|
I" HOT WATER SUPPLY
<br />11 11
<br />3 GAL. AM FRO
<br />EXPANSION T
<br />42
<br />VALVE
<br />VACUUM RELIFF
<br />1/8"xl 1/2" STEEL
<br />STRAPS SECURE TO
<br />FRAMING W/ 1/2"x2
<br />1/2" LAG SCREWS.
<br />(STRAPS -ICBG
<br />APPROVED)
<br />3/4" G
<br />SPILLAGE
<br />HOLDING PAN
<br />(ALUMJNLJM)
<br />3"TYPE "B" FLUE
<br />rumm
<br />SHUT OFF VALVES
<br />3/4" COLD WATER. SUPPLY
<br />CHECK VALVE
<br />TF, MPERATURE AND
<br />PRESSURE RELIEF
<br />VALVE
<br />3/4"
<br />WH f & P DRAIN LINE
<br />�i�l SPILLTO MOP SINK
<br />3/4" PVC DRAIN
<br />PLATFORM AND FRAMING
<br />SEE ARCH PLAN
<br />SCALE:
<br />GAS WATERAJEATER I NTS
<br />HOT WATERHEATER SIZING
<br />A. GPFI DEMAND
<br />1,3(,'OMPAR'I'MENT'SINK:----,--- 42GPI I
<br />1 HAND SINK.:- 3x5 = 15 GPI -I
<br />3. MOP SINK:- 15 GPH
<br />4. PREP 5 GPH
<br />5. LAV: ---------------------- 5 GPH
<br />TOTAL 82 GPI I
<br />B. ACTUALDEMAND ----- 82x0.6 = 49,2 GPH
<br />49.21x 60x 8.33
<br />C, KW 30737 BTUFf
<br />0.8
<br />D. SELE(,.TED:- RHEEMPERFORMANCE, 40 GALLON, SHORT,
<br />34,000 BTUH -, 80% EFF. 68 GPH RECOVERY AT 60- RISE
<br />FIELD CO.-ORDINATIOR NOTE:-
<br />PLUMBING A
<br />CONTRACTOR SHALL CO-ORDINATF, ALL PLUMBING FIXTURES ND WASTE/ VENTPIPING iNsTALLATION
<br />WITH PROPERTY MANAGER AND CONNECTIONS STAFFTO AVOID CONFLICTS WITH EXISTING PIPING. ALL PIPE RUNS
<br />SHALL, BE KFIPT SHORT AND PAINTED TO MATCH EXISTING PIPES. "I'LlE WASTE/VENT PIPING IS VERY CRITICAL
<br />CAREFUL CO-ORDINATION WITH PROPERTY MANAGER IS NEEDED TO AVOID ANY CONFLICTS.
<br />SCALE:
<br />GREASE INTERCEPTOR. DETAILl Ni's
<br />GREASE INTERCEPTOR. SIZE CALCULATION
<br />NO, PLUMBING QUANTITY TRP GPM DFU TOTAL D FU
<br />F I X TU R E PLUMBING SIZE PLUMBING PLUMBING
<br />FIXTURE FIXTURE FIXTURI_,;
<br />1. 3 --COMPARTMENT
<br />1 3" 15 3 3
<br />SINK
<br />roLALI 3
<br />REQUIRED SIZE PROVIDE 60 GAL. GREASE� INTERCEPTOR.
<br />(GALLONS)
<br />GREASE INTERCEP,roll NOTE:
<br />MANUFACTURER MODEL NO.: SCHIERPATG-I5-LO, TRAPPER SERIES,
<br />POLYETHYLENE CONSTRUCTION, WITH INTEGRAL FLOW CONTROL
<br />DEVICE AT INLET, 15 GPM, 60 LBS GREASE CAPACITY. (INSTALL BELOW
<br />I
<br />FLOOR WITI-TACCESS TO FLOW CONTROL DEVR _E WITH 2" VENTS FROM
<br />INLET AND OLYFL.E'r AND DISCHARGE SIDETRAP).(APPROVED EQUAL
<br />ZURN)
<br />WATER CALCULATION -S
<br />BUILDINGFIXTURE UNITS 21 = 17 GPM
<br />CWI-,INE:.- V
<br />BUIL,DING iwrERNAI.., PRESSURE LOSS
<br />PRV SET 8o PS1 (EXIST.) LOW PRESSURE = 70 PSI. (EXIST.)
<br />SIZED FOR 60 PSI (SAFE PRESSURE)
<br />3/4 WA,rER. METER (EXIST.) ISI
<br />0 BACK FLOW PREVENTER (EXIST.) 12PSI
<br />PRESSURE REDUCING VALVE (EXIST.) - ___ PST
<br />PRESSURE AVAILABLE AT' BUILDING ENTRANCE 45 PSI
<br />BUILDING, INTERNAL PRESSURE LOSS
<br />UNITS
<br />BUILDING STATIC PRESSURE HEIGHT
<br />(.,As'r IRON NO 11UB
<br />14 HE1GHTX0A34=
<br />6.1 PSI
<br />PRESSURE REQUIRED AT FIXTURE:
<br />SIZE
<br />FLUSH VALVE:
<br />- - - PSI
<br />FLUSFITANK:
<br />- 20 PSI
<br />FlUILDINGTOTAL LOSS:
<br />�261) s I
<br />AVAILABLE, PRESSURE FOR FRICTION LOSS
<br />GPM
<br />TOTAL LENGTH 125 FT X F 1.2 =TOTAL EQUIVALENT LENGTH (F.E.L.)
<br />12 FT
<br />(45--26.1} PSI X 100 FT -.150 T.E.L. 12.6 PST PER 100 FT
<br />2.5
<br />PIPES SIZED FOR 8 PSI/I00LF
<br />MOP SINK
<br />1 3
<br />P 147
<br />CW PIPING
<br />9
<br />PIPE
<br />SIZE 1/2" 3/4" 1 11/4" 11/2"
<br />SIZE;
<br />G I'm 3 9 16 30 44
<br />GAS 131 -ACK STEEL
<br />FU 3 11 23 54 104
<br />VEL
<br />_VEL 8 8 8 8 8
<br />5
<br />-S 8 g 8 8
<br />(D
<br />PSI
<br />2
<br />fl -W PIPIN( -
<br />PIPE
<br />WA r rE.R Fl."I" I _F
<br />UNITS
<br />WASTE, & CAST IRON NO HUB
<br />(.,As'r IRON NO 11UB
<br />WASTE
<br />VENT
<br />WATER
<br />SIZE
<br />1/2"
<br />3/14"
<br />TOTAL
<br />HOT AND COLD CO 11 P E R TY 1) F, " L
<br />NITS
<br />A130VE GRADE
<br />UNITS_.
<br />GPM
<br />3
<br />8
<br />13
<br />2.5
<br />2.5
<br />MOP SINK
<br />1 3
<br />F U
<br />3
<br />9
<br />17
<br />_3
<br />GAS 131 -ACK STEEL
<br />MAL,LEABLE
<br />VEL
<br />5
<br />5
<br />5
<br />(D
<br />3
<br />2
<br />—LOSS
<br />8
<br />8
<br />8
<br />3
<br />F3
<br />5
<br />5
<br />PREP. SINK
<br />-
<br />WASTE &
<br />WA r rE.R Fl."I" I _F
<br />UNITS
<br />WASTE, & CAST IRON NO HUB
<br />(.,As'r IRON NO 11UB
<br />WASTE
<br />VENT
<br />WATER
<br />Fl XTU R E
<br />FIXTURE TOTAL
<br />QUANT "X
<br />]
<br />FIX'T'URE
<br />TOTAL
<br />HOT AND COLD CO 11 P E R TY 1) F, " L
<br />NITS
<br />A130VE GRADE
<br />UNITS_.
<br />WATER. CLOSET (I)
<br />1 4
<br />4
<br />2.5
<br />2.5
<br />MOP SINK
<br />1 3
<br />3
<br />3
<br />3
<br />7,LOOR SINKS / ED
<br />_3
<br />GAS 131 -ACK STEEL
<br />MAL,LEABLE
<br />ABOVE GRADE
<br />SCH, 40
<br />................. I
<br />SCREWED ON
<br />[LAND SINK (N & E)
<br />(D
<br />3
<br />2
<br />6
<br />2
<br />0.6
<br />KITCHEN SINK
<br />3
<br />F3
<br />5
<br />5
<br />PREP. SINK
<br />-
<br />1
<br />2
<br />2
<br />ICE M/C
<br />0.5
<br />O.5
<br />CW OUTLETS
<br />2
<br />0.5
<br />1
<br />LAT(N)1
<br />1
<br />I
<br />I
<br />TOTAL,
<br />24
<br />21
<br />SEWER LINE - 4" (24 FU)
<br />GPM
<br />CURVE FLUSH `TANK - WATER I I N F= 1 (21 FU), 17 GPM
<br />17
<br />PIPE MATERIAL SCHEDULE
<br />SERVICE PIPE
<br />FI FT'INGS
<br />LOCATION
<br />WASTE, & CAST IRON NO HUB
<br />(.,As'r IRON NO 11UB
<br />A130VE GRADE
<br />BELOW GRAt)E
<br />VENT
<br />STORM CAST IRON NO HUB
<br />DRAIN
<br />CAST IRON NO HUB
<br />ABOVE GRADE
<br />BELOW GRADE
<br />HOT AND COLD CO 11 P E R TY 1) F, " L
<br />WROUGHT COPPER
<br />A130VE GRADE
<br />WATER. HARD DRAWN
<br />COLD COPPER TYPE, "L"
<br />WROUGHT COPPER
<br />BELOW GRADE
<br />WATER HARD DRAWN
<br />INDIRECT WASTE COPPER TYPE I'M"
<br />WROUGHT COOPER
<br />ABOVE GRADE
<br />CONDENSATE DRAIT\ HARD DRAWN
<br />GAS 131 -ACK STEEL
<br />MAL,LEABLE
<br />ABOVE GRADE
<br />SCH, 40
<br />................. I
<br />SCREWED ON
<br />C)
<br />CERAL NOTES P14A SYMBOLS AND LEGEND
<br />I, ALL WORK SHALE CONFORM TO THE UNIFORM PLUMBING CODE LOCAL SYMBOLS ABBRFIV, DESCRIPTION
<br />CODESINCLU DING INSTALLATION OF ALL REQUIRED CLEANOUTS PER,
<br />W SEWER WASTE ABOVE
<br />20t3 CPC. -,LOW
<br />W SEWER WASTE BE
<br />2. VERIFY SHE,, DEPTH, LOCA,rFON AND ADEQUACY OF ALL, UTII-XvIES, V VENT I -INE
<br />INCLIJI)ING METER LOCATIONS AND SEWER INVERTS, BEFORE Cw COLJ) WATER
<br />STARTING WORK, HW HOT WATER
<br />3, ALL PIPING IN FINISHED AREAS SHALL BE CONCEALED WHERE
<br />POSSIBLE,AND EXPOSED PIPING SHALL, BE RIJN AS HIGH AS POSSIBLE HwR I TOT' WA FEE, RETURN
<br />ANDTIGHT TO WALLS, Gw GW GRF ' ASE WASTE
<br />4, ALL, LINENS TO 13E AWAY FROM BEARING FOOTIN(JiS, OR AS DIRECTED 13Y ------ __ _ _.___C,...__.--._-_._____.__-- G GAS
<br />STRUCTURAL ENGINEER. CD CONDENSATE f)RAIN
<br />5, INSTALL BACKFLOW PROJECTION DEVICES AS REQUIRED BY LOCAL CODES. SOL SOIL,,WASTE ABOVE FLOOR OR. GRADF!"
<br />6, INSTALL PRESSURE REDUCING
<br />'ING VALVE(S) WITI I SFIUT-OFF WHERE CITY CWV- CWV COMBINATION WASTE & VI -ENT
<br />PRESSURE EXCEEDS 80 PSL DS DS DOWNSPOUT
<br />T ALL APPLIANCE AND PLUMBING VENTS SI-IAL.,LBl: A'1'1-,EASI'TEN (IO) NEWTO EXISTING CONNECTION
<br />FEET IN HORIZONTAL DIRECTION OR THREE (3) FEET ABOVE JfjE OUTSIDE Fs FLOOR SINK
<br />AIR IN FAKES FOR HVAC UNITS, WC"(.) WALL, CLE'AN t:)1..1'1`8, SEWERTO BE RUN 1/4" SLOPE AS PER 2013 CITY OF SAN
<br />FRANCISCO PLUMBING CODE. LARGER LINE MAY BE INSTALLFD AT CO CLEAN OUT TO:) GRADE
<br />A SLOPE OF- NOT LESS THAN 1% WHEN FIRST APPROVED BY THE FD F'L.,OOR DRAIN
<br />BUJI-DING DEPARTMENT, MEETING FU RATING OF'CPC.
<br />9, ALL REQUIRED CLEANOUTS SHALL BE INSTALLED AS PER 2013 CPC 0 POC POINT OF CONNt"."CTION
<br />10, ALL, EX'11RIOR HOSE B113S SHALL BE PROVIDED WITH NON REMOVABLE TRAP PRIMER
<br />13ACK FLOW PREVENTION DEVICES AND VACUUM BREAKEIRS,
<br />11, PROVIDE SHUT OFF VALVES FOR AI.A., PLUMBING FIXTURES AND GROUPS, AP ACCESS PANEL RIC ROUGH -IN & CONNECT
<br />ASR, AUTO. FIRE SPRINKI-ER RISER RD ROOT-- DRAIN
<br />11 PROVIDE ACCESS PANELS FOR ALL GROUPS OF TOILETFIXTURFS. BIP BACKFLOW PREVENTER SOC SHUT OFF COCK
<br />13, PROVIDE TRAP PRIMERS FOR TRENCH DRAINS. BC BALANCING COCK SOV Sl [tTr OFF VALVE
<br />CB CATCH BASIN NA NOT APPI ICABLF
<br />14 USE DIl-,LECTRIC UNIONS CONNECT S'1 ANT) COPPER OR BRASS COYB CLEANOUTIN YARD BOX N,LCI NOT IN CONTRACT
<br />OR D OVERS ROOF DRAIN
<br />PIPES & FixTURES. CO CLEANOUT -
<br />15 INSTALL APPROVED FLEX. GAS LINE (.,',ONNECTOR,TO PIZZA OVEN WITH IlDR HEADER PRV PRESSURE REDUCING VALVE
<br />LI -1 INDIRECT DRAIN (N) NEW
<br />SHUT OF VALVE" LE, INVERT ELEVATION (17) EXISTING
<br />MIT MANHOLE
<br />P.LUMBING FIXT LJRE SC"f-IEDUI-,E
<br />ITEM DFSCRIPTION WST 'FR VT CW HW SPECII-1CATIONS & REMARKS
<br />IM ICE M/CABOVE ' BEVERAGE 1/211 OWNER FURNISHED - PROVIDE INLINE FILTE'R
<br />I DISPENSER
<br />KS 3 COMPARTMENT SINK. 2" 1-1/2" 1-1/2" 3/4" 3/4" OWNER FURNISHED
<br />TO GREASE TR A 1-1
<br />PS
<br />fl� "I - PREP. SINK 1/2" 1/2" OWNER FURNISHED INDIRECT DRAIN TO FS
<br />HS HAND SINK (N & E) 2" 2" 1-1/2" 1/2" 1/2" OWNER FURNISHED
<br />FLOOR SINK JAY R. SMITH OR F ' CL,
<br />QUAL,
<br />I ILI) 2" 211 1-1/2" WITH P -TRAP CONN.
<br />WEI WATER HEATER 3/4" 111 40 GALLON, SHORT, 34,000 13TUH - 80(',/(, EFF
<br />RHEEM-PERFORMANCE 68 GPH RECOVERY AT 60" RISE?, WT: -350 LBS
<br />TRAP PRIMER.
<br />TP INSTALL IN WALL, AS SHOWN 1/2" PRIME PERFECT
<br />wiTti DISTRIBUTION UNITS AS
<br />INDICATED PER MFGRS.
<br />lNs'rRucTiONS.
<br />MS MOP SINK 2" 1 1/2" 1/2" L/2" FIAT, WITH CW/HW MIXING FAUCET WI -1-1-1 MOP HOLDER(SEE FLOOR PLAN FOR SIZE)
<br />IT FLOOR DRAIN 2't 211 1 1/211 J.R, SMITH OR EQUAL
<br />AMERICAN BOWL, BLAI)DLR
<br />WATER. CLOSET (E) 4" ENT, 1'. 2" 1/2" ASSISTED FLUSHTANK, 1.28 GPF, ADA COMPLIANT.
<br />1/2" AMERICAN STANDARD -"LUCERNE ", WALL., MOUNTED, 0.5 GlIM, SFLl'
<br />LAVATORY (N)
<br />CLOSING IJW/CW MIXING FAUCET, ADA COMPLIANT,
<br />GL GREASE INTFRCFPTOR 31' Yv 2" SCHIER-PAT(J-154,0, 60 LBS GREASE CAPACITY (INTEGRAL FLOW
<br />CONTROL) (ZURN OR 131(1 D11111FIR AS EQUAL)
<br />1. ALL PIJJM13ING WASTE CONNECTIONS SHALL (..',OMPL,Y WITH LOCAL, BLI)G, Dl-__,PT
<br />21, ALL PLUM131NG FIXTURES SHALL BE LOW WATER CONSUMPTION TYPE,
<br />0
<br />I
<br />DATE: 01/06/20,17
<br />JOB: HSD-TR-01
<br />DWG BY- KS
<br />CHK BY: APV
<br />w
<br />, Z6
<br />>-
<br />cy)
<br />L0
<br />N<<
<br />N
<br />0-
<br />z
<br />C)
<br />(D
<br />_4i_
<br />oco
<br />I
<br />DATE: 01/06/20,17
<br />JOB: HSD-TR-01
<br />DWG BY- KS
<br />CHK BY: APV
<br />
|