Laserfiche WebLink
_ <br /> kisimportant k>follow the procedures and instructions inthis Before beginning the tank installation,read through <br /> manual in order <br /> Underground Storage Tank.Failure to follow these instructions with all safety precautions,codes and regulations.No instrupilytions <br /> will void the tank warranty and may cause tank failure,serious or procedures presented in this manual should be interpreted as <br /> personal injury,or property damage.The Xerxes warranty applies to put at risk any person's health or safety or to harm any <br /> to a tank installed according to these instructions.Since Xerxes property or the environment.Keep the Installation Manual <br /> does not control the parameters of any installation,our sole available at the installation to refer back to safety procedures as <br /> responsibility in any installation is that presented in our warranty. needed.The following definitions will serve as a guide when <br /> Use the Tank Installation Checklist for all Single Wall Tanks . reading the Installation Manual: <br /> Double Wall Tanks(DWT),Oil Water Separator(OWS)and Multi DANGER: <br /> Compartment Tanks(MCT)found inserted in this manual,as the <br /> installation proceedsRetain acopy of the checklist,along with any indicates immediate hazards which,if not avoided,will cause � <br /> deviation—authorization letters,certification etc.in your files and any death,serious personal injury wraignificantpmlperty <br /> other project files.Consult your Xerxes representative ordistributor <br /> for asupply u(additional checklist forms. � <br /> Comply with all applicable regulations and standards,such as: indicates hazards which,xnot avoided,could cause death, <br /> ° national,state and local construction,health,safety and serious personal injury or significant property <br /> environmental codes 1, CAUTION: <br /> * National Fire Protection Association standards(o.g.NFRA <br /> 30.30A&31) indicates hazards which,xnot avoided,may cause personal <br /> ° industry standard pmnioea(e.g. PB/RP1OU.AP| RP1O15& injury mrproperty <br /> ERA^DongkRighM Working in excavations is dangerous and is regulated by both <br /> For additional information,contact your state,county and city federal and state safely codes.Careless activity or operation of <br /> storage tank authorities,including health,fire orbuilding depart- equipment can cause severe personal injury ordeath. <br /> monts.and environmental agencies.All work must beperformed <br /> according 0nstandard industry practices and OSHA regulations. <br /> AXerxes requirement will never take precedence over Although Ne:Vrmai0n-/esi�andXemes t8nkoare0 oed.:8nB <br /> 0qVinVm8Vtimposed bvany�d8n8[�� � <br /> our|V:G|Cod��r mu3�b�t@�8nth�devanVn<�dmpp9durd8m8ge-'uhng <br /> regulation.|nall cases,any such requirement takes precedence delivery,unloading and handling onthe job site. <br /> over any provision ofthe Xerxes manual. Zt WARNING: <br /> Xerxes must authorize any variation to,ordeviation from,these <br /> instructions.This authorization must bemade inwriting,prior to The tanks are heavy and have mlarge surface area.The tanks <br /> the tank installation. will roll on sloped surfaces and can beblown about by the <br /> DEFINIlONS-Throughout thitext,these definitionswill~'r|y: wind.Uncontrolled movement wfthe tanks can cause death, <br /> ' <br /> ° Service fitting:efi#m ' <br /> fitting, nthe tank serious personal' �n�pn�m� damage.««wx �« ��' <br /> shell,which opens into the primary containment vessel, Before the tanks are unloaded orrelocated onthe job site: <br /> where the tank's contents are normally stored; * besure that all equipment usedholift the tanks iarated 0D <br /> ^ Monitor fitting:8fitting,located unthe tank shell,which handle the load(Refer to the installation supplement'Tank <br /> opens into the secondary tui tveoamiwhiohiath* Handling Data"for tank waigh0. <br /> normal monitoring location unthe tank. ° prepare the unloading and/or storage site bvremoving all <br /> For additional terminology,see Figure mohoanddebhoO'1. ' <br /> ° arrange for sandbags mtires Wbe used as chocks. <br /> Use the lifting|ug(a)when hoisting the tank.Donot wrap chain or <br /> LIFTING LUG SERVICE FITTING cable around the tank.Tanks larger than 12'OOUgallons have <br /> MANWAY WITH FITTINGS ONITOR FITTING multiple lifting lugs.Use all ofthe lugs b}move the tank.(See Fig. <br /> 1'1).Use guy ropes to guide the tank when needed. Donot move ` <br /> the tank byrolling. AM <br /> FIGURE 0-1 <br /> Kyou have any questions Vrencounter any situations not <br /> covered inthese installation instructions,contact the Xerxes <br /> Technical Service Department at01O-887'189U. FIGURE 1-1 <br /> ~ ~ <br />