|
PLUMBING FIXTURE SCHEDULE Revisions
<br /> (nP}BALL VALVE FIXTURE DATA AND WATER CALCULATION
<br /> VACUUM RELIEF VALVE MARK TYPE MANUFACTURER AND MODEL NUMBER SUPPORT WASTE VT CW HW REMARKS
<br /> MARK DESCRIPTION NO, OF FIXT WFU 'S DFU 'S GW NW SEWER
<br /> Z., "// o 2
<br /> WATER AMERICAN STANDARD CADET FLpWWISE p1 WATER CLOSET FLUSH TANK
<br /> RIGHT HEIGHT ELONGATED BOWL, FLOOR ( ) 1 2.5 4.0 2.5 0 4.0 3
<br /> P7 PRESSURE
<br /> ASSIST PRESSURE ASSISTED FLUSH, 1.1 GPF MOUNTED 3 2" 1/2" -- 1.1 GALLONS PER FLUSH
<br /> W MODEL 2467.100 P2 LAVATORY 1 1.0 1'0
<br /> 1.0 0.8 1.0 0
<br /> FAUCET:AMERICAN STANDARD SELECTRONIC, MODEL#6055.204P3 MOP SINK 1 3.0 3.0 3.0 2.3 a
<br /> P2 LAVATORY AMERICAN STANDARD FLOOR 0.35 GPM PRESSURE COMPENSATING, VANDAL RESISTANT, 3.0 o
<br /> INSULATE ALL PIPING
<br /> LUCERENE (WHITE) 0355.012 MOUNTED 1-112" 1-1/2" 112" 1/2" NON-AERATED SPRAY, CR-P2 LITHIUM BATTERY OPERATED
<br /> INCLUDED. 7.5 SECONDS ERUNNING TINE, 0.044 GALLONS PER CYCLE P4 HAND SINK 1 1.0 1.0 0 0.8 1.0
<br /> IN ACCORDANCE WITH 6
<br /> SPECIFICATIONS. PROVIDE WITH MR-371 FAUCET, HOSE, HOSE BRACKET, MOP a
<br /> MOP SINK FLORESTONE FLOOR MR-374 LOK SEAL. P5 3 COMPARTMENT SINK 1 3.0 3.0 3.0 2.3 3.0 Z
<br /> UNION (TYP.) P3 BASIN MSR-2424 (MOLDED STONE) MOUNTED 3 2 112 1/2 ATTACHMENT ON FAUCET SHALL BE EQUIPPED WITH AN
<br /> E 7
<br /> ANTI-SIPHON ;z
<br /> VACUUM BREAKER P6 HAND SINK 1 1,5 2.0 1.5 1.1 2.0
<br /> T & P KOHLER FAUCET: AMERICAN STANDARD 7402.000 AND#972. COLOR TO BE 5
<br /> COUNTER
<br /> THERMAL EXPANSION TANK: AMTROL, RELIEF VALVE P4 MINI HAND SINK MODEL K6579 WHITE 3-HOLE CAST IRON TOP 1-1/2" 1-112" 1/2" 112" BRIGHT WHITE. PROVIDE WITH 0.5 GPM PRESSURE COMPENSATING FLOOR SINK 0 0 2.0 0 0.0 p•0
<br /> MODEL AST-5, OR EQUAL. INSTALL WITH SPLASH GUARD AERATOR. 93
<br /> m
<br /> PER MANUFACTURER'S WATER HEATER TOTAL WFU`S, DFU'S 12,0 rn G G
<br /> RECOMMENDATIONS & LOCAL CODE T REGENCY TENANTS CONCTRACTOR TO SUPPLY AND INSTALL SCULLERY SINK, 7.1 14.0 z ry � V 0
<br /> REQUIREMENTS. " P5 SCULLERY SINK MODEL 600S31515215 FLOOR o ,
<br /> MOUNTED INDIRECT 2" 314" 314" FAUCET t T& S) B266}AND TRIM. PROVIDE WITH 1,5 GPM PRESSURE MAIN DOMESTIC WATER SUPPLY 12 WSFU (COLD WATER) =T 11 GPM 4 N � O O
<br /> GC FURNISHED COMPENSATING AERATOR, SIZING BASE ON LATEST EDITI❑N 7 WSFU (HOT WATER) __=6 GPM
<br /> a L_ Ill
<br /> 2" WIDE, 20 GA. SHEET HAND SINK CPG 2016 TABLE A 103,1, CHART A z 0 00
<br /> METAL BAND, SECURE WITH SIDE ADVANCE 105,1 C1) 4 AT Q •ti co �.
<br /> P6 „ (PROVIDE SPLASH GUARDS PER HEALTH) PROVIDE WITH 0.5 GPM °�
<br /> COPPER T&P RELIEF RUN TO WALT_ FOR SEISMIC SPLASH MODEL NO. 7-PS-66 WALL HUNG 2 2" 314 314" w ro U ,
<br /> FULL SIZE TO MOP SINK BRACING WHERE STAINLESS STEEL PRESSURE COMPENSATING AERATOR. w �s E o � �
<br /> GUARDS = LA 2
<br /> 7
<br /> PER LOCAL CODE REQUIRED n V � .a N �
<br /> REQUIREMENTS FLOOR DRAIN CAST IRON BODY 6" DIAMETER NICKEL BRONZE"TYPE B"STRAINER, o w L
<br /> GALV. DRIP PAN FD-1 WITH TRAP "ZURN" MODEL#Z415"B" FLOOR 3„ 2" _ _ COMBINATION INVERTIBLE MEMBRANE CLAMP AND ADJUSTABLE S IJ co � � W
<br /> PRIMER MOUNTED COVER. PROVIDE WITH TRAP PRIMER TAP AND TRAP PRIMER TYPICAL FRICTION LOSSES
<br /> DRAIN VALVE 74 V)
<br /> Q
<br /> FLOOR SINK COMMERCIAL ENAMELING" WATER PRESSURE AT THE STREET(VERIFY IN FIELD) 100 PSI
<br /> COPPER DRAINS RUN FS 1 (SQUARE) MODEL#Z90$-3 -' 3" 2" _ 12"-12"TOP, 8" DEEP BODY, ALUMINUM DOME STRAINER,AND F-934 a Q
<br /> 6" TOP GRATE (FLUSH WITH SLAB FLOOR) ....
<br /> IN WALL & PUNCHED LENGTH OF DOMESTIC WATER SYSTEM TO THE FURTHEST RUN. 100 FT o
<br /> REFER TO ARCHITECTURAL WALL CLEAN
<br /> DRAWINGS FOR WATER HEATER OUT 1" ABOVE MOP WCO OUT ZURN MODEL#ZB-1443 -- WITH SQUARE POLISHED BRONZE ACCESS COVER AND FRAME EXISTNG WATER METER 5 PSI
<br /> PLATFORM FRAMING DETAIL SINK W/ AIR GAP - - z
<br /> FCO FLOOR CLEAN "ZURN" MODEL#ZN-1400 FLOOR SEE PLAN EXISTING BACKFLOW PREVENTER 10 PSI
<br /> OUT (ADJUSTABLE) MOUNTED FOR SIZE -- -- NICKEL BRONZE TOP EXISTING PRESSURE REGULATOR
<br /> $ PSI � � Z
<br /> 0
<br /> TOTAL LOSSES 23 PSI
<br /> THERMOSTATIC ZURN MODEL LFMMV 112" INLET/OUTLET SET SUPPLY TEM @ 110°F. (PROVIDE WITH m f
<br /> TMV-1 MIXING VALVE (OR APPROVED EQUAL) -- -- -- 112 -- ALL HAND SINKS AND LAVATORIES PRESSURE INSIDE THE BUILDING 60 PSI
<br /> 1/2" INTEGRAL BFP AND VACUUM BREAKER MOUNT ABOVE CEILING STATIC HEIGHT 10 FT N
<br /> TER HEATER (WH-1 ) ABOVE MOP SINK DETAIL y
<br /> 1 TP 1 TRAP PRIMER P1-500 WITH ADAPTER - __
<br /> SCALE: NONE NOTE:ALL PLUMBING FIXTURES AND ACCESSORIES ARE TO BE INSTALLED AND SUPPLIED BY CONTRACTOR. RESIDUAL PRESSURE; 25 PSI
<br /> w U
<br /> PRESSURE AVAILABLE FOR FRICTION LOSS 30.70 PSI
<br /> EQUIPM0
<br /> _
<br /> ENT SCHEDULE ALLOWABLE FRICTION LOSS PER HUNDRED FEET 30.7 PSI a
<br /> ITEM 4goFEsslaN�
<br /> DESCRIPTION GOLD WATER PIPE SIZING HOT WATER PIPE SIZING �� � D�� ����
<br /> o Ido. 34874
<br /> WATER HEATER: 'AO SMITH' DEN-30, 30 GAL, 9KW- (2) 4.5KW HEATING ELEMENTS WITH SIMULTANEOUS OPERATION, 240V13, 51 GPH @ 72°F TEMP RISE, 470LBS FULL, FLUSH TANK FLUSH VALVE FLUSH TANK FLUSH VALVE � Exp,
<br /> rune 30, zozo
<br /> PROVIDE WITH EXPANSION TANK AND INSTALL PER DETAIL. BELOW. PIPE DIA. GPM FIXTURE UNIT FIXTURE UNIT VELOCITY PIPE DIA. GPM VELOCITY
<br /> FIXTURE UNIT FIXTURE UNIT * �cHaNtC�y
<br /> ti
<br /> 1/2" 4.3 1 - - 6.2 1/2" CAM
<br /> 3.5 1 -- 5.0
<br /> NOTE PIPE MAY EXTEND AS WASTE 3/4" 12.3 7 - $.0 3/4" 7.5 3 -- 5,0
<br /> WATER HEATER ANCHOR SEISMICALLY GC SHALL VERIFY HEIGHT AND WIDTH OR COLUMN OR PARTITION AS
<br /> PER DTL.SHEET M2 OF WATER HEATER&NOTIFY PROJECT VENT. o
<br /> MANAGER IF CEILING CONDITION ON FLOOR PLAN. 1�� 1 9.6 20 6 8.0 1" 1 3 4 8 5 0 0
<br /> 3-518"x 20 GA METAL STUDS W15/8" REQUIRES ALTERATION_ PROVIDE CLEANOUT TEE WITH -- w
<br /> TYPE'X'GYP_BD.BOTH SIDES.TAPE, THERMAL EXPANSION TANK ON SHELF SCREWED COUNTER-SUNK ABS w
<br /> SAND SMOOTH&PREP TO ACCEPT 1 -1/4" 29.6 52 13 8.0 1-i/4" 19.6 20 6 5,p
<br /> ABOVE SINK PROVIDE 2"W 20 GA. PLASTIC PLUG:TAPERED-7HRHAD a
<br /> FINISH. m
<br /> METAL BAND SECURED O WALL FOR WITH TEE JOINT COMPOUND 1-1/2" 41,3 91 29 8.0 1 -1/2" 27,5 44 10 5.0
<br /> B"X 8"METAL ACCESS DOOR FOR SHUT SEISMIC BRACING PER CODE,SLE ALSO o
<br /> OFF VALVE,PAINTED TO MATCH WALL. DTL.ON MECHANICALS. w
<br /> LABELED"WATER SHUT-OFF" 1 A 1-112"x 1-112"x 918"MARLITE PLASTIC 2" 71.3 232 1 14 8.0 2" 46.4 1 13 41 5.0
<br /> SUPPLY LINE SHUT OFF VALVE A5 CORNER GUARD WHERE CLEANOUT TEE IS
<br /> 4
<br /> RECESSED IN WALL @ 60"A.F.F. ISO, CONCEALED IN A CHASE OR WATER HEATER FLOOR WI SHELF DRIP PARTITION,PROVIDE A ROUND 18 2-1/2" 119.6 477 361 8.0 2-1/2" 72,3 237 117 5.0 p
<br /> PAN BELOW GAUGE STAINLESS STEEL COVER CLEANOUT FACE SHALL BE WITHIN z
<br /> WITH BEVELED EDGES AND 4" „
<br /> T/z (2)3-518"x 20 GA METAL STUDS AT 6"x 16 GA METAL STUDS W!518"TYPE'X' FLATHEAD MACHINE SCREW. OF WALL SURFACE.PROVIDE 3 177.7 801 756 8.0 3" 1 15.6 456 340 5.0 w d'
<br /> 0
<br /> CORNERS GYP.BO.BATH SIDES,TAPE,SAND EXTENSION IF REQUIRED.
<br /> SMOOTH&PREP TO ACCEPT FINISH. 3-1/2" 205.6 984 981 8.0 =1/2" 141.2 593 489 5.0 W
<br /> FRP
<br /> a. G ff w I�
<br /> FLOOR SLAB. a� "
<br /> - CONCRETE HUB AT FLOOR Off 283.0 1625 1625 $.O 4" 186.7 860 828 5.0
<br /> CHEMICAL SHELF ABOVE - FRP ALL SIDES e 5 427.5 2948 2948 8.0 5
<br /> 284.1 1635 1635 5.0 s W
<br /> I
<br /> ALL SIDES 3-518"x 20 GA METAL STUDS W!518" RISER LENGTH 1, o
<br /> 6 676.3 6436 6436 8.0 6" 437.7 3046 3046 5.0 W N
<br /> TYPE'X'GYP.BD.BOTH SIDES,TAPE, AS REQUIRED a
<br /> SAND SMOOTH&PREP TO ACCEPT LONG SWEEP AT ENA D LINE OR COLD WATER VELOCITY NOT TO EXCEED 8 FEET PER SECONDHOT WATER VELOCITY NOT TO EXCEED 5 FEET PER SECOND
<br /> FINISH. z MCI
<br /> COMBINATION WYE AND EIGHTH
<br /> p J LO
<br /> BEND DIRECTION U
<br /> MOP&BROOM HOLDER IN RUN OF LINE. LO
<br /> OF FLOW3011
<br /> o
<br /> U
<br /> NOTE:ALL PLUMBING PIPING AND z
<br /> DRAINS LOCATED INSIDE OF WALLS TO - q W 0
<br /> DRAIN INTO MOP SINK w J
<br /> v 0 0
<br /> PROVIDE WCO WHERE SHOWN ON PLAN,AND ON SANITARY WASTE a
<br /> w
<br /> EXISTING WALL FAUCET!CONTROLS BRANCHES NOT SERVED WITH A FLOOR CLEANOUT:LOCATE ABOVE � W
<br /> @ 30"AF.F. FLOOR MOUNT MOP SINK FIXTURE FLOOD RIM WITHIN 4'OF FLOOR.CONSULT LOCAL CODES
<br /> FOR m
<br /> OTHER WOO REQUIREMENTS,
<br /> 0
<br /> a
<br /> w
<br /> WATER HEATER MOUNTING DETAIL WALL CLEANOUT DETAIL z
<br /> SCALE; NONE SCALE: NONE 304
<br /> w N
<br /> M
<br /> z
<br /> 4
<br /> LL.
<br /> z
<br /> PROVIDE CLEANOUTS IN TURNSlLN bISCHARGE INTO CENTER HOLE OF GRATE OF WASTE
<br /> z
<br /> OF PIPE.USE DWV PITTINGS IF SIZE i RECEPT[CALE WITH AIR GAP SUFFICIENT TO REMOVE
<br /> AIR INTAKE
<br /> IS LARGER THAN 1" TWO PIPE DIAMETERS
<br /> GRATE AND STRAINER.MINIMUM GAP= w
<br /> THREE COMPARTMENT SINK F180 DEGREE ELBOW BEHIND HACKSPLASH 5"ABOVE RIM w GRATE
<br /> FINISHED FLOOR
<br /> FLOOR DRAIN a Sheet Content
<br /> z
<br /> V SLOPE PIPE AS MUCH
<br /> 2"VENT --f`-
<br /> AS POSSIBLE IW PLUMBING I a
<br /> e.- TOWARD LEGEND AND NOTES
<br /> CLEANOUTS IN W2-
<br /> LARGER IN WALL DISCHARGE
<br /> c
<br /> ENDS OF PIPE CAULK OUTLET- a
<br /> 2 IMAKE CONNECTION TO
<br /> CLEANOUT O EQUIPMENTASFLOORREQUIRED M
<br /> MAKE PIPE MINIMUM ONESIZE
<br /> FLOW CONTROL FITTING
<br /> VERIFY WITH LOCAL RE RE IF/WHENUIREDocument Status
<br /> FLOOR SINK THAN EQUIPMENT CONNECTION, TRAP AND/OR VENT ARE REQUIRED
<br /> MINIMUM 314",USE"M"OR"L"HARD FOR THE LENGTH OF DRAIN PIPE INSTALLED
<br /> w
<br /> COPPER UP TO 1"AND TYPE DWV FOR
<br /> LARGIHR
<br /> plan chk after
<br /> ARRANGEMENT SHOWN IS SCHEMATIC.ADJUST TO
<br /> SUIT FIELD CONDITIONS OR MEET LOCAL CODE bidding permitDEEP SEAL"P"TRAP w
<br /> REQUIREMENTS.UTILIZE HUBLESS CAST IRON PIPE. ROUTE PIPE INCONSPICUOUSLY AND UNOBTRUSIVELY, HANG PIPE AS REQUIRED.DO
<br /> FITTINGS 0
<br /> AND CONNECTORS FOR SINK CONNECTIONS, NOT INSULATE INDIRECT DRAIN PIPE WHEN INSTALLED EXPOSED IN FOOD SERVICE FACILITY,
<br /> Date:
<br /> PROVIDE P-TRAP REFER TO LOCAL CODES FOR FURTHER INFORMATION,
<br /> 0
<br /> n
<br /> a
<br /> 0
<br /> z Drawn by:
<br /> V
<br /> 3-COMP SINK DETAIL WASTE PLUMBING DETAIL U Checked by:
<br /> SCALE: NONE SCALE: NONE 5 FLOOR DRAIN DETAIL z
<br /> SCALE: NONE 6 Project, 19-503.36
<br /> Sheet Number
<br /> e" e H,
<br /> P002U
<br /> O 2020 SCHUSS CLARKBRANDON
<br /> ARCHITECTS,INCORPORATED
<br />
|