SU0011119 - Laserfiche WebLink

Home Browse Search

San Joaquin Valley Air Pollution Control District PERMIT UNIT: N-3731 -1 -0 EXPIRATION DATE : 07/31 /2021 EQUIPMENT DESCRIPTION : MOTOR VEHICLE AND MOBILE EQUIPMENT COATING OPERATION WITH A DEVILBISS PAINT SPRAY BOOTH WITH DRY EXHAUST FILTERS PERMIT UNIT REQUIREMENTS 1 . No air contaminant shall be released into the atmosphere which causes a public nuisance. [District Rule 4102] 2. All painting shall be conducted in booth with filters in place, fan(s) operating, and doors closed. [District Rule 2201 ] 3 . Particulate matter (PM 10) emission rate shall not exceed 5 .3 lbs/day. [District NSR Rule] 4. VOC emission rate shall not exceed 40 .0 lbs/day. [District NSR Rule] S . No coatings, solvents, or additives containing Chromium compounds shall be used. [District Rule 4102] 6. The VOC Regulatory content of coatings, as applied, shall not exceed any of the following limits: adhesion promoter 540 g/I (4.5 lb/gal), clear coating 250 g/l (2, 1 lb/gal), color coating 420 g/l (3 .5 lb/gal), multi-color coating 680 g/1 (5 .7 lb/gal), pretreatment coating 660 g/1 (5 . 5 Ib/gal), primer 250 g/I (2. 1 lb/gal), primer sealer 250 g/l (2. 1 lb/gal), single- stage coating 340 g/l (2. 8 lb/gal), temporary protective coating 60 g/l (0.5 lb/gal), truck bed liner coating 310 g/1 (2.6 Ib/gal), underbody coating 430 g/l (3 .6 lb/gal), uniform finish coating 540 g/l (4.5 lb/gal), and any other coating type 250 g/I (2. 1 lb/gal). The VOC Regulatory content for coatings shall be defined as the VOC in grams per liter of coating (or pounds per gallon of coating), excluding water and exempt compounds. [District Rules 2201 and 4612] 7 . No person shall possess at any automotive refinishing facility, any automotive coating that is not in compliance with the VOC coating limits of Rule 4612. [District Rule 4612] 8. Only high-volume low-pressure (HVLP) spray equipment, electrostatic, brush, dip, or roll coating application equipment, or other application equipment approved by the District in writing, shall be used. All application equipment shall be operated in accordance with the manufacturer's recommendations. [District Rules 2201 and 46121 9. If an HVLP spray gun is used, the operator must demonstrate that the spray gun operates between 0. 1 and 10 pounds per square inch, gauge, (psig) air atomizing pressure, measured dynamically at the center of the air cap and at the air horns. For a gun permanently labeled HVLP by the manufacturer, a satisfactory demonstration shall either be in the form of manufacturer's published technical information or by a demonstration of the operation of the gun using an air pressure tip gauge from the manufacturer of the gun. For a gun not permanently labeled HVLP by the manufacturer, a satisfactory demonstration shall be based on manufacturer's published technical material and by a demonstration of the operation of the gun using an air pressure tip gauge from the manufacturer of the gun. [District Rule 4612] 10. For solvent cleaning operations other than for bug and tar removal, the permittee shall not use solvents that have VOC content greater than 25 g/1 (0.21 lb/gal) of cleaning material. [District Rule 4612] 11 . For bug and tar removal, the permittee shall not use any material other than bug and tar remover regulated under the Consumer Products Regulation (California Code of Regulations Section 94507 et seq.). [District Rule 46121 12. All fresh or spent solvents, waste solvent cleaning materials such as cloth, paper, etc., coatings, adhesives, catalysts, and thinners shall be stored in closed, non-absorbent and non-leaking containers. The containers shall remain closed at all times except when depositing or removing the contents of the containers or when the container is empty. [District Rule 4612] PERMIT UNIT REQUIREMENTS CONTINUE ON NEXT PAGE These terms and conditions are part of the Facility-wide Permit to Operate. Facility Name: DELTA TRUCK CENTER Location: 10182 S HARLAN RD,FRENCH CAMP, CA 95231 M-3731-n-0 : are 4mia 1953 - Mcoorvouo