|
to
<br /> CUENT�,
<br /> NEUTRAL BUS ISOLATED 4 I-ANK/4 MPD W/ ISD
<br /> MOM GROUND &
<br /> PUMP CONTROL ELECTRICAL PANEL
<br /> BONDING SKREW REMOVED
<br /> FROM DISPENSER ISOLATION PER NEC 2 0-61(b) INTRINSICALLYSAFE AREA
<br /> RELAYS
<br /> SWITCHED HOT
<br /> 120 OR 240 VAC�
<br /> ELECTRICALLY ISOLATED GROUND
<br /> PUMP IN (PI) GROUND BUS (INSULATED ............ lor
<br /> FROM THE PANEL VIA A LNON—HAZARDOUS ANIA A MODULE TYPE:
<br /> TYPICAL NON-CONDUCTWE MOUNTING) _E 70_�7TI6R___R7ECORD:
<br /> _ER z -MElAWC CONDUIT, DO NOT LOW VOLTAGE SIDE RIGID CONDUIT FROM
<br /> MASTER TURBINE CONTROL]
<br /> r
<br /> EACH DISPENSER ARCO
<br /> z R ROUTE THROUGH AG TROUGH JUNCTION BOX 2 6 - bp WEST COAST PRODUCTS,LLC
<br /> "0
<br /> 200-250V CONDITIONED _071 OPDONAL HP mmNG TLS--350 PLUS MONITOR PANEL., 3__ 7 -
<br /> POWER SUPP f .................... ........ RIGID 4- 0
<br /> 3 PH 1 PH<-:;5 U SENSOR LOCATED 8-
<br /> 'A E In MODULE TYPE: AUJANCE MANAGER, AGENT FOR BP:
<br /> THROUG CONDUIT
<br /> U_ Ll (SEE NOTF -7) WFATHERPROOF d-BOX IN DISPENSER CABINET
<br /> ELFICTRICAL DIST1111BUTION I F9 -_AT -Q-N-LY _QN
<br /> CONTROL CENTER 1§��, GNO VAPOR -L POSITION RECORD:
<br /> + DISPENSER
<br /> 4_1 .............
<br /> li 1�"_. - _r PRESSURE
<br /> 115V AD NEUTRAL �'i - ___� SENSOR 7 5-
<br /> ........... ......
<br /> ........... ...................
<br /> 0 0
<br /> NEUTRAL AC LINE T�
<br /> ICED]LOBAW RIGID CONDUIT.- 0 so Gooses@
<br /> SENSOR LOCAITD —-----
<br /> WEATHERPROOF JBOX IN DISPENSER CABINETVApOR
<br /> + WF`T`
<br /> ED
<br /> B Mo4- - - -=W J. ......
<br /> LD -------- POSITION
<br /> FLOW
<br /> K TO MOTOR 0 METER 6
<br /> 0 0 see -7f
<br /> ses"Gool'a"
<br /> :9� RED XAM _ 'TYPICAL AT ALL 7-
<br /> ------ DISPENSERS T_7
<br /> so Go a 9 mr:j -1 _. 18—
<br /> See monufacturer installatton instructions 4p 0 0 SENSOR LOCATFD MODULE -TYPE: SMAR'l SENSORS
<br /> for specific wiring connections and _7
<br /> TO WEATHERPROOF J-BOX _�ATICKA SITE A6APl ONSULfANT7
<br /> SUBMERSIBLE speed/dIp switch settings, ................ IN DISPENSER ISUMP POSITION RECORD: ISD DISPENSER SENSORS
<br /> ............... I -
<br /> PUMP ........... 5- VAPOR PRESSURE SENSOR DISPENSER �/_X _
<br /> Sump 1 - DISPE��_Rl 2 A R FLOW METER
<br /> .......... j
<br /> Orr SENSOR 2-- DISPENSELy, 4 AIR FLOW METER T-—SPARE GHAU
<br /> sees* G000esoseee ...... - UFSTE_�_SER 5 --91—R -FLOW METER .......
<br /> _!@stem !09 3 76 7--- SPARE
<br /> mxx
<br /> SINGLE FLOAT' SENSOR DISEE-NSER_ 7/8 AIR FLOW METER ___7_-- S�A_RE 47� -71
<br /> 0 _20000-= 6666690600 IN HYCIROSTAJIC MODUI E TYPE: INTERSTIIIAL SENSOR INTERFACE �_O_b F 7F_
<br /> 0
<br /> RESERVOIR
<br /> OR DRY ANNULAR POSITION RECORD: UDC SUMP SENSORS, rANK SUMP SENSORS, ANNULAR SEN ORS
<br /> WEATHERPROOF J-BOX 0
<br /> 1 -- UNLEADED REGULAR 2 ULR FIL.L. SUMP
<br /> 5--UNCEADE I REGULAR 3 ULR ANNULAR 0
<br /> TYPICAL ____'_'__*_____] ANNULAR LEAK
<br /> __j
<br /> 7-75'[EADED REGULAR 2 ULR ANNULAR - UNLE
<br /> SLAVE TURBINE CONTROLLER L DETECTION 6 ADED PREMIUM ULP TURBRE SUMP
<br /> 3- UNLEADED REGULAR 3 ULR "TURBINE SUMP 7--- UNLEADED PREMIUM ULP FILL SUMP
<br /> R "L
<br /> R ANI
<br /> LAIR TU ULPI
<br /> 4- UNLEADED REGU�LAR W3R FILL SUMP 8- UNLEADED PREMIUM ULP ANNULAR
<br /> mX)NAL a UP Mmw
<br /> 200-250V CONDITIONED
<br /> C-7 �_D
<br /> I Q E N G
<br /> POWER SUPPLY 3 PH PH-� L2 RIGID CONDO MODULE TYPE: INTERS-11TIAL SENSOR INTERFACE MODULE
<br /> PROVIDED THROUGH Ll IT -SEE NOTE 10 SENSOR LOCATED
<br /> TRIrAl
<br /> PUMP ELECTRICAL BELOW POSITION RECORD: UDC SUMP SENSORS, TANK SUMP SENSORS, ANNULAR SENSORS
<br /> DISTRIBUTION CONTROL GN[, WEATHERPROOF J-BOX IN TURBINE/FILL SUMP STANDARD 'LAND PLANNING AND DESIGN SPECIALISTS'
<br /> CENTER LEAK 1 — DISPENSER_LjZL�Ump 5- UNLEADED REGULAAJR1 ULR TURBINE SUMP 18215 72ND AVENUE SOUTH
<br /> DETECTION 2-- DI�PENS T 9
<br /> 115V LR # 314SUMP 6- UNLEADED REGULAR 1 UL,.R FILL SUMP KENT, WASHINGTON 98032
<br /> -- DISPENSLRA § SUMP REGULAR 1 (ULK__ANULAR (425) 251-6222
<br /> SUMP 4- DISPENSER LIZ,� SUMP UNLEADED REGU�� ULR
<br /> NELRRN- 8- AUDIBLE HORN ........ ........ TURBINE/FILL 3
<br /> _j MODULE TYPE: PROBE INTERFACE SENSOR MODULE TURBINE SUMP
<br /> TYPICAL AT T_5�,`TTION RECORD: TANK LEV TUG E�_ ........
<br /> MAG PROBE LOCATED ALL TANKS NO. DATE REVISION DESCRIPTION
<br /> WEAFHERPROOF I-BOX IN FILL SUMP I UNLEADED REGi���ULR ATG 1 - SPARE
<br /> ND
<br /> G
<br /> U(� TO MOTOR TANK UNLEADED 2- SPARE
<br /> ORGf t*MV --A-!
<br /> J L, LEVEL 3- UNLEADED REGULAR 11 �I I I l�..R) ATG 3-- SPARE -------
<br /> RED� -.1- — L2\
<br /> GAUGING 4- UNLEADED PREMI LP ATG 4- SPARE
<br /> ------------- —------
<br /> m" MODULE TYPE: PL_LD INTERFACE MODULE
<br /> TOT—ITION TlN`E PLI-D
<br /> PLLD SENSOR PRESSURE 1 -UNLEADED REGULAR*ULR PLLI - SPARE
<br /> RIGID CONDUIT FROM Lp 5�
<br /> EACH TANK WEATHERPROOF JBOX IN TURBINE SUMP
<br /> -UNLEADED PREMIUM ULP PLID 6-- SPARE 5
<br /> - 3-SPARE 7 - SPARE
<br /> _J--�0�1_ DETECTION
<br /> + LINE LEAK 8 - SPARE
<br /> TURBINE Ai
<br /> -----___--- I F-
<br /> SLIMP GROUND Eel I-E
<br /> SPARE-T ULR = UNLEADED REGULAR
<br /> CONDUCTOR
<br /> SENSOR WIRING SHALL BE IN'TRINSCALLY ULP = UNLFADED PREMIUM
<br /> SAFE WIRING BELDEN CABLE 88760 FOR ULM = UNLEADED MID GRADE 4
<br /> EACH SENSOR/PROBE (TYP.)
<br /> ...........
<br /> EXAMPLE CONFIGURATION: Ld
<br /> ................. ..................... ................................................................................................. ........... ........................... ...... ....... S FA L.. 0
<br /> A STATION WITH 4 DISPENSERS AND 3 TANKS ULR, ULM, ULP
<br /> ............ ESSIPAI fl,
<br /> C)
<br /> I.............. ...................... .......... ............................. .......................................... TO Ism 4
<br /> ........ CONFIGURE CONSOLE IN THE FOLLOWING ORDER STARTING WITH Ll AND
<br /> .............. 11%1.�
<br /> MOVING PRODUCTS UP IN ORDER TO AVOID GAPS IN WIRING THE MODULES
<br /> CID
<br /> AND PROGRAMMING, IF SOME PRODUCTS DON'T EXIST, (E.G. IF MIDGRADE CJ HAV`10 "AU�R�`
<br /> H,
<br /> 'TANK NOT PRESENT, MOVE PREMIUM TANK UP IN ORDER)
<br /> HIGH VOLTAM
<br /> JUNCMN BOX
<br /> IN INSTALLATION AND USE OF THIS PRODUCT, Ll: DISPENSER 1 -2
<br /> J� FWAR—NING" DISCONNECT ALL POWER BEFORE MAKING AN VEEDER-Roar TL-S--350 NOTES
<br /> 0
<br /> COMPLY WITH THE NATIONAL, ELECTRICAL CODE: FEDERAL,
<br /> ONS TO PREVENT DEATH, SERIOUS INJURY, Al" 6/30 134 0
<br /> ............................... .......... L2: DISPENSER 3-4
<br /> C / v J \, Ld
<br /> EXPLOSION OR ELECTRICAL SHOCK. MONITOR MUST NEVER BE 1. WIRING TO PROBES, SENSORS, & PLLD MUST BE SHIELDED L4: DISPENSER 7-8
<br /> STATE AND LOCAL CODES. IN ADDITION, TURN OFF POWER L.3: DISPENSER 5-6
<br /> AND TAKE OTHER NECESSARY PRECAUTIONS DURING OPERATED UNLESS THE FRONT COVER IS CLOSED OVER THE
<br /> MULTI-STRAND, GAS AND OIL RESISTANT SIZES FROM AWG #18 TO AWG L5: REGULAR lJLR TURBINE SUMP F'
<br /> INSTALLATION, SERVICE AND REPAIR TO PREVENT PERSONAL BARRIER TERMINALS IN THE INTRINSICALLY SAFE AREA. #14, BARRIER GROUND WIRING MUST BE AWG #12 OR LARGER. L6: REGULAR UlL.R FILL SUMP
<br /> INJURY, PROPERTY LOSS AND EQUIPMENT DAMAGE.
<br /> L7: REGULAR ULR INTERSTITIAL
<br /> 2. CONNECT WITH #12 AWG (OR LARGER) CONDUCTOR THE BARRIER L& MIDGRADE ULM TURBINE SUMP THE RECIPIENT OF THESE MATERIALS UNDERSTANDS THAT
<br /> C0FlYMGHT IN THE MATERIALS IS OWED BY BP, AND ALSO,
<br /> T�HAT THE MATERIALS CONTAIN PRIVLEGED AND CONFIDENTIAL
<br /> GROUND TO THE EARTH GROUND BUIS AT THE POWER DISTRIBUTION BUSINESS INFORMATON OF BP. ACCORDINGLY, THE
<br /> AND SO ON, ORDER SHOUL D PARALLEL PRODUCT LABELS IN IN--TANK RECIPIENT AGREES TO RETAIN THESE MATERIALS IN STRICT
<br /> CONFIDENCE AND AGREES NOT TO DISCLOSE THESE
<br /> SCOPE OF WORK NorE: IF THERE ARE ANY MASTER/SL,AVE TURBINE CONFIGURATIONS INSTALLED AT AN EXISTING PANEL. SE_TUP. SPACES IN MODULES SHOULD BE USED COMPLETELY WITHOUT MAIEIRIALS TO ANY OTHER PARTY AND FURTHER AGREES
<br /> NOT TO MAKE COPIES DF THE MATERIALS THE RECIPIENT
<br /> FACILITY (I.E. TWO UNLEADED REGULAR TANKS), PART OF THE SCOPE OF WORK FOR THE INSTALLING CONTRACOR IS DESIGNATING SPARES. AGREES TO USE THE MATERIALS ONLY FOR THE UMITED
<br /> 1 Ce) DENOTES FIELD WIRING CONNECTION USING WATERPROOF PURPOSE FOR WHICH BP HAS MADE THE MATERIALS
<br /> TO REWIRE THE CONTROL- OF THE TURBINES SUCH THAT 'THE THE VEEDER ROOT AUTOMATIC TANK GAUGES WILL AVAILA9L.E, AND RECIPIENT AGRUS TO RETURN ALL
<br /> DETERMINE WHICH TURBINE IS TO BE TURNED ON AS THE MASTER 'TURBINE IN ACCORDANCE WITH THE LEVELS OF CONNECTORS SUPPLIED WITH THE PROBE(S) AND SENSOR(S), MATERIALS TO BP ETHER UPON COMPLUON OF THE 0
<br /> THE ORDER OF THE TANK SET-UP PROGRAMMING DOES NOT NECCESSARILY INTENDED PURPOSE'tOR UPON III<REDUEST Of BP,
<br /> THE MANIFOLED TANKS. THE OPERATION OF THE "TURBINE WILL BE CONTROL-LED BY THE 1/0 COMBINATION MODULE 4. INTRINSICALLY SAFE WIRING SHALL BE INSTALLED IN ACCORDANCE FOLI OW THE ORDER OF THE TANKS AS LOCATED IN THE FIELD WHICHEVER COMES FIRSI�
<br /> AND PRESUURE LINE LEAK CONTROLLER MODULE WIRING DIAGRAM AS SHOWN IN THE ABOVE DETAIL, >_
<br /> WITH ARTICLE 504-20 OF THE NEC ANS/NFPA '70, 1990. BP DOES NOT AND CANNOT WARRANT THAT THE PLANS FOR 0-
<br /> PERROLEUM STORAGE AND DISPENSING ARE COMPLIANT WTH
<br /> ALL LEGAL REQUIREMENIS THAT EXIST OR AS THEY MAY BE
<br /> APPUED IN THE FUTURE, NOR DOES BP WARRANT THAT A
<br /> Typical Masfer/Slave Turbine Wiring Diagram 5. TO MAINTAIN INTRINSIC SAFETY AND PROPER SYSTEM OPERATION, FUE)LING STORAGE AND DEUVERY SYSTEM CONSTRUCTED IN
<br /> CONFORMITY VATH THESE PLANS NLL BE FREE OF ALL
<br /> PROBE AND SENSOR WIRING MUST BE INSTALLED WITHIN SEALED LEAKS. YOU ARE ACCORDINGLY STRONGLY fNCOURAGED TO
<br /> CONSUIJ WTH A FLIELING STATON ENGINEER OF YOUR C()
<br /> SCALE: NTS CONDUIT, CHOOSING To INDEPENDIENTLY EVALUATE WHETHER THESE 0
<br /> PLANS ARE.YRULY'AJMCIF.NT FOR CONSTRUCTINIG'nHE 0
<br /> STORAGE".AND DELIVERY SYSTEV AT YDUR STATION,
<br /> 6. ELECTRICAL RATING POWER INPUT -- 120VAC, 50/60 HZ, 600 DEVELOPMENT INFORMATION:
<br /> WATTS MAX.
<br /> `2
<br /> UNDERGROUND STORAGE Q>
<br /> 7. REFER TO "SITE PREPARATION AND INSTALLATION INSTRUCTIONS," TANK STANDARDS E
<br /> MANUAL NO, 576013--879 OR LKI'EST VERSION FOR ACTUAL LOCATION 1�1
<br /> Q)
<br /> OF CONDUIT ENTRY INTO TLS-350 MONITOR. EVR PHASE 11 WITH ISD
<br /> 8. REFER TO LINE LEAK DETECTOR "SITE PREPARATION AND V-8.0 2008 SERIES C)
<br /> C.T1
<br /> INSTALL)VTION," MANUAL NO, 576013-90? OR LAI-EST VERSION, CALIFORNIA MARKET
<br /> N
<br /> 9. RS--232 MODULE IS LOCATED IN THE COMMUNICATIONS _!iii A6ffE!FS-
<br /> COMPARTMENT AND MUST BE ORDERED SEPARATELY.
<br /> 800 E KETTELMAN LN
<br /> 10. BONDING LOCKNUTS AND OR BONDING BUSHINGS SHALL BE USED
<br /> AT ALL CONDUIT ENTRANCES TO THE TLS-350 ENCLOSURE AND AT ANY LODI , CA
<br /> 0
<br /> JUNCTION BOX/WIRING TROUGHS IN THE NON-HAZARDOUS AREA TO Q
<br /> ENSURE POSITIVE CONDUIT GROUNDING,
<br /> FACIL11Y No. 02076
<br /> 11. NO SPLICING OF PROBE/SENSOR WIRE EXCEPT AT THE DEVICE
<br /> ITSELF.
<br /> _�M�FD B�-___j_p_/()V A'LLIANCE Z&DM:
<br /> Ld
<br /> -------------------------- (n
<br /> 12. CONTRACTOR MUST COMPLY WITH ALL THE TRAINING CHECnD Or OV BP REPM: <
<br /> REQUIREMENTS OF VEEDER-ROOT, -
<br /> DkA 13� ip ALLIANCE PM:
<br /> 13. SPECIFIC PROGRAMMING FOR VEEDER ROOT TLS-350 CONSOLE V.,8.0 PROJECT NO, 0
<br /> SHALL BE OBTAINED FROM THE LOCAL ENVIRONMENTAL COMPLIANCE 0
<br /> BCE #13412
<br /> MANAGER.
<br /> _6RiWNG TITCE-
<br /> 14. IN THE MASTER/SLAVE TURBINE SETUP SHOWN, IT IS THE DESIGN ELECTRICAL FUELING WIRING
<br /> INTENT TO HAVE THE VEEDER ROOT FIELD OUTPUT CONTROL MODULE DETAILS FOR VEEDER ROOT& 0
<br /> AND THE 4-RELAY OUTPUT CONTROL MODULE TO CONTROL THE 'TYPICAL TURBINE SET UP
<br /> STARTING OF THE TURBINES. THE LIEVEL OF THE TANKS WILL- DICTATE (EVIR PHASE Il RETROFIT PROGRAM) -107"
<br /> WHICH TURBINE IS TURNED ON FIRST, 0
<br /> Q)
<br /> E
<br /> .T
<br /> TK3m20
<br /> 0
<br /> 0
<br />
|