INSTALL_2022 - Laserfiche WebLink

Home Browse Search

Environmental Health Department SAN-6-JOAQUIN vii fir : C 0 U ( T Time In: Time Out: r'�JFOSX;` Creotness grows Frere, Underground Storage Tank Program Service Request Inspection Report Name of Facility: LOVE'S COUNTRY STORES OF CALIF#223 Date: 12/16/2022 Address: 1553 COLONY RD , RIPON 95366 Requestor: CONTACTOR-WESTERN PUMP INC,WESTERN PUMP INC Telephone: (209)599-0740 Program Element: 2303-UST/PIPING INSTALLATION Request#: SR0082925 Inspection Type: 298-UST RETROFIT REPAIR INSPECTION Onsite Service Technician: Chris Mizicko ICC Service Tech/Installer Exp. Date: 12/11/2024 Manufacturer training: VR, 03/20/23;VMI, 12/12/24; OF, 12/13/2024; SB, 12/13/24 OVERALL INSPECTION NOTES AND COMMENTS NOTES -Witnessed testing of the biodiesel electronic leak detector at 3 gph at 10 psi. Passed. The leak detector was tested on the biodiesel product line connected inside the fill sump of the existing/old diesel tank closest to the store building. The 87 and diesel tanks are siphoned into existing tanks and do not have pressurized piping or leak detectors. -There are 4 vacuum sensors monitoring the new tanks, located in the biodiesel STP sump. The piping sumps for the 87 and diesel tanks do not contain turbines. Witnessed testing of the vacuum sensors. All sensors passed for both vacuum and liquid portions. Verified vacuum zone communication. -Verified deflector plates have been installed on all dispensers. -Verified no vent sump alterations have been made. The vent sump only contains the diesel and biodiesel vent lines for the new tanks. Per the technician,the 87 vent piping is connected to the existing/old small 87 tank(split tank with 91),which is then vented through the old 87 vent piping near the store building. The vent sump appeared to have non-Bravo sealant. Confirm that all sealants and installation on the vent sump were performed to manufacturer's specifications. -Verified overfill flappers for all three tanks are below 95%. Verified flapper functionality. Per the technician,the serial numbers of all three flappers were submitted to the manufacturer and confirmation was received that the model of all three flappers is the Franklin Fueling Defender#708692-902. This is not the model that was approved for installation. The plans submitted indicated the overfill flappers would be model#s 708592-902 and 708695-922. The-922 model is specifically approved for use with biodiesel. Immediately submit cut sheets, compatibility, and part information for the overfill models installed,for approval by the EHD. -Witnessed testing of three tank top spill containers and three remote spill containers, including 1 hour hydrostatic testing, drainage, and 5 gallon capacity. All passed. The remote spill containers were direct-bury EMCO Wheaton model#A1005-517SF, marked with an installation date of 09/2022. No vacuum monitoring was observed for the remote fill piping. VPH monitoring for this piping will need to be verified prior to use of the remove fill piping. -Chase piping for four lines(biodiesel STP sump to diesel STP sump, biodiesel STP sump to 87 STP sump, biodiesel STP sump to biodiesel fill sump, and 87 piping sump to 87 fill sump)were found unmonitored at the time of inspection. Vacuum monitoring was added to these lines and communication verified. **This facility is NOT approved to operate the new 87, biodiesel, or diesel USTs.** **This facility is NOT approved to receive fuel in the new 87, biodiesel, or diesel USTs.** Additional paperwork is needed. Refer to items 8, 9, and 10 of the approval letter dated 10/27/2021 for details. FA0012659 SR0082925 SC298 12/16/2022 EHD 23-01 Rev.06/30/15 Page 1 of 2 Underground Storage Tank Program Service Request Inspection Report