|
I roduc' - le: DBU-1 , Revised:03117199, Prepared:03/18/' gage 2
<br /> Intentional mla by deliberately cernceriuming aJtrf Inhaling� contents can be harmful or decomposition products during wMO,rp or flame eating.
<br /> fatal.Red—,itching,burrnin9 sanxtiw and viWl,d_diaturbacces may wdicate excessive
<br /> eye contact.Drynw,item",asckng,bwrning,r ass.and swelling are conditions
<br /> aeaodmted wntn excmwve udin contact. IFDNaeJLA VALUES.NOT&ALAI f}ICIRCATX)MI
<br /> MEDICAL CONDITIONS AGGRAVATED BY EXPOSURE:Not applicable. MUNG��' :12.48 pegrg F SOLUBILITY IN WATER:<10%
<br /> VAPOR PRESSURE:72.45 mmHg WEIGHT/GALLON(LBSJ:x.60(US.)
<br /> VAPOR OENSITY:"winner Ven air PH:Ilan appNcable
<br /> WARNING:This product contains a Chemical known to the State of %VOLATILEAVOLUME 52-74 %SOLIDS BY W8GHT:33-60
<br /> SPECIFIC ORAVfTY:1.020 EVAPORATION RATE(BuOAc-100):133
<br /> California to cause birth defects or other reproductive harm. ODOR/APPEARANCE:Vise"liquid with an odor characteristic of the aohromt listed In
<br /> '•>:+'t?AlS3?' Section 2.
<br /> •INGESTION:If swallowed,do not induce von, .Gentry wnpe out Inside mouth to
<br /> remove arty residual material. •This Product is normally,stable but may undergo hazardous reactiorm at extrmery high
<br /> •EYE CONTACT:In case of eye contact.ramose ontact lernas and riva)t eyes immexistaly temperatures aid preeaa
<br /> ttro
<br /> with a gwtfe stream of luke warm water for at t 15 mortes. .INCOMPATIBILITY(MATERIALS AND CONDITIONS TO AVOID):Avoid contact with
<br /> *SKIN CONTACT:In oase of skin contact/lush' mediately with plenty of water two strong dltatlea,wrong mineral acids,or strong omol irtg agents,
<br /> lees/15 minutes followed by weaning with soap rid ouster. .HAZARDOUS DECOMPOSITION PRODUCTS:May produce the following h ordoum
<br /> .INHALATION:If affected by inhooDon of vepw spray mist,remove to fresh aa.Appty decomposition product,when axposed to extreme heat carbon monoxide;taboo
<br /> artitldai respiration and other support maeswns as required. dioxidd;oxides,of shrminun:lows molecule weight polymer frectiaos;Extnomo heat
<br /> •OTHER:If ingestion,any type of overexposure or symptoms of averexpoewa occur dtmng includes,but Is not limited to,flame cutting,brazing,end weldi
<br /> or following the use of this product,Wnax[apoison control center.energency room or Hun rdas Materials klo nH acation System IHMISI and Nat1wW Fre Prataction Association
<br /> phyuaen immaGately;have Mstarel Safety Data Sheat information evadable. INFPAJ Ratings;
<br /> *IS Ratlrq NEPA Hating
<br /> .FLASHPOINT:27 Degrees F 1-3 Degrees C)(PENSKY-MARTE14S CLOSED CUP) ----------------------- ------•--•-----•-------
<br /> •FL.AMMAEU LIMITS:Lower ex"on limit(LEL)-1.3 HEALTH 2' HEALTH 2
<br /> •Upper explosion limit IUELI:Not available FLA14 BILITY 3 FLAWABILITY I
<br /> .EXTINGUISHING MEDIA:Use Natnornsi Firs Prot on Association(NFPAI Class B REACTIVITY I DISTMILln I
<br /> "llAgwahes icarbon dioxide,drl'chemical,or area aqueous flim forming town) Ramp Sygen:O–Mirtlmal,1-Slight.2-Moderate,3–Sarioua,4-Severe,s�Clvonic
<br /> designed to extinguish NFPA Class 1B hmmable t card fires. Efface.
<br /> .UNUSUAL FIRE AND EXPLOSION HAZAROS•Kee mis product away from heat sparks,
<br /> flame,and other sources of ignition ties•,pilot ligh alecmc motors,static elsctndtyl. Safe handling of dao product requires that ON of the information m the MSOS be evalwtad
<br /> Invisible vapors tarn travel to a uxu.of Ignition flash beck.Do not mnokm whiia
<br /> using this product.Keep contemn tightly dosed vhen not n use.Closed contalnen may for specific wok amnoorments and conditions of use.
<br /> Uuplode when overheated.Do not apoty to hot 3u.Toxic gasesm,may towhen,tura
<br /> product comes In oxttact with exrsme heat. THIS IS THE END OF THE MSDS FOR:DBU (0013861 5.001 D8U )
<br /> -SPECIAL RAE FIGHTING PROCEDURES:Water sp may be ineffective.Water spray
<br /> may be used to cook timed comsirwe to prtvnt7".:fa't:=
<br /> are poasblia
<br /> sutoigrnition w expbaion when exposed to exttwn usedtog namesere
<br /> peleaUN.Fre-fighters should wear aNf-eon[sinederNrg appratus and tWl protective
<br /> dothning.
<br /> 1
<br /> -STEPS TO BE TAKEN IN CASE MATERIAL IS RELEASED OR SPILLED Provide maxkmm
<br /> ventilation.Only Pwilwrel egasppW with PrOPe r wary,skin,and eye ptoreetlon
<br /> should be permitted In the wee.Rmove sit sour of igndan.Take up wed material
<br /> with wand,vermiculite.or other noncombwtiblei matarisi rid dace In Ueen,
<br /> mDty cnxuannet for dispossi.On)y the spillb m!b.Icd_.;pod.Ii.—d&ntc@with
<br /> absorbam should be
<br /> plead In thls tontine.
<br /> •WASTE DISPOSAL METHOD:Waste mate ial m
<br /> federal.state,prwinar.and Iocal emirwvnntal control regWalnors.Empty eonawwa
<br /> should be recvded or disposed of through an aggro ed waste meager w r fedlhy.
<br /> •HANDUNG AND STORAGE PRECAUTIONS,Do not same above 120 degrees F.(48
<br /> dageas C.I.Siwe large quamitias in bu ddi ngs designed and Protected for storage of
<br /> NFPA Cie la rlmmebla ligtkda-
<br /> .OTHER PRECAUTIONS:Vapors may COMM In Itnw areas,if this material is part of a
<br /> mWpge component system,read the Mstarie Seta
<br /> �Data SheetlU for Me other
<br /> component or components before Zrlditg es the rretldng mixture may have the hataAs
<br /> of ail of its pats.Contra nefe Should be gnoundod when pourng.Avoid fres fell of liquids
<br /> in"come of a taw inches.
<br /> ICU a '
<br /> PERSONAL PROTECTIVE EQUIPMENT FOR:
<br /> •EYE PROTECTION:Wes,cf»mic"ps aotesh or full taw shield when ppuibllity
<br /> os
<br /> exists for eye contact dto splestkng or spaying I 'd,airborne puma",or vapors.
<br /> .SKIN PROTECTION:Wes,protective cior it akin contact.Aeon and gloves
<br /> shasd be constructed of!neoprene rubber.No■ped ic petmostxxn/degradabon tested
<br /> haw time donne On pro[anxMe clothing for Mit .Reconmendatbm for skin
<br /> protection are based on infrequent contact with this Noduct.For hequem wmact or total
<br /> imma aeon,contact s manufacturer of Proteetive ciol hing for appropriate Cnemial
<br /> impervious equipment.
<br /> .RESPIRATORY PROTECTION:Overexposure to voix rs they be preveMW by ensuring
<br /> papa v i nt"110n Ci nnlrMs,vapor exhaust or freshA(ROSH-approved air
<br /> Purifying respinitw with rho appmphata entry.chemical Of a powave-preewra.
<br /> airyuopied reeprator May WO reduce eMpoers.Rep the rostannor menufarnrer's
<br /> inmtructiwu and litesture csrafuay to c:wmine the nn
<br /> flv'e.of airborne comamnenn against
<br /> which the respirator is effective.its Ikmitatiorns,aid I it Is to be properly fitted oral
<br /> used.
<br /> .OTHER EQUIPMENT:Clean contminated clotha ngfrees.
<br /> VENTILATION REQUIREMENTS:Prtrvide gwrr rlktdm or lou etdotat ventilation in
<br /> volume aid pattern to keep the concentroom of kgr s listed in Section 2 below the
<br /> lowest suggested expwtxe limits,the LEL below the aced limit,and to remove
<br /> Manufactured and Supidilied by:
<br /> 1 ' REFINISH PRODUCTS
<br /> 19699 PROGRESS DRI I
<br /> E STRONGSVILLE. OH 44136
<br />
|