Laserfiche WebLink
T 07/03/2003 13:29 209832F'52 WRIGHT ENVIRONMr-',ITAL PAGE 06 <br /> • V <br /> FUEL DISPENSING STATION <br /> SECONDARY CONTAINMENT PIPING, TEST PROTOCOL <br /> TANK PIPING Si MIPS/UNDER DISPENSER CONTAINMENT SUMPS <br /> BUSINESS NAME: .TS <br /> LOCATION/ADDRESS: / <br /> 0 1-ft 0 <br /> PHONE/FAX: <br /> OWNER/OPERATOR NAME; <br /> SCHEDULED TEST DATE.- <br /> PERMITTING AGENCY: <br /> INSPECTOR: <br /> PHONE: FAX: <br /> Wright Environmenal Services, Inc. <br /> General Contractor, Lie. No. 651501 A, B,$az TMat <br /> Ph 209-833-0758 Fax 209-832-5152 <br /> 1. Clean sump of all loose debris and other material, <br /> Separate "initial wash water" from -test water" in labled and separate F;3 gal. <br /> drums <br /> 2. Inspect all penetrations into sump for damage too or missing test boots <br /> • electrical. product, vapor (make note by sump No.) <br /> 1. Repair and reseal penetrations from inside sump as may be required: <br /> Clean ail penetrations removing scale and surface irreZ'ularities <br /> Bostic sealant is best for scaling around penetxat' <br /> • Disconnect piping and or remove dispense; if required to slip replacetnen t boats <br /> into place over priman;product line and over secondary containment pipin„ <br /> • Install split test boots as needed <br /> Is Install spacers in test boots as required. <br /> 4. Inflate secondary containment pipe to mfg. recommended test pressure (3-3 psi). <br /> 3. Allow pressure to stabilize for a few minutes and verify correct test pressure. <br /> 6. Record date. start time and test pressure on sump wall or cover for tach test point <br /> 7. Soap test all test boots inspecting for bubbles/leaks. <br /> 3. Record any change in pressure after one hour, test passes of pressure does no-. drop <br /> below 3-psi in 1 hour. <br /> NOTE: <br /> Secondaz­ containtnent pI- Inz _est 5110uld be ,;otr.pieted before starting lake tesi oz Burr nc s I. <br /> e:i11 that conduit oer,e:raiicns are not lower than highest ..7roduct line penexai il=s <br /> (conduits do not seal), If such a condition exists, seal conduit tittings and penetration� with <br /> 'de lcompatiGie ;eali m ,3(�S;- C) prior .o staving lake test of sump :he :est': <br /> rev I i-�6-02 5EC0NDARY CvNT-aZ4ivIENT PIP!NG <br />