OF THE GENERAL CONTRACTOR & INCLUDED IN BASE BID, NO
<br />w
<br />LL
<br />f
<br />F
<br />EXCEPTIONS.
<br />0
<br />(
<br />22.
<br />JTH-LINE PRESSURE MONITOR NOT REQUIRED
<br />IL
<br />CITY OF LODI
<br />H�
<br />FIRE DEPARTMENT NOTES
<br />1.
<br />ALL UNDERGROUND STORAGE TANKS TO COMPLY WITH SAN JOAQUIN
<br />Z'
<br />COUNTRY ENVIRONMENTAL HEALTH & CITY OF LODI.
<br />2.
<br />PERMITS TO INSTALL UNDERGROUND TANKS SHALL BE OBTAINED FROM
<br />THE FIRE DEPARTMENT.
<br />3.
<br />EMERGENCY SHUT-OFF VALVE TO BE CLEARLY LABELED.
<br />4.
<br />NO SMOKING SIGNS TO BE CLEARLY VISIBLE.
<br />•��
<br />5.
<br />BUILDING PERMIT MAY BE ISSUED WITHOUT ANY FURTHER ACTION BY
<br />r
<br />THE FIRE DEPARTMENT.
<br />I
<br />6.
<br />NO FIRES SHALL BE PERMITTED TO BURN ON THE CONSTRUCTION
<br />SITE FOR ANY PURPOSE. THE USES OF DEVICES. OR TOOLS PRODUCING
<br />A FLAME WHEN USED IN AN APPROVED MANNER AND NECESSARY FOR
<br />THE CONSTRUCTION OF THE BUILDING WILL BE PERMITTED,
<br />I LEGEND
<br />7.
<br />WHEN EXPOSED TO PROBABLE VEHICULAR DAMAGE DUE TO PROXIMITY
<br />f NEW 2"0 DOUBLE-WALL FIBER
<br />TO ALLEYS, DRIVEWAYS OR PARKING AREAS, ABOVEGROUND GAS
<br />GLASS PRODUCT PIPING LINES
<br />METERS, REGULATORS, AND PIPING SHALL BE SUITABLY PROTECTED.
<br />w/ FIBERGLASS SECONDARY
<br />CONTAINMENT
<br />ANMENT PIPE (SLOPE 1/4"
<br />8
<br />COMMERCIAL DUMPSTERS AND CONTAINERS WITH AN INDIVIDUAL
<br />PER FOOT MINIMUM UPWARD
<br />I
<br />CAPACITY OF 1.5 CUBIC YARDS OR GREATER SHALL NOT BE STORED
<br />FROM TANKS)
<br />OR PLACED WITHIN 5 FEET OF COMBUSTIBLE WALLS, OPENINGS, OR
<br />COMBUSTIBLE ROOM EAVES LINES UNLESS DUMPSTERS AND CONTAINERS
<br />°_
<br />ARE PROTECTED BY AN AUTOMATIC SPRINKLER SYSTEM.
<br />NEW UNDERGROUND SINGLE-
<br />ALL CONTAINERS IN WHICH COMBUSTIBLE TRASH, WASTEPAPER, OR
<br />WALL FIBERGLASS VENT/VAPOR
<br />RUBBISH IS KEPT OR STORED SHALL BE MADE OF METAL AND EQUIPPED
<br />p /
<br />LINES 2"0 OR 3"0 (SLOPE 1/4"
<br />WITH ATIGHT-FITTING METAL LID WHEN LOCATED WITHIN A BUILDING OR
<br />O//
<br />PER 12' MINIMUM UPWARD FROM
<br />ADJACENT TO A BUILDING.
<br />TANK). PIPING TO BE 3" AFTER
<br />MANIFOLD OF THE VAPOR
<br />9.
<br />APPROVED NUMBERS OR ADDRESSES SHALL BE PLACED IN SUCH A
<br />RECOVERY LINES.
<br />POSITION AS TO BE PLAINLY VISIBLE AND LEGIBLE FROM THE STREET
<br />OR READ FRONTING THE PROPERTY. SAID NUMBERS SHALL CONTRAST
<br />WITH THEIR BACKGROUND AND BE OF THE MINIMUM HEIGHT AS LISTED
<br />VR VAPOR RETURN
<br />IN THE FOLLOWING TABLE,
<br />DISTANCE TO BUILDING ADDRESS SIZE HEIGHT
<br />MEASURED FROM BACK OF WALK
<br />R REGULAR UNLEADED
<br />25 FEET 3 INCHES
<br />26-40 FEET 5 INCHES
<br />41-55 FEET 9 INCHES
<br />P PREMIUM UNLEADED
<br />I
<br />OVER 55 FEET 12 INCHES
<br />l
<br />_ r r �� r r •�•r- - - �r�r�•
<br />EMAN_
<br />71m�7 NOTE! ALL EXISTING ITEMS ARE TO REMAIN
<br />0 5 10 15 UNLESS NOTED OTHERWISE.
<br />GRAPHIC SCALE
<br />+ UNLEADED PLUS
<br />D DIESEL
<br />I I NEW CONCRETE
<br />a
<br />© SHELL OIL COMPANY, ALL RIGHTS RESERVED 1995.
<br />
|