Laserfiche WebLink
e Checklist <br /> Month/Year: 06 <br /> Station Name: Y � <br /> Address: 4 3 75 ! t <br /> Coaxial/2-Point Phase I and BalancePhase II-Vapor Recovery Systems Facility44 <br /> This form was designed for use at stations with inspection turned up equipment defects or other issues requiring further action. related to the noted repairs with the Log. Keep these records <br /> Coaxial or 2-Point Phase I with Balance Phase II Record descriptions of the noted defects and repairs on the Daily Repair Log. "accessible in the Operations&Maintenance Manual for inspection <br /> vapor recovery systems. Place aCheck mark in Record your initials at the bottom of the form after completing each day's by the Air Pollution Control District for a period of at least two years. <br /> each box where your inspection revealed no inspection. Keep copies of work orders and/or equipment part receipts <br /> problems,and an"X"in each box where your / <br /> ✓✓� J ,.� o Month <br /> (else TRAFFIC CONES and SAFETY VESTS) I 112 3 4-1-5 6 17J-81 10 11 12 1311411511-611711811 9 20 21 22 23 24 25 26 27 28 29 30 31 <br /> TANK AREA <br /> 1,Vent line PV valve(s)-present,.yellow sticker,no vapor shadows ""� ✓ ,J✓� ✓ `� <br /> z-Spill containers-clean and dry ✓✓ ✓ ✓t/ <br /> :t,Spill container drains-operative and closed,chain attached(if applicable) ✓ ✓ ✓✓ ✓ <br /> a.Vapor caps-gaskets present&tight,caps not missing,broken orloose ✓ ✓ <br /> s.Vapor adapters-tight on riser,dry break poppet is not missing/damaged /ti/✓ t/ IV <br /> s. Fill caps-gaskets present and tight,caps not missing broken or loose t! ✓+� c% <br /> r. Fill adapters attached tightly to riser,inside gasket not missing or tom <br /> ti, Fill tube(coaxial spring-loaded)present,round,spring not broken or sagging ✓� V✓ <br /> o.Coaxial gasket-in place,sealing vapors ✓ ✓✓✓ +/ ✓ <br /> 1 o. Fill tube-(2-Point)present,round <br /> DISPENSER AREA <br /> >1.Air district decals-legible operating instructions,correct complaint phone# V f ✓ <br /> 12. Hoses-CARS-approved,no kinkslteanvsilts,LRD installed correctly ✓ ✓ ✓ ✓ <br /> 13. Breakaways-CARS-approved,no liquid stain/dust buildup ✓ ✓✓ ✓ <br /> 14. Nozzles-CARB-approved,has all clamps,swivets work smoothly,no Peaks ✓ ✓ ✓ ✓ <br /> 1s" Nozzle hold-open latches-present and operating correctly, �f +/ ✓ V <br /> 1 a.Nozzle bellows and faceplates-tight on nozzle,no tears/slits,good seal ti/' <br /> 17.Nozzle spouts-not loose,not out-of-round,have latch devices <br /> 16. Nozzle vapor valves-no vapor shadows emitting from nozzle V Ve ✓✓ <br /> 19. Hose Retractor-present with a 10"or less hose loop unless LRD present ✓ <br /> INSPECT AT LEAST ONCE PER WEEK <br /> 2o. Drain vapor hose to remove excessive gasoline rJ' <br /> INSPECTOR'S INITIALS: •s r <br />