COMPLIANCE INFO_2013-2018 - Laserfiche WebLink

Home Browse Search

Variable Speed Submersible Turbine Pump Specifications Liquid Compatibility • Max. Ilquid viscosity: 70 SSU at 601(IS 'C). • Variable speed models are UL and cUL listed for fuel mixtures containing up to I S% ethanol or methanol, and 20% MTBE, 20% ETRE or 17% TAME with gasoline, I? + J V:n iablc spccd (non -AG) modals can also be used with diesel fuels, fuel oils, kerosene, Avgas and jet fuels in a non -gelled pourable sate. • All wetted elastomers are made of a high grade, fluorocarbon Vicon' compound. A I Standard Features For full diagram see page 5. Power Requirements VS models can only be powered by a MagVFC` controller: • VS2 models can operate with single - or three-phase incoming power supply to the MagVFC`, • VS4 models require three-phase incoming power supply to the MagVFC"' for proper operation. • Incoming power supply to the MagVFC` can be 200-250 VAC, 50 or 60 Hz • MagVFC'" outputs a three-phase, variable frequency signal, valid for FE Petro variable speed pumps only. • VS2 max. motor draw: 9 Amps. • VS4 max. motor draw: IS Amps. • MagVFC"max. line draw: 20 Amps. Pump Motor • 2 hp or 4 hp, variable speed, two-stage centrifugal type pump motor with integral, automatic, thermal overload protection. • Max. flow: VS2 = 110 gpm, VS4 = 140 gpm. • Max. pressure: selectable operating pressure on MagVFC- between 24 psi and 42 psi deadhead. • Available with MagShell' which results in 45% increased flow area around motor. 6 • Variable speed models are available in variable and fixed length options. • Check valve: 21/4" diameter fluorocarbon Viton' seal constructed on cost aluminum body and steel backing washer. • Pressure relief valve: available in four pressure relief settings, Integral to check valve. Standard model relieves at 40 psi and resets above 35 psi. • Syphon: venturl-type syphon primer supplied with every submersible. Syphon check valve and secondary syphon sold separately. • Air eliminator: every submersible includes a tank return path with one-way check valve to provide active air elimination. • Electrical disconnect electrical yoke for positive contractor disconnect during service. Approvals • Consult factory for applicable approvals. Quality Certification • Franklin Fueling Systems is an 150 9001 Certified Manufacturer. 'Viton�' is a registered trademark of DuPont Dow Elastomers. C &US LISTED has up to five Components to define the pump being supplied as follows: SXXXt3C Y - P-- B` (I +STP- Basic Model Designation " Nota All STP models include alcohol - gasoline compatibility, variable speed and variable length as part of the base model. XXXXX - Factory Installed Options STP model designations may Include one or more of the following characters in alphabetical order: F = Floating suction adapter (I''A" NPT female adapter) K = Intake filter screen (IFS, factory Installed to PMA) M = MagShell' (flow enhancing, expanded PMA shell) A = Model R check valve (24 psi relief/22 psi reset for PLLD) W = Model W check valve (16 psi relief/ 13 psi reset for PPM4000) Note: If not otherwise specified, all STP models are supplied with standard model check valve (40 psi relief/3S psi reset for MLD and TS-LS300). Y = Pump Motor Horsepower Rating VS2 = 2 hp variable speed VS4 = 4 hp variable speed A = Model Length VL I = Variable length range # I. VL2 = Variable length range #2. VO = Variable length range #3. Note: VL2 models fit 94% of all known installations. = Riser Pipe Length Riser pipe length is expressed as two numeric characters that indicate the total length of the riser in inches. Riser pipes are available from 7" to 69" in I" increments (additional charge for risers 31"or longer). 4 11.10" t55"_ RADIUS .55"- RADIUS DISCHARGE/LEAK DETECTOR CENTERLINE 10.65' SYPHON PORT %" NPT TANK PORT %4" NPT RISER PIPE 4" NPI RISER/COLUMN PIPE CENTERLINE LINE TEST PORT V4" NPT RECEIVE ,/, OCT 18 2016 yt 10.45' RADIUSE �IRONMENTAL HES DEPARTMENT O3X0, C e PR n o U*4 RISER/COLUMN PIPE , C 1 reor CENTERLINE - +11evca 5.80" -I 12.50' LEAK DETECTOR PORT - 2" NPT DISCHARGE OUTLET 2" NPT DISCHARGE/LEAK DETECTOR CENTERLINE 4�FEsS NO. 36475 * \ EXP. 6-30-18 9� CIVI1, OF CALL% R"SION■ H z z F Py OU ? m y V Orn �.x W V x a RZOo, WJfti ZU -� zea a z z z < zw� wog�� CO) Z < , �) Q DRAWN ER DATE mMMU16 SHT nTLE UTSHEETS SHEET A3