COMPLIANCE INFO_PRE 2019 - Laserfiche WebLink

Home Browse Search

� Document Number: 909 R 5003 Document Number: 909 R 5003 Procedure Rev: 12 Date: 1/22/13 Procedure Rev: 12 Date: 1/22113 EMERGENCY RESPONSE PROCEDURES EMERGENCY RESPONSE PROCEDURES Secondary Storage Areas Generally one to two different types of petroleum based products are stored within the Lehr tube Storage Area boiler room. Storage is limited to actually that being used. Several different types of water treatment (for RO system & boiler) chemicals are also found here. The boiler Drums and pales of petroleum based products are stored here for use in and around room also has a satellite collection point for waste oil. the lehr. Generally, inventory is limited to that actually needed, Approximately, eight 55 gallon drums of different materials are in use along with several lubricants that are Batch House Storage Room Bast Butler Buildin in either 5 gallon pales or small kegs. A satellite collection point for waste oil and oily waste solids are located here. Certain materials are used as glass colorant chemicals. Stored in these locations are nickel oxide, Iron Oxide, Selenium, Soda Ash, Silica Sand, cobalt oxide, sodium nitrate, Sodium Sulfate, Titanium Dioxide, Limestone, Dolomite, and a cobalt oxide Maintenance Shop and Satellite Maintenance Cages containing mixture(material 98).When melted into the glass product,their hazardous properties are no longer manifest. The materials are purchased as dry powders in The facility has one main maintenance shop and several smaller satellite shops. The paper bags or fiber drums. main shop generally has one to six 55 gallon drums of petroleum based product as well as smaller quantities of other materials associated with the maintenance of a Hazardous Material Bulk Storage manufacturing facility. The satellite shops serve specific areas of the facility. Small quantities of petroleum Sulfur Dioxide based products may be stored in these locations. The satellite locations generally A sulfur dioxide dispensing port is located outside on the north side of the lehr. Two have several one and five gallon containers or kegs of product. A majority of the shops 500 Ib cylinders are located here, one for dispensing and one on standby.There is a have Safely-Kleen solvent based parts washers. third two 500 lb cylinder located about 50 feet away as a back up(not connected). Main Storeroom Chlorine The main storeroom is located within the main facility,just behind the general offices. Cylinders are located at each of the cooling towers and at the sanitary packaged Materials generally stored within this storeroom, aerosol cans of maintenance treatment plant. One to two 150 Ib. cylinders are usually found at the cooling tower products,small containers(half gallon,paints)of petroleum based products. south of the boiler room and east of the furnace. Two 150 Ib. cylinders serve the packaged sanitary treatment plant. Chlorine gas is used continuously to disinfect the Water Treatment Chemicals storage buildin effluent from the treatment plant and at the cooling towers. This facility is located by the !East Cooling tower 1 Marley tower, and serves as the Propane Gas storage area for chemicals that are used for water treatment.The main chemicals that are stored in this building are Hydrogen Peroxide,Tolytriazol,and Sodium Molybdate. Propane gas is used as fuel in forklifts and as standby fuel for the furnace. The main propane tank farm(standby fuel)consists of four 40,000 gallon tanks and one 30,000 gallon tank located to the rear of the facility. In addition to these,a 1,000 gallon tank is Boiler Roam located in the same area and used to fuel equipment. Document in and SettingslnlrmUcal SettingsWemporary Intemet FileskContent.OutlookUQ9W31 RY CAPA Document in and SeltinKsliltranll.ocal SettingsNremporary Internet Fi1es\Contcnt.0utiook1JQ9W3I RYTAPA CCR 66265 55.doc Page 35 of 69 CCR 66265 55.doc Page 36 or 69 Paper Copies are Not Controlled unless stamped In RED-Controlled DocumarI Controlled Version appears In Q59000 database_ Payer Copies are Not Controlled unless stamped In RED`Controlled Document,Controlled Version appear In 059000 database. Copies withouta RED"Connoged 0ocumenr stamp will be CBSCLETE 24 hours from 6111201!1:57 Pid Copies mUrouts RED Tontrolied Documenr'stamp vn0 be OBSOLETE 24 hourstrom 611177014 1:57 PN