SR0080167 - Laserfiche WebLink

Home Browse Search

NON-MECHANICAL CAUTION: The improper handling of Blue Crystal and FLOW EQUALIZATION Bio-Neutralizer tablets may cause personal injury or property damage. Keep out of the reach of children and The patented design of the Bio-Kinetic system provides do not allow the tablets or feed tubes to contact skin, non-mechanical flow equalization for the Singulair eyes, or clothing. Blue Crystal tablets may be fatal if wastewater treatment plant. Equalization reduces swallowedand tablet dust is irritating to the eyes,nose incoming hydraulic surges (e.g. typical shower of 10 and throat. Do not handle the tablets or feed tubes minutes duration,bathtub discharge of 5 minutes duration, without first carefully reading the product container clothes washer discharge of 2 minutes duration and label,MSDS information and the handling and storage dishwasher discharge of 2 minutes duration)throughout the instructions. Mixing of chemicals may cause a violent system. The flow equalization provided by the Bio-Kinetic reaction leading to fire or explosion. For additional system causes wastewater to be held upstream of the final information about Blue Crystal and Bio-Neutralizer outlet during hydraulic surges,which preserves treatment tablets contact your Singulair service provider. integrity and enhances system operation. The actual rate of equalization varies and depends upon specific loading ACCESS RISERS AND COVERS patterns and the duration of each flow surge. At the design loading pattern used during the NSF/ANSI Standard 40 Concrete access covers are recommended and must be performance evaluation, the Singulair system equalizes secured after each service visit. A concrete plug should all flow an average of 50%. As a result, hydraulic surges be installed in the access openings of the tank to prevent and periods of high wastewater flow are automatically accidental entry. Access covers should be inspected during reduced to protect the environment and all treatment plant service visits and replaced as necessary. If plastic risers processes on a demand use, as needed, basis. and/or covers are utilized,they must be approved for your application and secured as instructed by the manufacturer. BLUE CRYSTAL° RESIDENTIAL Refer to state and local regulations for applicable codes DISINFECTING TABLETS that may apply to your installation. If local regulations require, an initial supply of Blue Crystal DANGER: Make sure your service provider does not disinfecting tablets will be placed in the Bio-Kinetic system leave access risers uncovered or partially covered. chlorine feed tube(s) at system start-up. Manufactured Failure to properly secure access covers could result from calcium hypochlorite, Blue Crystal disinfecting tablets in bodily injury,illness or death. Do not allow children provide effective,economical bacteria killing power. Liquid to play on or around the treatment system. entering the Bio-Kinetic system contacts the installed Blue Crystal disinfecting tablets, just downstream of the NO OWNER MAINTENANCE equalization ports. A fully charged feed tube will last an average of six months. During each semi-annual The Singulair system is inspected and serviced by a inspection, your Singulair service provider will check local,factory-trained service provider,therefore, no owner system operation and install tablets as needed. maintenance is required during the warranty period. The Singulair system does not require pumping as often as NOTE: USEPA guidelines state "On the average, a septic tank. Under normal use only the pretreatment satisfactory disinfection of secondary wastewater effluent chamber should be pumped. How often pumping is can be obtained when the chlorine residual is 0.5 ppm after necessary depends on system use. The local Singulair 15 minutes contact." Retention time must comply with the service provider will inspect the aeration chamber contents controlling regulatory jurisdiction. and plant effluent at six month intervals to determine if the pretreatment chamber is discharging excessive solids. BIO-NEUTRALIZER® DECHLORINATION Every three years, the pretreatment chamber should be TABLETS inspected. The pretreatment chamber will normally require pumping at three to five year intervals. Contact your In environmentally sensitive areas,regulations may require the local service provider prior to tank pumping for complete use of Bio-Neutralizer dechlorination tablets. Manufactured information on removal of equipment, access to individual to chemically neutralize both free and combined chlorine, chambers and coordination of services. A tank pumping Bio-Neutralizer dechlorination tablets provide consistent service licensed by the local regulatory agency must be reduction or elimination of chlorine residual without used for removal and disposal of tank contents. unnecessarily reducing the level of dissolved oxygen in the treatment system effluent. As liquid passes through If a period of intermittent use, or an extended period of the final discharge zone of the Bio-Kinetic system, the non-use of the Singulair system is anticipated, contact flow contacts the tablets and residual chlorine is removed your Singulair service provider for instructions. Your from the system effluent. A fully charged feed tube will service provider has comprehensive Singulair service last an average of six months. During each semi-annual instructions and has been factory-trained in troubleshooting inspection, your Singulair service provider will check procedures. Contact your service provider if you require system operation and install tablets as needed. service or information regarding tank pumping.