COMPLIANCE INFO_2011-2013 - Laserfiche WebLink

Home Browse Search

<Sandy.Huff@valero.com> Subject: FW: 1210 East Hammer Lane, Stockton, Valero Station #3641, (591982) Tom, Sandy, Please find the below and attached information. Our invoice is not complete as of yet and we will forward as soon as it is. Please read below and advise if more information is required. This email is not complete as there is more information to follow with invoice and print outs. . I attached the Inspection reports (in case you need them). There are no print outs attached to the job we are trying to round them up. Call came in on 6/23/12 — Emergency Response — Randy Benham reports (1-1) fuel alarm, regular down. Day 1 - (6/23/12) Investigate 87 STP, found fuel coming out of secondary. Removed about 2 gallons of product. Did not see any fracture on primary, checked all Bravo pans, no fuel, locked and tagged out. PSI testing on 87 line three, 15 minute test all 3 bled down from operating pressure at about 41 psi to 6psi. Left snap tab setup in D1/2. Day 2 (6/25/12) Removed fuel from product line, removed fuel from sump. Break a part product line in STP sump to cap line, (no ball valve). Prep 4 dispensers to test. Pressure test line 20 PSI for 1 hour, dropped 2.5 PSI. Prep for helium test, helium tested and located helium at D5/6. Cleaned up site, place dispensers back in service, will return. 87 line to remain LOTO and out of service. Day 3 (6/26/12) Excavate to 87 products on D5 side, located piping, replaced with new. Replaced sections of pipe under the dispenser 5/6 as needed to correct line leak. Day 4 (6/27/12) Replaced drain valve on mid grade fill bucket. Replaced float on mid grade product in UDC rj. Tested 87 primary line at 40 PSI, tested all above with inspector he approved test on line. Tested 87 secondary line at 5PSI, repaired decay on hex nut in D1/2 (lubed o -ring). Held for 2 hours, backfilled. Day 5 (6/28/12) Installed rebar and poured concrete in front of D5. Tested 87 secondary line after concrete was placed and UDC 5/6 with inspector, both passed. Purged 87 line, third party precision tested line, passed. Cleaned up, opened 87 products up. Regards, Office 707.545.5522 Cell 707.799.7934 Santa Rosa Office 3224 Regional Parkway, 95404 ------ Forwarded Message From: "Sexton, Tom" <Tom.Sexton@valero.com> Date: Thu, 12 Jul 2012 00:34:51-0500 To: Rod Brownlee <rod@ablemaintenance.com> Cc: "Huff, Sandy" <Sandy.Huff@valero.com>, Rod Brownlee<RodBCa@servicestationsystems.com>, Sarah Molinari 2