Laserfiche WebLink
FUEL DISPENSING STATION <br /> SECONDARY CONTAINMENT PIPING, TEST PROTOCOL <br /> TANK PIPINGS SUNDER DISPENSER CONTAINMENT SUMPS <br /> BUSINESS NAME: <br /> LOCATION/ADDRESS- .-7'5D eC_ L p o e- 540 <br /> PHONE/FAX: Lq J <br /> OWNER/OPERATOR NAME: C <br /> SCHEDULED TEST DATE: ( -3 <br /> PERMITTING AGENCY: <br /> INSPECTOR: <br /> PHONE: FAX: <br /> Wright Environmenal Services,Inc. <br /> General Contractor,Lic. No. 651501 A, B, Haz Mat <br /> Ph 209-833-0758 Fax 209-832-5152 <br /> 1. Clean sump of all loose debris and other material; <br /> • Separate "initial wash water" from "test water" in Tabled and separate 55 gal. <br /> drums <br /> 2. Inspect all penetrations into sump for damage too or missing test boots <br /> • electrical,product, vapor(make note by sump No.) <br /> 3. Repair and reseal penetrations from inside sump as may be required; <br /> • Clean all penetrations removing scale and surface irregularities <br /> • Bostic sealant is best for sealing around penetrations <br /> • Disconnect piping and or remove dispenser if required to slip replacement boots <br /> into place over primary/product line and over'secondary containment piping <br /> • Install split test boots as needed <br /> • Install spacers in test boots as required. <br /> 4. Inflate secondary containment pipe to mfg. recommended test pressure (3-5 psi). <br /> 5. Allow pressure to stabilize for a few minutes and verify correct test pressure. <br /> 6. Record date, start time and test pressure on sump wail or cover for each test point <br /> 7. Soap test all test boots inspecting for bubbles/leaks.-- <br /> 8 Record any change in pressure after one hour, test passes of pressure does not drop <br /> .W. below 3-psi in 1 hour. <br /> NOTE. <br /> Secondary containment piping test should be completed before starting lake fest of sump(s). <br /> Venfy that conduit penetrations,are not, lower than highest`product line-penetration(s) <br /> (conduits do not seal), If such a condition exists, seal conduit fittings and penetrations with <br /> fiiel com sable sealani(BOSTTCFpnoftastartinglake test of siiinp the test.1 <br /> � P <br /> .y kid`""' SAY 'a2 -1.12�L ♦RL ��� ;y� � � `. .� Z� �3t�; .+t"'Y {�s4+ +wE 5 'i. Y' S <br />