|
C A P I T 0 L A V E N U E
<br />P E T R 0 L E U M E L E C T R I C A L S I T E P L A N
<br />SCALE : I" = 10'
<br />(USE GRAPHIC-, SCALE FOR REDUCED PLOTS)
<br />0 10 20 40
<br />5i
<br />KEYNOTES (x)
<br />PROJECT DESCRIPTION - REPLACE EXIST, ELECTRICAL COMPONENT46 REaUIRED, EXIST, ciRcuri6 TO REMAIN.
<br />1. EXl,5TlN(.-3 SERVICE MAIN, ELECTRICAL PANEL, CIRCUIT 5REAKER,5, TO REMAIN,
<br />2. REFLAGE EXI&T. FE-TROLEUM GONTROL5, AS REQUIRF_[�. IN5TAL.L NEW FETROL, IRELATED CCNI-.7UIT, CONDUCTORS, 6EALOFF5,
<br />ETC., A 6 REQUIRED, PER MNFR. RECOMMENDAVONS,
<br />3. EXI51'. MONITORING FAN L. INSTALL NEW MONITORING GOMFONFNrs,A6 APFLIC,45LE, PER MNFR. RECOMMENDATION5.
<br />4, NEW EMERGENCY 5HUTOFF (E,6.0.). SEE ALSO PETROLEUM SITE PLAN.
<br />F;1. NOT USED,
<br />(0 ALL GONDUrra AT TRAFFIC APER 6 TO [5E 5URIED A MIN, OF 24'' (12" AT NON -TRAFFIC, ARE45).
<br />1 NEW (N) I" C, FOR 5.T.F. (5U5MEI`--,GED TURINE PUMP) W/ (2) "10'5 ANr.� (1) 010 GOND,, MIN.
<br />5 (N) I" C. HOMERUN TO WIREWAY W1 3/4" LOOPED FOR, SUMP FLOAT 5WITCHE6 AND TAN< GAUC:sE PROBES (3/4" HOME UN O,<i IF
<br />NOT LOOPED).
<br />9. (N) 3/4" C. HOMERUN TO WIREWAYFOR D16PEN6ER H.V,1 T"r'fm,, WIRE PER MNFR. REQUIREMENT5.
<br />10, (N) 3/4'' C. HOMERUN TO WIREWAYFOR DISPENSER L.V., "ryP.. WIRE PER MNFR. REaUIREMENT5.
<br />11, (N) 3/4" C. �40MERUN TO WIREWA`r'FOR DISPENSER FUTURE/INTERCOM, WITH FULL STRING TYF,.
<br />12. HOMERUN CIRCUIT, TYPICAL. MINIMUM (2) #12'6 AND (1) 012 GOND, IN 3/4" C. W1 MAXIMUM (3) HOMERUN ciRcurre PEP CONDUIT,
<br />NUMBER OF ARROWHEADS INDICATES NO. OF HOMERUN CIRCUITS. BRANCH CIRCUITGREATER THAN Iro FT, TO FIR5T LIGHT
<br />FIXTURE OR CUTLET 54--1ALL BE MINIMUM '110 AWG. INGREA5E WIRE AND (..-.ONDUI"r SIZE PER MNFR, AND/OR CODE REQUIREMENTS.
<br />13, REUSE (E) CONDUIT AND WIRE, AS Af=PLICA5LE, AND RECONNECT (E) CIRCUIT TO EXIT. PANEL AND CIRCUIT, FIELD VERIFY ALL
<br />(E) CONDUITS, CONDUCTORS.
<br />14. ROUTE (N) HOMERUN CONDUITS BELOW CONCRETE VIA (N) 8AWCUT,A5 REQUIRED. 45 REQUIRED, AW UT (E) CONCRETE AND
<br />REF(.')UR TO ORIGINAL CONDITIONS TO ROUTE (N) UNDERGROUND CONDUITS TO EXIST, PANELS AND CONTROLS,
<br />15. PULL 5AC< ALL WIRING TO YARD EQUIPMENT IN HAZARDOUS LOCATION ,AND REFULL ALL NEW WIRING SUCH THAT' NEW WIRING
<br />15 UN5FLICED TO (N) EAL-OFF FITTINGS LOCATED INSIDE OF BUILDING. FIELD VERIFY ALL (E) CONDUITS,
<br />1&. IF NEW FULL15OX NEEDED, 6ET (N) BELOW GRADE, FLUSH, TRAFFIC RATED PULL50X.
<br />1_1. LOCATE SEAL -OFF FITTINGS PER 14AZARDCU6 LOCATION SPEC IF ICAT [ON5, TH16 SHEET, FOR CIRCUITTO D16PEN5INGAPER AND
<br />UNDERGROUND FUEL TAN<6/ A6 AFFILICA5LE.
<br />la PROVIDE (CONSULT OWNER PROVIDED EQUIPMENTL16T) AND/OR PROVIDE AND IN6TALL ADDITIONAL 6Y TEM COMPONENT15,45
<br />REQUIRED TO PROVIDE A COMPLETE, WORKABLE 6'Y" TEM PER MNFP. AND CODE REQUIREMENTS.
<br />1121, (2) NEW 3/4" C. FOR FUTURE, FROM VENT RISERS / RAC< TO WIREWAY, STU5/C,4f=, W/ 5EAL--OFF5 A5 REOUIRED,,450VE PAVING.
<br />INSTALL W1 PULL STRING.
<br />20. (1) NEW 3/4" C. FOR. FUTURE, FROM VENT CONTAINMENT / TERt[INATION TO WIREWAY, INSTALL W1 PULL 5TRING AND SEAL -CFF$ AS
<br />REQU IRE D,
<br />21, CONDUIT, RUN& ARE INTENDED AS SCHEMATIC. FIELD CONDITIONS AND 5TANDARD PRACTICES MAY DICTATE-'- MIFFERENCES,
<br />HAZARDOUS LOCATION SPECIFICATIONS
<br />A, PROVIDE EXPLOSION PROOF JUNCTION LOX AND 5E,4L-OFF FITTING,15 FERARTiGLE 14 OF THE NEC FOR HAZARDOUS
<br />LOCATION6.
<br />D. ALL, CONDUIT ANIL.) WIRING TO FUEL DISPENSERS AND 6U5MER515LE PUMP' 6 SHALL 5E INSTALLED AND USED IN ACCORDANCE
<br />WITH FLAMMABLE AND (_-cm5uaTI5LE LIO)UID5 CODE NFfOA 30 AND APPLICAeLE PROVISIONS OFTHE LATEST EDITION OF TIT'
<br />NATIONAL ELECTRIC CODE NFPA -10, ARTICLE 514, GASOLINE D15PEN51N`,T. AND SERVICE STATIONS INCLUDING THE FOLLOWING;
<br />PROVIDE EX'LO eION FROG F/51EAL-OFF FITTINGS ON ALI- POWER SUPPLY LINE5 LOCATED AT FUEL DISPENSERS, eU5MEReI5LE
<br />PUMPS AND ANY OTHER ELECTRICAL EaUlf=1`IENT LOCATED IN A 20' RADIUS OF THE GA501-INE FUEL- D16FEN51ER 15LANr.). AN
<br />AREA PER FIGURE 1, TA LE E514-2 OF THE NEC 15 DEFINED AS A HAZARDOU5 LOCATION WITHIN A 20' RADIUS FRam THE ENE) OF
<br />EACH DISPENSER. ALL ELECTRICAL EQUIPMENT AND WIRING WITHIN THIS AREA SHALL 5E PER NEC 514,
<br />C. AN APPROVED eEAL (EXPLOSION PROOF SEAL -OFF FITTING) SHALL BE PROVIDED IN EACH CONDUIT RUN ENTERING OR
<br />LEAVING A DISPENSER OFA ANYCAVITIES OR ENCL06URE5 IN DIRECT C_')MMUNIC4TION THEREWITH, THE SEALING FITTING SHALL
<br />BE THE FiR51, FITTING AFTER THE CONDUIT EMERGES FROM THE EARTH OR CONCRETE-:, ADDITIONAL SEALS SHALL 5E
<br />PROVIDED AT BOUNDARIE5 IN ACCORDANCE WITH NEC SECTION 501-5(AX4)AND (5X2) AF:PLY'ING TO DOTH HORIZONTAL AS
<br />WELL AS VERTICAL 5OUNDARIES OF CLASS I LOCATIONS.
<br />D, PROVIDE EXPLOSION PF OOF/5EAL-OFF FITTINGS AT THE POINT OF CONDUIT 5TUBUF' ENTRANCE (AT PANELE30ARD) INTO THE
<br />SERVICE BUILDING FOP ALL POWER SUPPLY CONDUITS TO FUEL D15PEN,51ERS, 5UBMER815LE PUMPS AND OTHER ELECTRICAL
<br />EC UIPMENT LOCATED IN THE ,4 0V DEFINED HAZARDOUS LOCATIONS..
<br />E. ALL ELOW GRADE CONDUIT RUNNING THROUGH (ENTERING OR LEAVING - THEN THE ENTIRE CONDUIT RUN SHALL 5E RGS) THE
<br />CLAe5 I D MESION I HAZARDOUS LOCATION AS DESCR15ED 45OVE ANE) A5 DEFINED PER NEC ARTICLE 514 5HALL_ 5E RG5.
<br />RIGID NON-METALLIC CONDUIT (PVC) MAY ONLY DE USED AS LONG A5 THE PROVISIONS OF NEC ARTICLE 514-0 EXCEPTION NO.
<br />2 ARE STRICTLY ADHERED TO INCLUDING THE REQUIREMENTS FORAN EQUIPMENT GROUNDING CONDUCTOR IN THE RIGID
<br />NON-METALLIC CONDUIT AND THE EC UIFIMENT GROUNDING CONDUCTOR MUST BE 5ONDED TO THE EXPL06 ION -PROOF RACEWAY
<br />6"I"51"EM INESIDE THE DISPENSER (THIS, MAY 5E Accc)mF:,Li5i-IED 5yTERmINATING THE EaUIPMENT GROUNDING CONDUCTOR ON
<br />THE GROUND SCREW PROVIDED IN THE JUNCTION 5OX). WHERE RIGID NON-METALLIC CONDUIT 15 USED IT SHALL BE BURIED A
<br />MINIMUM OF 2'-0" F3ELOW EARTH AND THREADED RIGID METAL CONDUIT SHALL BE USED FOR THE LAST 2 FEET OF THE
<br />UNDERGROUND RUN TO EMERGENCE OR POINT OF CONNECTION TO THE 45OVE GROUND RACEWAY.
<br />R EACH CIRCUIT LEADING TO OR THROUGH A DISPENSING PUMP SHALL 5E PROVIDED WITH A SWITCH TO DISCONNECT
<br />81MULTANEOUSL�I` FROM THE SOURCE OF SUPPLY ALL CONDUCTORS OF THE CIRCUIT INCLUDING THE GROUNDED CONDUCTOR,
<br />G� Tk?E METAL- PORTION OF DISPENSING PUMPS, METAL RACEWAY5 AND ALL NON-CURRENT'GARRYING METAL PARTS OF ELECTRIC
<br />EQUIPMENT, REGARDLE5e OF VOLTAGE $HALL 5E GROUNDED A5 PROVIDED IN NEC, ARTICLE 2 0.
<br />CLASS 1. GROUP D LOCATIONS - SERVICE STATIONS
<br />UNDERGROUND TANK
<br />FILL OPENING
<br />D IV, I ANY PIT, BOX, OR' SPACE 5ELOW GRADE LEVEL, ANY PART OF WHICH 15 WITHIN THE DIVISION I OR, 2 CLA661FIED LOCATION,
<br />DIV. 2 UP TO 16 IN, 45OVE GRADE LEVEL WITHIN A HORIZONTAL RADIU',5 OF 10 FT, FROM A LOOSE FILL CONNECTION AND WITHIN
<br />A HORIZONTAL RADIUM OF 5 FT. FROM A TIGHT FILL CONNECTION.
<br />VENT - DISCHARGING UPWARD
<br />DIV. I WITHIN 3 FT. OF OPEN ENE) OF VENT, EXTENDING IN ALL DIRECTIONS.
<br />DIV. 2 SPACE 5ETWEEN 3 FT. 4ND 5 FT, OF OPEN END OF VENT, EXTENDING IN ALL DIRECTIONS.
<br />D 16PEN5 ING DEVICE - PITS
<br />DIV. I ANY PIT, 50X, OR SPACE 5FLOW GRADE LEVEL,AN`r' PART OF WHICH 15 WITHIN THE DIVISION I OR 2 CLA5,51FIED LOCATION.
<br />DISPENSING DEVICE - r.)(5FEN6ER, OUTDOOR
<br />DIV2 WITHIN, 16 IN, HORIZONTALLY IN ALL DIRECTIONS EXTENDING TO GRADE FROM (1) THE D15PENC-ER ENCLOSURE OR
<br />(2) THAT PORTION OF THE DISPENSER ENCLOSURE CONTAINING LIQUID HANDLING COMPONENTS,
<br />SPACE CLASSIFICATION INSIDE THE DISPENSER ENCLOSURE 15 COVE -RED IN ''Power Operated DIspersire Devices For
<br />Petroleum Products",AN5VUL Sl -IIB IBO,
<br />DIV2 UP TO 15 IN.,45OVE GRADE LEVEL WITHIN 20 FT. HORIZONTALLY OF ANY EDGE OF ENCLOSURE.
<br />REMOTE PUMP - au"rDaaR
<br />DIS'. I ANY PIT, BOX, OR SPACE 5ELOW GRADE LEVEL IF ANY PART 16 WITHIN HORIZONTAL DISTANCE OF 10 FT. FROM ANY
<br />EDGE OF FIUMFI
<br />DIV. 2 WITHIN 3 FT. OF ANY EDGE OF PUMP, EXTENDING IN ALL DIRE-CTION5. ALSO UP TO I& IN4F5OVE GRADE LEVEL WITHIN
<br />10 FT. HORIZONTALLY FROM ANY EDGE OF PUMP.
<br />z
<br />x
<br />fil 0 0 x
<br /><T 'I
<br />ul CA
<br />zw
<br />-
<br />j X
<br />> c(I
<br /><[
<br />A LL 0
<br />Lu
<br />c()
<br />w x
<br />D
<br />Se
<br />. 0
<br />an
<br />Uj Mj
<br />U.
<br />C())
<br />cq
<br />\D
<br />Nt
<br />I
<br />"IN
<br />x
<br />WHEMPAROM
<br /><T 'I
<br />ul CA
<br />zw
<br />ul
<br />wwwoo
<br />> c(I
<br /><[
<br />A LL 0
<br />Lu
<br />c()
<br />> Ix
<br />D
<br />LU (5
<br />:c 0.
<br />an
<br />Uj Mj
<br />U.
<br />C())
<br />cq
<br />\D
<br />Nt
<br />f --
<br />LLJ
<br />-A
<br />2
<br />Uj
<br />LU
<br />wM
<br />w .j
<br />0 Ifj
<br />0
<br />0. Uj1fl
<br />bY Q__ 0
<br />(y,
<br />0
<br />-T <[ 9_I(yj
<br />I
<br />-w
<br />q
<br />"IN
<br />x
<br /><T 'I
<br />ul CA
<br />zw
<br />ul
<br />wwwoo
<br />> c(I
<br /><[
<br />A LL 0
<br />Lu
<br />c()
<br />> Ix
<br />D
<br />LU (5
<br />:c 0.
<br />an
<br />Uj Mj
<br />U.
<br />C())
<br />cq
<br />\D
<br />0 :f I
<br />"IN
<br />�- v , (y
<br />z
<br />A LL 0
<br />Lu
<br />D
<br />j7_!
<br />Uj Mj
<br />T q
<br />C())
<br />0 :f I
<br />U,
<br />LLJ
<br />2
<br />Uj
<br />o Z6
<br />wM
<br />w .j
<br />0 Ifj
<br />0
<br />0. Uj1fl
<br />bY Q__ 0
<br />(y,
<br />0
<br />-T <[ 9_I(yj
<br />"IN
<br />
|