COMPLIANCE INFO_2018 - Laserfiche WebLink

Home Browse Search

S A N,10 A Q U I N Environmental Health Department COUNTY -.___-. Underground Storage Tank Program InspectionReport Facility Name: Facility Address: Date: TIWANA GAS&FOOD 1210 E HAMMER LN, STOCKTON June 29, 2018 SUMMAk*-6F-VIQLATCONS (CLASS 1;CLASS If,of MINOR=Notice to Comply) ? Item# Remarks 301 HSC 25292.1 UST system is not operated to prevent unauthorized release, including spills and overfills. The 91 product STP sump contained approximately 30 gallons of fuel when inspector and service technician arrived on site. After speaking with the operator, he stated that the site has issues with the 91 product line and that are working on making the repairs. He also stated that they are no longer using the tank nor the lines because of an alarm on the 1-5-91 STP sump that was enable three days after they started using the tank. He stated that they stopped using the tanks as soon as the sensor went into alarm. The underground storage tank system shall be operated to prevent unauthorized releases. Immediately contact a certified contractor to make the needed repairs to the 91 product line and to remove the fuel that is inside the 91 product STP sump. This is a Class II violation. 309 CCR 2636(f)(1) Monitoring in sump/UDC failed to activate an audible and visual alarm or stop the flow product. The Bravo box float and chain in the 87 product in UDC 3/4 and 7/8, 89 product in UDC 7/8 sump failed to stop the flow of product at the dispenser when tested. All monitoring equipment shall be maintained to activate an audible and visual alarm or stop the flow of product at the dispenser when it detects a leak. The service technician adjusted the chain in UDC 1/2 for the 89 product, cleaned the float for UDC 7/8, 87 product and UDC 3/4 product and verified functionality. This is a repeat violation, Class II. 313 HSC 25290.1, 25290.2, 25291 Failure to construct, operate, and maintain primary containment as product-tight. approximately 30 gallons of fuel was found on the 91 product STP sump, indicating a leak in the primary piping. All primary containment for the UST system must be tight. Immediately have a properly licensed,trained, and certified contractor repair or replace the failed component under permit and inspection of the EHD. This is a Class II violation. 319 CCR 2635(b) No spill bucket, failed to contain five gallons, or failed to provide a means to keep it empty. The 91 product spill container is not equipped with a properly functioning drain valve. All USTs shall be equipped with a spill container that has a minimum capacity of five gallons and a drain valve that allows drainage of the collected spill into the primary container or provide a means to keep the container empty. Immediately contact a properly licensed, trained, and certified contractor to install an approved spill container under permit and inspection of the EHD. If a spill container can't be installed immediately,there is a possibility that the 91 product UST system may be red tagged to prevent fuel inputs. This is a Class II violation. Overall Inspection Comments: Complete and submit a copy of the Return to Compliance Certification form to the EHD with a statement documenting the corrective actions that have been or will be taken for each violation, and any supporting paperwork, by July 29th, 2018. Document reviewed: Monitoring system certification test results 2015, 2016 and 2017, secondary containment test results from 2017, employee training, response plan, monitoring plan and designated operator monthly inspection reports from June 2017, July 2017-June 2018. FA0003730 PR0231125 SCO01 06/29/2018 EHD 23-01 Rev.10/31/2017 Page 7 of 8 Underground Storage Tank Program OIR 1868 E. Hazelton Avenue I Stockton, California 95205 1 T 209 468-3420 1 F 209 464-0138 1 www.sjcehd.com