Laserfiche WebLink
- 1 <br /> Page 1 of 2 <br /> CONDITIONS FOR PERMIT N-8600-1-0 E: 10/3112016 <br /> LEGAL OWNER OR OPERATOR: ATC ASSOCIATES INL � <br /> MAILING ADDRESS: 17 LONE PALM AV <br /> MODESTO. CA 9535ft <br /> LOCATION: 4075 E MAIN ST <br /> STOCKTOK CA <br /> INSPECT PROGRAM PARTICIPANT: NO <br /> EQUIPMENT DESCRIPTION: <br /> SOIL REMEDIATION PROJECT SERVED BY A 0.75 MMBTU/HR MAKO INDUSTRIES MODEL THERMCAT 250 <br /> NATURAL GAS-FIRED THERMAL/CATALYTIC OXIDIZER <br /> CONDITIONS <br /> 1. {1420} The soil remediation system shall be maintained in proper operating condition at all times. [District Rule 2201] <br /> 2. {15}No air contaminant shall be discharged into the atmosphere for a period or periods aggregating more than three <br /> minutes in any one hour which is as dark as,or darker than,Ringelmann 1 or 20%opacity. [District Rule 4101] <br /> 3. {98} No air contaminant shall be released into the atmosphere which causes a public nuisance. [District Rule 41021 <br /> 4. {14} Particulate matter emissions shall not exceed 0.1 grains/dscf in concentration. [District Rule 4201] <br /> 5. Only natural gas shall be used as auxiliary fuel for the combustion of VOC. [District Rule 22011 <br /> 6. {1462} The minimum operating temperature for the combustion chamber of the thermal oxidizer shall be maintained <br /> at or above 1400 degrees F. [District Rule 22011 <br /> 7. {1464} The minimum operating temperature for the combustion chamber of the catalytic oxidizer shall be maintained <br /> at or above 600 degrees F. [District Rule 2201] <br /> 8. {1469} The thermal/catalytic oxidizer shall be equipped with an operational temperature gauge to indicate the <br /> temperature of the combustion chamber. A continuously recording device shall be utilized to indicate the combustion <br /> chamber temperature during operation. [District Rule 22011 <br /> 9. {1470} The soil remediation system shall not be operated unless the combustion chamber is at or above minimum <br /> operating temperature. The system shall automatically terminate operation if the temperature drops below the <br /> minimum operating temperature. [District Rule 22011 <br /> 10. The total VOC emissions,measured as methane, from the soil remediation system served by the thermal <br /> oxidizer/catalytic oxidizer shall not exceed 14.8 pounds in any one day. [District Rule 2201] <br /> of the <br /> 11. The emissions from the combustion of natural gas 0.00285 Ib-SOx/MMBtu, 0.0076 Ib PM10/MMBtu,hO 084 lb-CO/Mall not exceed MBtu or following0055 lb-VOC/MMBtu. [District Rule <br /> 22011 <br /> 12. The control efficiency for this thermal/catalytic oxidizer shall not be less than 99%. [District Rule 22011 <br /> 13. {1413} Sampling ports adequate for extraction of grab samples,measurement of gas flow rate,and use of an FID,PID, <br /> or other District-approved VOC detection device shall be provided for both the influent and the effluent gas streams. <br /> [District Rule 108 11 <br /> trol <br /> y requirements shall be demonstrated <br /> 14. sampling both gthe influent and the ecompliance with ffluent gas gas streams with ssion rate and nan FID,PID,or other District-approved sVOC detection <br /> device. [District Rule 108 11 <br /> 15. Sampling to demonstrate ongoing compliance when the soil remediation operation is served by thermal oxidizer or the <br /> catalytic oxidizer shall be performed at least once per month. [District Rule 10811 <br /> xaew.to . sxatstnsex-ereoo¢s <br />