WORK PLANS - Laserfiche WebLink

Home Browse Search

Standard features Engine details • Mechanical governor adjustable from service side Model: Cummins Onan OHV EH65V gasoline engine • Cummins Onan OHV engine Design: 4-cycle, OHV, 90-degree V-twin • Pressurized thru flow cooling system Cylinders: 2 • 4-point mounting system with coil spring vibration Bore: 80 mm isolators Stroke: 65 mm • Universal mounting tray with structural capability to Displacement: 39.8 in3(653 cm3) support the generator set in commercial mobile applications Compression ratio: 8:1 • integral USDA Forest Service-approved spark-arrestor Oil capacity: 2.0 qt(1.9 L) including filter muffler Power(max): At 2880 r/min: - Gasoline-fueled models: • Integral control box 14.0 hp- LP-fueled models: 11.6 hp • Instant one-touch stop switch Cooling: Centrifugal blower, generator set mounted for • Electronic ignition high effectiveness, pressurized system, vertical flow • Self diagnostic capability Cooling air volume: 60 Hz: 500 W/min (14.2 m3/min) • Hour meter at 2880 r/min. Air flow includes engine, generator set and • Battery charging - 5 A control cooling air flow • Remote disable/continuous stop Fuel system: • Start and run without AC output- engine run only Replaceable dry element air cleaner • Enclosed muffler provides noise reduction and ease of . Gasoline -sidedraft carburetor installation Electronic fuel pump with positive fuel shutoff(3 psi), • WaterpSound-roof ated housing maximum fuel lift 3 ft(0.9 m), Automatic choke with • Waterproof remote connector vacuum pull-off • Heavy-duty solenoid shift starter Combustion air volume: 60 Hz: 18.9 ft:/min • Fuel filter (0.53 m3/min)at 2880 r/min • Spin-on, low oil filter . LPG -sidedraft mixer with demand regulator • Low oil pressure protection • Over/under speed protection Combustion air volume: 60 Hz: 18.3 ft3/min• Low power factor field overcurrent protection (0.51 m3/min)at 2880 r/min • Digital voltage regulation Starting system: Remote, 12 V, negative ground; • Hydraulic pump standard on some models automotive type starter with steel pinion and ring gear, • 10 ft generator set output lead automatic start disconnect, connector for remote start cable, start-stop rocker switch mounted on set control Ignition system: Electronic magneto type with resistor plugs Lubrication: Full pressure positive displacement lube oil pump, spin-on, full-flow lube oil filter, low oil pressure shutdown, dipstick Cylinder crankcase: Alloy aluminum with iron cylinder liners cast into the block, aluminum oil base Cylinder head: Aluminum, OHV, removable Typical fuel consumption Gasoline, Gal/hr(L/hrl No load 1 Half load Full load 7.0 HGJAE 0.42(1.6) 0.73(2.8) 1.22(4.6) LP Vapor,Gal/hr(L/hr) 6.5 HGJA>Er 0.52(1.95) 0.90(3.4) 1.5(5.9) Alternator details improved waveform; Class 200 quadrature wire with 70% Design: Cummins Onan, revolving field,AC, 2-pole self- more insulation over comparable generator sets excited, two bearing design Excitation: Capped, digital voltage regulation Insulation system and temperature rise: Meets DC brushes: Electrographic; long life requirements of NEMA MG-1 and CSA C22,2, Std. 100 gearing: Double-sealed pre-lubricated ball bearings Motors and Generators Generator set performance Cooling: Direct drive centrifugal blower, cast aluminum Hydraulic pump housing for excellent heat transfer . Fixed displacement gear pump, 1.8 Gal/min at 2500 psi Rotor: Laminated electrical steel assembly press-fitted . Hydraulic pump is rated with the pump idle to shaft, balanced; heavy insulated copper wire windings; .When using a non-Cummins Onan pump supplied by the optimized air gap for improved waveform and motor customer,the hydraulic pump shaft seals must be capable starting; Class 200 magnet wire of operating in a temperature environment of 225° F to Stator: Laminated electrical steel assembly, skewed for 250°F.Seal failure will result in equipment damage Frequency regulation No load/Full load 5.0% Frequency regulation Constant load 1.7°/o Voltage regulation No load/Full load 2.0% Voltage regulation Constant load 1.70/6 Performance you rely on." cumminsonan.com 02016 Cummins Power Generation Inc. I A-1441 k (8115)