Laserfiche WebLink
GAS-FIRED <br />LISTED HLW <br />On Select Models. <br />airier:cars - <br />WATER HEATERS <br />(1) <br />Low NOx Heavy-Duty <br />Commercial Gas <br />3-Year Limited Tank/ 1-Year Limited Parts Warranty* <br />Eighty plus percent thermal efficiency affords lower operating <br />costs on most models. <br />Induced Draft Built-In Blower <br />The blower is built into the top cover, factory <br />mounted and wired. Ideal for installations <br />where negative pressure is present in the <br />building. Blower proves draft prior to <br />ignition. No drafthood or barometric <br />damper required. <br />Metal Venting <br />Uses standard metal single wall or double <br />wall type "B" vent. Can be commonly vented <br />with Category I appliances. Vent connects <br />directly to the blower outlet. Perfect choice <br />for retrofit and upgrade installations. <br />Water Connections <br />For ease of installation, all BCG3-NOx feature <br />water connections on the top, front, and rear. <br />Glasslined Tank <br />Our proprietary slush coating is applied <br />after the complete tank has been assembled <br />to give a seamless barrier against hot water <br />corrosion. Maximum working pressure <br />160 psi. <br />Installed Cost Savings <br />When multiple BCG3-NOx units are <br />exclusively used in a vent manifold, use the <br />National Fuel Gas Code Table 13 Fan Sizing <br />Charts to determine vent diameter and <br />specifications.The BCG3-NOx with its internal <br />induced draft blower enables safe use of <br />smaller vent diameters, This feature can save <br />hundreds of dollars in installation costs. <br />Fully Automatic Digital Controls With <br />Safety Shutoff <br />Accurate, dependable control system. <br />Manual reset gas shutoff device for added <br />safety. Maximum inlet gas pressure is 14"W.C. <br />Minimum gas pressure is 5.2" W.C. Natural <br />Gas, 11" W.C. Propane. <br />"Environmentally-Friendly" Non-CFC <br />Foam Insulation <br />Saves fuel, helps reduce standby heat loss. <br />Jacket <br />Heavy gauge steel finished with a baked <br />enamel finish over a bonderized undercoat. <br />Fully Tested for Safety and Performance <br />Design certified by the Underwriters <br />Laboratory for 180°F hot water service. Meets <br />rigid requirements of the National Sanitation <br />Foundation Standard 5 when equipped <br />with optional leg kit. Certified for use on <br />combustible flooring. <br />Easy Cleaning <br />Handhole cleanout allows access for <br />easy cleaning. <br />Anodes <br />Long-life, stainless steel core <br />anode rods. <br />Intermittent Ignition Device <br />Eliminates standing pilot. Provides flame failure <br />response in less than one second. Power <br />ON/OFF switch. <br />Easy-to-Install <br />Completely factory-assembled. Only gas, water, <br />vent and electric connections need be made. <br />Provided with drain valve. <br />Plug Kits <br />Pipe nipples and caps are included to plug <br />unused water connections. <br />Approval Ratings and Certification <br />All models meet or exceed the thermal <br />efficiency and standby loss requirements of <br />the U. S. Department of Energy and current <br />edition ASHRAE/IESNA 90.1, C.E.C. California <br />Energy Commission and comply with Texas <br />requirements for Low NOx emissions. <br />OTHER FEATURES <br />Equipped with gas pressure regulator and <br />pilot filter <br />Integral automatic gas shutoff system prevents <br />excessive water temperature <br />CSA certified and ASME rated T&P relief valve <br />Maximum working pressure is 160 psi standard <br />Cathodic protection <br />Adjustable thermostat with a 120-180°F range. <br />OPTIONS <br />Manifold kits for multiple heater installations. <br />two units - #9003426205 <br />three units - #9003427205 <br />four units - #9003428205 <br />Leg kits for UL sanitation to meet <br />NSF-5 - # 9003425205 <br />THREE YEAR LIMITED TANK WARRANTY <br />For complete warranty information, consult <br />written warranty or contact American <br />Water Heaters. <br />*For complete warranty information consult the written warranty of American Water Heaters found at www.americanwaterheater.com , or call (800) 456 -9805. <br />Copyright ,, by American Water Heaters 2012. All rights reserved. NCGSS00608 Revi sed March 2013 <br />ho part of this work maybe reproduced or transmitted in any form or by any means, electronic or mechanical, induding photocopying and recording, or by any information storage retrieval system, without permission in writing from American Water Heaters.