COMPLIANCE INFO_2024 - Laserfiche WebLink

Home Browse Search

A dOAQU1N Environmental Health Department COUNTY CP22 - AST Non-Qualified Inspection Report Facility Name: Facility Address: Date: OM SCOTT&SONS/HYPONEX CORP 23390 E FLOOD RD, LINDEN Jul 10 2024 SUMMARY OF VIOLATIONS (CLASS I,CLASS II,or MINOR-Notice to Comply) Item# Remarks REGULATION GUIDANCE: (c)(2)Construct all bulk storage tank installations (except mobile refuelers and other non-transportation-related tank trucks)so that you provide a secondary means of containment for the entire capacity of the largest single container and sufficient freeboard to contain precipitation.You must ensure that diked areas are sufficiently impervious to contain discharged oil. Dikes, containment curbs, and pits are commonly employed for this purpose. You may also use an alternative system consisting of a drainage trench enclosure that must be arranged so that any discharge will terminate and be safely confined in a facility catchment basin or holding pond. CORRECTIVE ACTION: Immediately ensure that SPCC adequately discusses all applicable bulk storage containers, including compatibility with material stored and conditions of storage, and description of sized secondary containment capable of containing the largest single container and sufficient freeboard to contain precipitation. This is (Minor)Violation. 59 Code of Fed Regulations 112.7(a)(1), 112.8(c)(8)4010056-SPCC adequately describes overfill prevention methods, and devices/systems used for each container. OBSERVATION: The Spill Prevention, Control, and Countermeasure(SPCC) Plan failed to adequately describe the overfill prevention methods, including a description of the devices or systems in place for each container to prevent overfills. -The SPCC plan states that the 10,000 gallon diesel tank is gauged and ullage is calculated as part of the fueling procedure. During the inspection, I was informed there was a sensor installed per the 2018 20-year tank inspection recommendation. -The SPCC plan also states that"All other fueling on site will be monitored by a trained plant employee"but does not discuss overfill prevention methods. REGULATION GUIDANCE: 112.7 (a)(1) Include a discussion of your facility's conformance with the requirements listed in this part[§112.7]. 112.8(c)(8) Engineer or update each container installation in accordance with good engineering practice to avoid discharges. You must provide at least one of the following devices: (i) High liquid level alarms with an audible or visual signal at a constantly attended operation or surveillance station. In smaller facilities an audible air vent may suffice. (ii) High liquid level pump cutoff devices set to stop flow at a predetermined container content level. (iii) Direct audible or code signal communication between the container gauger and the pumping station. (iv) A fast response system for determining the liquid level of each bulk storage container such as digital computers,telepulse, or direct vision gauges. If you use this alternative, a person must be present to monitor gauges and the overall filling of bulk storage containers. (v)You must regularly test liquid level sensing devices to ensure proper operation. CORRECTIVE ACTION: The SPCC plan shall adequately address overfill prevention methods, including a description of the devices or systems in place for each container to prevent overfills. Provide proof of correction to the EHD. This is (Class 2)Violation. 61 Code of Fed Regulations 112.8(c)(8)(v)4030022-Liquid level sensing devices regularly tested to ensure proper operation. OBSERVATION: Liquid level sensing devices for all containers have not been tested. REGULATION GUIDANCE: (c)(8)(v)You must regularly test liquid level sensing devices to ensure proper operation. CORRECTIVE ACTION: Liquid level sensing devices must be installed in accordance with CFR 112.8 and shall be FA0005674 PR0537051 SCO01 07/10/2024 EHD Rev.12/06/2021 Page 6 of 8 CP22-AST Non-Qualified OIR 1868 E. Hazelton Avenue I Stockton, California 95205 1 T 209 468-3420 1 F 209 464-0138 1 www.sjgov.org/EHD