WORK PLANS - Laserfiche WebLink

Home Browse Search

In-N-Out Burger NGF 255 Operators Manual © 2011, IMI Cornelius Inc.- 3 -Publication Number: 621058746INS START-UP AND OPERATING INSTRUCTIONS ICE DRINK DISPENSER The ice drink dispenser must be installed by qualified personnel following the instructions given in the Installation manual P/N 621058476INS. Fill the hopper with ice. Dispense several large cups of ice (approximately 20 to 30 seconds total dispensing time) to allow ice to fill the cold plate cabinet. Add ice to the hopper as necessary to refill, then replace the lid. Allow 10 to 15 minutes for the cold plate to cool down. Repeat this procedure whenever the dispenser has run out of ice. Start up the beverage system and adjust faucets to the proper brix. Contact your local syrup distributor for complete information on the beverage system. The ice drink dispenser is designed to operate in ambient temperatures ranging from 65 to 95o F. Do not allow the unit to be stored or operated in conditions below 32o F. This could cause damage to the unit. CAUTION:! Dispenser cannot be used with crushed or flaked ice. Use of bagged ice which has frozen into large chunks can void the warranty. The dispenser agitator is not designed to be an ice crusher. Use of large chunks of ice which “jam up” inside the hopper will cause failure of the agitator motor and damage to the hopper. If bagged ice is used, it must be carefully and completely broken into small, cube-sized pieces and left to “temper” or warm up for a minimum of 20 minutes in room temperature before loading into the dispenser hopper In normal operation, pushing the ice dispenser mechanism causes ice to flow from the ice chute. Ice flow continues until the dispenser mechanism is released. Dispensing of any faucet provides beverage of the appropriate flavor. !WARNING: Use caution to avoid spilling ice when filling dispenser. Clean up immediately any spilled ice from filling or operating the unit. To prevent contamination of ice, the lid must be installed on the unit at all times. Failure to clean up spills could result in serious injury or death If the dispenser fails to dispense ice or beverage, refer to the troubleshooting section in the Installation Manual P/N 621058476INS. NOTE: The dispenser is not designed for a wash-down environment and MUST NOT be placed in an area where a water jet could be used. NOTE: This appliance is not intended for use by personnel (including children) with reduced physical, sensory or mental capabilities or lack of experience and knowledge, unless given supervision or instruction concerning use of the appliance by a person responsible for safety.