|
QI i� I
<br />L -----J I------I
<br />—tiRANU T R
<br />(YERIFY
<br />L------._---___— CANOPY _ J
<br />FLOOR PLAN
<br />]/a"- 1'-0"
<br />SHEET NOTES:
<br />O1 PROVIDE SINGLE POINT BAR, "SQUARE On DPK7GTA OR EQUIVALENT WITH CAPACITY
<br />FOR 7 INDIVIDUAL TERMINATIONS OF No.6 AWG CONDUCTORS. BOND THE GROUND
<br />BAR TO THE GROUND BUS IN PANEL A WITH #6 Cu.
<br />Q PROVIDE 2 SIZE 0 STARTERS IN NEMA 3R ENCLOSURES FOR (2) CAN CRUSHERS
<br />GENERAL NOTES: _
<br />1. Before submitting the bid proposal the Electrical Contractor shall visit the job site and
<br />fully acquaint himself with the job conditions and verify service connection including all
<br />necessary pull boxes, size and number of conduits and conductors, switchgear, metering,
<br />cable charges, etc., whether are shown on drawings or not, but required to make a
<br />complete and operating electrical service without additional cost to Owner. Verify service
<br />with the Landlord or Landlord's Representative.
<br />2, The Electrical Contractor shall coordinate his work with that of all others, to install
<br />lighting fixtures symmetrically with titles and/or dimensions to accommodate fixtures
<br />with other equipment installations. Prior to finish of affected work the Electrical Contractor
<br />shall instruct the Owner and/or Manager on the use and maintenance of the electrical
<br />system.
<br />3. The Electrical Contractor shall verify all requirements of mechanical equipment with
<br />mechanical drawings and specifications. The Electrical Contractor shall furnish and install
<br />all items required by the air conditioning, heating, and ventilating Contractor for a
<br />complete installation.
<br />4. Fixtures and equipment locations indicated are based preliminary layouts. Exact locations
<br />shall be verified.
<br />5. Running over current protection and disconnect means, shall be installed on all motors
<br />to comply with code.
<br />6. A pull wire shall be installed in all conduits marked "C.O,"
<br />7. All disconnect switches shall be horsepower rated for the motor connected to switch.
<br />8. The Electrical Contractor shall do all work required to provide temporary electrical service
<br />for construction illumination and power for all trades. All cost of labor and material
<br />required for electrical service shall be included in the electrical contract.
<br />9. The Electrical Contractor shall verify the exact ceiling being furnished before ordering
<br />fixture noted, either at the job side or with the architect and shall provide the necessary
<br />hardware for a complete installation
<br />10. The Mixing Room is classified as class L Division 1 per 500-7(a) of the NEC.
<br />All electrical equipment in this room shall be approved for
<br />Class I Division 1 location, including switches, receptacles and light fixtures.
<br />All wiring methods and sealing in these areas shall be in accordance with
<br />N.E.C. Section 501, for Class I Division 1 areas.
<br />11. All remaining interior spaces except rooms 104, 105, 106, 107, & 108 area classified
<br />as Class I Division 2 per 500-7(b) of the NEC.
<br />All electrical equipment in these rooms shall be approved for Class I, Division 2 areas
<br />12. See Mech. Plans for location of mech. equipment
<br />SINGLE
<br />METER / MAIN 400 A,
<br />GROUND BUS
<br />#2/0 B.C.
<br />METALLIC COLD WATER PIPE'
<br />W/APPROVED GROUND CLAMP
<br />MIN 20' IN LOWER 4"
<br />OF CONCRETE FOOTING
<br />C.—<,o,+,a,u,,
<br />1 4 HP
<br />AMPS/HP
<br />120
<br />V
<br />2
<br />12,
<br />1/2"
<br />C
<br />20/1
<br />P-1
<br />EF -7
<br />1/25 HP
<br />1/2 HP
<br />-
<br />120
<br />120
<br />V
<br />V
<br />2
<br />2
<br />#12,
<br />#12,
<br />1/2"
<br />1/2"
<br />C
<br />C
<br />20/1
<br />201
<br />/
<br />(4) SMOKE DAMPERS
<br />(2) SMOKE DETECTORS
<br />1/40 HP
<br />1.0 A
<br />2 #4,1#10G,1/2"C
<br />120
<br />120
<br />V
<br />V
<br />2
<br />2,#12,
<br />#12,
<br />1/2"
<br />I 2"
<br />C
<br />C
<br />20/1
<br />EMERGENCY SHOWER
<br />1.0 A
<br />1776
<br />120
<br />V
<br />2
<br />#12
<br />1/2"
<br />C
<br />540 12 20/1
<br />20
<br />1380 2
<br />NOTE: SEE MECH. PLANS
<br />FOR LOCATIONS
<br />OF
<br />EQUIPMENT
<br />1776
<br />6
<br />8
<br />10
<br />CAN CRUSHER, 3 HP
<br />EQUIPMENT SCHEDULE
<br />UNIT
<br />AMPS/HP
<br />VOLTS/PHASE
<br />CONDUCTOR/
<br />D1ISSEONNECT/
<br />STARTER SIZE
<br />(1) AIR COMPRESSOR
<br />5 HE,
<br />208/3
<br />3 #10,1#10G,3/4"C
<br />30/3
<br />-
<br />(2) CAN CRUSHERS
<br />3 HP
<br />208/3
<br />3 #12,1#12G,1/2"C
<br />30/3
<br />0
<br />(1) FILTER CRUSHER
<br />4 HP
<br />208/1
<br />2 #4,1#10G,1/2"C
<br />30/2
<br />-
<br />(1) GRANULATOR
<br />1.5 HP
<br />115/12#10,1
<br />100,1/2"C
<br />30/1
<br />-
<br />LINE DIAGRAM
<br />120/24OV, 30, 4W, NEMA 3R
<br />400/3
<br />PANEL
<br />PANEL
<br />B
<br />/ IN NEMA 3R ENCL.
<br />1 #2/0 G, 2"C
<br />PHOTOCELL
<br />TORK 2101
<br />2 #2 THW Cu,
<br />1 #8 G, 1 "C
<br />NOTE: ALL FEEDER CONDUCTORS ARE THW CU.
<br />PROVIDE SERIES RATED SYSTEM 42 KAIC MIN.
<br />NATURAL GAS GEN. SET
<br />30 kW, 120/24OV, 30, 4W
<br />WITH WP ENCLOSURE AND
<br />TRANSFER SWITCH
<br />LIGHTING CONTACTOR
<br />3 POLE, 120V, 20A
<br />TO CANOPY LIGHTS,
<br />WALL PACK LIGHTS,
<br />POLE LIGHTS & SIGN
<br />C
<br />C
<br />C3
<br />Q
<br />MEZZANINE FLOOR PLAN
<br />1/5' • 1'-0"
<br />1q 3U- da
<br />120/240 V
<br />01740
<br />GLB
<br />9W
<br />07-09-02
<br />S.JOA-E2
<br />P A N E L:
<br />3 PHASE 4 WIRE
<br />A
<br />200A M.L.O.
<br />REMARKS: O NEMA 3R ENCLOSURE
<br />2 VERIFY LOAD
<br />SURFACE MOUNTED
<br />SURFACE MOUNTED
<br />LOCATION
<br /><AIC
<br />10 kAIC
<br />;REMARKS:
<br />3 PROVIDE
<br />HACR C.B.
<br />SERVING
<br />CKT
<br />A
<br />BB WIRE CIRC A
<br />SIZE BRKR
<br />8 C CIRC
<br />BRKR
<br />WIRE
<br />SIZE
<br />A
<br />B
<br />C
<br />CKI
<br />SERVING
<br />3 2
<br />SPARE
<br />1
<br />3
<br />540
<br />12 20/1
<br />—
<br />40
<br />10
<br />10
<br />1776
<br />1776
<br />62
<br />2
<br />4
<br />COMPRESSOR, 5 H
<br />3 OFFICE
<br />HEAT PUMP
<br />5
<br />7
<br />9
<br />1380
<br />540 12 20/1
<br />20
<br />1380 2
<br />3
<br />3p
<br />10
<br />12
<br />12
<br />1320
<br />1320
<br />1776
<br />6
<br />8
<br />10
<br />CAN CRUSHER, 3 HP
<br />CAN CRUSHER, 3 HP
<br />11
<br />800 30
<br />E
<br />3
<br />12
<br />1200
<br />1320
<br />12
<br />13
<br />1320
<br />50
<br />4
<br />3100
<br />505
<br />14
<br />FILTER CRUSHER
<br />15
<br />EMERGENCY SHOWER
<br />1320 3
<br />2
<br />4
<br />3100
<br />16
<br />ELEC. Will
<br />17
<br />2250
<br />10
<br />30
<br />2
<br />16
<br />18
<br />EF -6
<br />EF -7
<br />40/1
<br />10
<br />SPARE
<br />19
<br />2300
<br />18
<br />GRANULATOR, 1.5 HP
<br />19
<br />2250
<br />20/1
<br />10
<br />20/1
<br />20
<br />SPARE
<br />20
<br />SPARE
<br />3 PUMP 1 HP
<br />21
<br />920
<br />12
<br />20
<br />LCL 8997
<br />+25% LCL —
<br />—
<br />22
<br />REMAINDER ���—
<br />TOTAL 13966
<br />TOTAL13966 -
<br />240 W _
<br />= 58 AMPS
<br />FACP
<br />23
<br />25
<br />50020/1
<br />920
<br />2
<br />20/1
<br />20/1
<br />1000
<br />1000
<br />24
<br />26
<br />GEN.BATT.CHARGER
<br />GEN, HEATER
<br />I SUMP PUMP, 1 HP
<br />27
<br />1150
<br />0
<br />7/2
<br />—
<br />28
<br />29
<br />1150
<br />2
<br />20/1
<br />50
<br />30
<br />P-1
<br />4 W.
<br />31
<br />720
<br />20/1
<br />32
<br />SPARE
<br />33—
<br />—
<br />20
<br />2
<br />1000
<br />34
<br />ELEC. GATE
<br />PANEL B
<br />3
<br />2
<br />10
<br />1000
<br />36
<br />37
<br />2
<br />2
<br />201000
<br />38
<br />ELEC. GATE
<br />—
<br />1 W TTB
<br />39
<br />41
<br />—
<br />50O_J
<br />2
<br />12
<br />20/1
<br />2
<br />20/1
<br />1000
<br />280
<br />40
<br />42
<br />2 W
<br />PHASE A 22903 VA
<br />PHASE B_ 12966 VA
<br />PHASE C 18006 VA
<br />LCL 12757
<br />+25% LCL 3189
<br />REMAINDER TOTALS 4054
<br />TOTAL
<br />57064 -. 240 V
<br />= 238 AMPS
<br />NOTE: DO nlnT nDNIJC(`T nnrV
<br />»n v n." — —.. ,,..,,
<br />120/240
<br />V
<br />01740
<br />GLB
<br />9W
<br />07-09-02
<br />S.JOA-E2
<br />P A N E L:
<br />PHASE 3 WIRE
<br />B
<br />225A M.L.O.
<br />PANEL
<br />N.
<br />IS 42 POLE WITH 42 20/1 C.B.'S
<br />SURFACE MOUNTED
<br />Q
<br />LOCATION
<br />10 kAIC
<br />;REMARKS:
<br />SERVING
<br />CKT
<br />A B WIRE CIRCSIZ BRKR
<br />BRKR SIZE
<br />B
<br />CK1
<br />SERVING
<br />LIGHTS, A & 6
<br />LIGHTS, J, K & H
<br />LIGHTS, OUTSIDE
<br />1
<br />3
<br />5
<br />1728 12 20/1
<br />400
<br />1734
<br />20/1 12
<br />20/1
<br />15/1
<br />5
<br />505
<br />578
<br />2
<br />4
<br />6
<br />EXIT SIGN
<br />POLE LIGHTS
<br />EF -1
<br />SIGN LIGHT
<br />AERSOL CRUSHER
<br />7
<br />9
<br />1200
<br />62
<br />670
<br />505
<br />8
<br />10
<br />EF -2
<br />EF -3
<br />SMOKE DAMPERS
<br />11
<br />13
<br />480
<br />1200
<br />505
<br />505
<br />12
<br />14
<br />EF -4
<br />EF -5
<br />EMERGENCY SHOWER
<br />15
<br />17
<br />120
<br />200
<br />20/1
<br />1130
<br />670
<br />16
<br />18
<br />EF -6
<br />EF -7
<br />SPARE
<br />19
<br />20/1
<br />20
<br />SPARE
<br />PHASE A -759Z VA
<br />PHASE B VA
<br />LCL 8997
<br />+25% LCL —
<br />TOTAL—' 1717 VA
<br />REMAINDER ���—
<br />TOTAL 13966
<br />TOTAL13966 -
<br />240 W _
<br />= 58 AMPS
<br />.A
<br />D
<br />7
<br />DI
<br />=15iii art Avmae __
<br />Soho
<br />6imr gar Ca 95104
<br />Td: (M 5440784
<br />F¢ (707)544 9%
<br />OO Copyriym
<br />BRUCE WISHARD
<br />ELECTRICAL ENGINEER
<br />m a,n. a. xwn imt aysav
<br />(fin wesae m AOA assn
<br />No.
<br />Job Ne:
<br />Drs.," 8,
<br />Cheoked ey:
<br />Dote:
<br />File Nr.
<br />01740
<br />GLB
<br />9W
<br />07-09-02
<br />S.JOA-E2
<br />RevisionsBy
<br />Q
<br />--
<br />Sleet Number
<br />E2
<br />SHEET 7, or Z TOT?,L J
<br />
|