COMPLIANCE INFO_2020 - Laserfiche WebLink

Home Browse Search

Environmental Health Department AMENDED 10/5/2020 RCRA Large Quantity Hazardous Waste Generator Inspection Report Date: August 31, 2020 Facility Address: 1325 EL PINAL DR, STOCKTON Facility Name: METAL FINISHING SOLUTIONS - STOCKTON SUMMARY OF VIOLATIONS (CLASS I, CLASS II, or MINOR - Notice to Comply) RemarksItem # (4) If the source of the release was a leak to the environment from a component of a tank system without secondary containment, the owner/operator shall provide the component of the system from which the leak occurred with secondary containment that satisfies the requirements of section 66265.193 before it can be returned to service, unless the source of the leak is an aboveground portion of a tank system. If the source is an aboveground component that can be inspected visually, the component shall be repaired and may be returned to service without secondary containment as long as the requirements of subsection (g) of this section are satisfied. If a component is replaced to comply with the requirements of this subsection, that component shall satisfy the requirements for new tank systems or components in sections 66265.192 and 66265.193. Additionally, if a leak has occurred in any portion of a tank system component that is not readily accessible for visual inspection (e.g., the bottom of an inground or onground tank), the entire component shall be provided with secondary containment in accordance with section 66265.193 prior to being returned to use. (g) Certification of major repairs. If the owner or operator has repaired a tank system in accordance with subsection (f) of this section, and the repair has been extensive (e.g., installation of an internal liner; repair of a ruptured primary containment or secondary containment vessel), the tank system shall not be returned to service unless the owner/operator has obtained a certification by an independent, qualified, professional engineer, registered in California, in accordance with section 66270.11(d), that the repaired system is capable of handling hazardous wastes without release for the intended life of the system. This certification shall be submitted to the Department within seven days after returning the tank system to use. CORRECTIVE ACTION: Immediately fix the leaking pump. Provide a corrective action statement and supporting documentation to the San Joaquin County Environmental Health Department (EHD) within 30 days. This is a Class II violation. 605 CCR 66262.34(f) Failed to completely label containers or portable tanks of hazardous waste. OBSERVATION: Hazardous waste containers were observed on-site with incomplete labeling. The containers were: -One white plastic 275 gallon tote of waste aluminum filters was observed east of the process line without hazardous properties on the label. REGULATION GUIDANCE: All hazardous waste containers shall be marked with the following information: the words Hazardous Waste, name and address of generator, hazardous properties, physical state, composition (contents), accumulation start date CORRECTIVE ACTION: Immediately label the containers as required for hazardous waste. Provide a corrective action statement and supporting documentation to the San Joaquin County Environmental Health Department (EHD) within 30 days. This is a Class II violation. Overall Inspection Comments: An inspection report was provided to the facility operator on September 3, 2020. The report was amended and replaces the initial report. Complete and submit a copy of the Return to Compliance Certification form to the EHD with a statement FA0024706 PR0543517 SC001 08/31/2020 EHD 22-03 Rev. 9/16/2020 RCRA Large Quantity Hazardous Waste Generator OIRPage 15 of 16 1868 E. Hazelton Avenue | Stockton, California 95205 | T 209 468-3420 | F 209 464-0138 | www.sjgov.org/EHD