|
CONDUIT
<br />CONDUIT
<br />SIZE:
<br />CONDUIT PURPOSE:
<br />IN
<br />WIRE
<br />PULLS:
<br />OR
<br />3
<br />ISLAND
<br />EXPANDABLE
<br />TO
<br />4
<br />ISLAND
<br />CONFIGURATIONS.
<br />(TURBINE)
<br />1"
<br />EMER. SHUT OFF REMOTE_ ALARM TO STORE
<br />(5) ##12 AWG THWN
<br />#12 GROUND
<br />- - --i
<br />OR
<br />4
<br />SPARE TO MEMBERSHIP
<br />EXPANDABLE
<br />25## PULL CORD
<br />5
<br />ISLAND
<br />-
<br />Z"
<br />PHONE FROM STORE
<br />ONLY
<br />25 PAIR CABLE
<br />----- -----
<br />ISLAND
<br />OR
<br />2"
<br />E.D.F. ROOM TO KIOSK PHONE BOARD
<br />EXPANDABLE
<br />75# PULL CORD
<br />6
<br />ISLAND
<br />CONFIGURATIONS.
<br />3/4"
<br />PHONEBOARD TO HELPLINE RHONE----
<br />OVERFILL ALARM
<br />2 PAIR PHONE WIRE
<br />WITH HORN/STROBE 120VAC
<br />9G
<br />-
<br />06
<br />'1"
<br />LOOP'_ O RIGHT WALL
<br />PETRO POWER
<br />25# PULL CORD__
<br />-70
<br />- 3/4"
<br />-
<br />TURBINE POWER
<br />(6) #12 AWG THWN,
<br />(2) #12 GND
<br />0
<br />3/4"
<br />TURBINE: POWER
<br />(6) ##12 AWG THWN;
<br />25# PULL CORD
<br />(2) #12 GND
<br />_-3/q
<br />SPARE TO VENT RACK
<br />-POWER
<br />--
<br />------
<br />---
<br />DISPENSER AND PUMP CONTROL
<br />�I�-2
<br />DISPENSER POWER AND PUMPCONTROL-
<br />T_ _j_
<br />- T-
<br />-_
<br />0
<br />-�i„
<br />1"
<br />DISPENSER POWER AND PUMP CONTROL
<br />—__-_---------
<br />C
<br />1"
<br />DISPENSER POWER AND PUMP CONTROL
<br />DISPENSER _POWER AND -PUMP CONTROL
<br />--- -
<br />--
<br />DD
<br />1"
<br />DISPENSER POWER AND PUMP CONTROL
<br />-
<br />DISPENSER DATA CARD PROCESSING
<br />02
<br />DISPENSER DATA CARD PROCESSING
<br />C3
<br />DISPENSER DATA CARD PROCESSING
<br />--
<br />-
<br />4 -
<br />DISPENSER DATA CARD PROCESSING----
<br />DISPENSER DATA CARD PROCESSING
<br />--
<br />—_.._.__..__
<br />C6
<br />---
<br />DISPENSER DATA CARD PROCESSING
<br />---- ---
<br />-------
<br />_ 20
<br />1"
<br />LOOP TO VEEDER ROOT--
<br />25# PULL CORD
<br />----- -----_.._._-4
<br />(2
<br />3"
<br />LOOP TO POWER CENTER
<br />-
<br />2
<br />2"
<br />LOOP TO DISCONNECT
<br />_ 3/4
<br />AIR/WATER RLEL W/ HEATER
<br />25# PULL CORD
<br />€
<br />2_r
<br />3/4
<br />FAGSIA LIGHTS/SIGNS
<br />zl '12. .
<br />( ) # THWN 2.#12
<br />( )
<br />GND
<br />CD
<br />1"
<br />CANOPY LIGHTS
<br />(6) ##12 THWN, (4)
<br />#12 GND
<br />L2
<br />-
<br />I„
<br />CAN OIDY LIGHTS
<br />(2).__#12 THWN, (4)
<br />#12 GND
<br />03
<br />1"
<br />W -----
<br />CANOPY LIGHTS
<br />(6) ##12 THWN, (4)
<br />:#12 GND
<br />L4
<br />1"
<br />CANOPY LIGHTS
<br />(2) #12 THWN, (4)
<br />#12 GND
<br />-
<br />27
<br />1"
<br />SPARE TO STORE
<br />25# PULL CORD
<br />-- ---
<br />mm(�,3/4"
<br />/¢
<br />FSO TO DISPENSERAREA-- -_4 _ —
<br />-
<br />(2) ##12 THWN, (1)
<br />#12 GND --
<br />29
<br />3/4"
<br />ESO TO DISPENSER AREA
<br />(2) #12 THWN, (1)
<br />#12 GND
<br />30
<br />- 3/4"
<br />LOOP TO CAMERAS
<br />(2) #12 THWN, (1)
<br />#12 GND
<br />31'
<br />1„
<br />LOOP TO RIGHT WALL
<br />(4) #12 THWN, (3)
<br />##12 GND
<br />3?
<br />i"
<br />LOOP TO RIGHT WALL (E.S.O.)
<br />(6) #12 THWN, (1)
<br />##12 GND
<br />-�3/4"-
<br />E.S.O./VEEDER ROOT ALARM Q ENCLOSURE
<br />(2) #12 THWN W(1)
<br />#12 VGND
<br />-- )
<br />1'--
<br />E.S.O./VEEDER ROOT ALARM 0 STORE
<br />(2) #12 THWN, (1)
<br />#12 GND
<br />I"
<br />TANK VEEDER ROOT
<br />(4) BELDING CABLE
<br />8760, (1) #12
<br />GRND
<br />TANK ^VEEDER ROOf--(4)
<br />BELDfNG CABLE
<br />8760, (1) #12
<br />GRND
<br />3/4"
<br />DISPENSER ^SUMP' SENSOR -
<br />(1) BELDING CABLE:
<br />8760, (1) #12
<br />GRND
<br />_38 ---
<br />3/4"
<br />DISPENSER SUMP SENSOR
<br />(1) BELDON CABLE
<br />#8760, (1) #12
<br />GND
<br />3/4"
<br />DISPENSER SUMP SENSOR
<br />(1) BELDON CABLE
<br />#8760, (1) #12
<br />GND
<br />:It 40
<br />3/4
<br />DISPENSER SUMP SENSOR
<br />() BELDON CABLE
<br />#8760, (1) ##12
<br />GND
<br />-
<br />€ --
<br />-3/4"
<br />DISPENSER SUMP SENSOR-.__ ------
<br />(1) BELDON CABLE
<br />##8760, (1) #12
<br />GND
<br />=
<br />3/4"
<br />DISPENSER SUMP SENSOR
<br />(I) BELDON CABLE
<br />,#8760, (1) ##12
<br />GND
<br />L
<br />LOOP TO INTERCOM
<br />T`I
<br />INTERCOM 1-0 DISPENSER
<br />INTERCOM To DISPENSER
<br />:5
<br />INTERCOM TO DISPENSER
<br />14
<br />INTERCOM TO DSPENSER
<br />T5
<br />INTERCOM TO DISPENSER
<br />INTERCOM TO DISPENSER---- -
<br />46
<br />KIOSK CAMERA (HV)
<br />0-2)
<br />KIOSK CAMERA (FIV)
<br />X18
<br />1"
<br />CAMERA POWER TO CANOPY
<br />(2) ##12 THWN, (1)
<br />#12 GND
<br />4J
<br />I"
<br />--.----------____.____
<br />--
<br />CAMERA TO STORE MULTI PLEXER
<br />1 COAX PER CAMERA
<br />�0---1;„-_
<br />CAMERA @ CANOPY
<br />1 COAX PER CAMERA
<br />CAMERA @ CANOPY
<br />1 COAX PER CAMERA
<br />52
<br />KIOSK CAMERA (LV)
<br />(2) #12. THWN. PER
<br />CAMERA
<br />53
<br />KIOSK CAMERA (LV) SPARE
<br />#25 PULL STRING
<br />.� r
<br />i
<br />2 106
<br />3
<br />LEFT- WALL
<br />f03
<br />CANOPY LIGHTS
<br />ON /OFF
<br />STP CONTROL
<br />ON/OFF
<br />REAR WALL
<br />CANOPY FASCIA
<br />LIGHTS ON/OFF
<br />) I
<br />c�
<br />97 �
<br />z
<br />CJ
<br />PETRO I�
<br />POWER
<br />CENTER o I
<br />(CONDUIT LOCATION UNDER
<br />VR -TLS 390 R
<br />93 !
<br />RUN CONDUIT TO HIGH
<br />OR RIGHT
<br />EXTERIOR ENCLOSURE EVOLTAGE
<br />WALL AS INDICATED
<br />ON E-1 1 !
<br />i I
<br />1 106 t 108
<br />102 96
<br />r i}
<br />94 95
<br />I II I! !
<br />RIGHT WALL
<br />ALIGN HV/LV PARTITION IN
<br />LV WIREWAY WITH HV/LV
<br />DIVISION ON VEEDER
<br />ROOT MODULE
<br />INTERCOM
<br />LOW
<br />VOLTAGE 109
<br />€
<br />6” x 6" f
<br />WIREWAY
<br />7f
<br />PHONE BOARD „ PETRO POWER CENTER U 33 HvI I I i r
<br />CONTRACTOR DISCRETION)
<br />I I CJ LV VR HV LV
<br />2 4 6 ` 8 QD2", Q4 D6 C1 C3 C521 rIT2 I4 I6 46 48 49 52
<br />��1 5 7 D13�D520 �G2�C4�C6 107 3 22 6 i 33� 20 32 31 3a 36 37 38 Q39t40 41 1€ 2
<br />i I ! 1 I I 1 �I I 1 I € I i i €I 11131151301471 501 51t 3
<br />! j j l l l 'I❑ t f l l � r l i i i l i I I f l
<br />! I € I
<br />€i III €lI l!I rf lI! ;'❑ €I II �€I �!I�! 11€ r1 i �II » 1iI l1 i1 iI iI iI i1 21 24 L4 29 30 32Cx 6l❑
<br />UPS-3KVA 2!8
<br />I Q 1€ 0! 1 I 1I €WIREWAY
<br />II
<br />! I UE `t1 ¢I <1 di I f 1 ( 1 } € I ! 9 1
<br />€ I I I I I !❑ f ! I ! ! f € ! I # ! I f 1 I 10,_I! I ! ! I I I I I I ! € ! ! ! 1 !
<br />I I 11 ! I f C 1 i✓ i CL f I I €
<br />tlQdiltl llQ�lillll��Q i! 0I i ! I I 1 r I fY f L J I Ld I W I LSI I
<br />i k f 11 I ii i CLI ilF€ t 1 t I I f f ! !! t E € I I! 11 l i I I t
<br />❑ 1 i € I € I f l l I r l I I I i I I I I I�� �I �I �I �I I � � � i f i 1 f j f I 1 i€€ I r l l I! I f I I I b
<br />¢1 QI <I Q1 I I E I ! t I I [ i E I I I€ f l€ I l t! I! 1 1 1 1 1
<br />¢I
<br />} I I I I I ❑ I € I I ! € ! ! € ( f t f I I 1 �i 1 I ! f 1 f I I € I €
<br />I! I; f 1 1 j f € j Z1 (Xj zj Z! Zi Z1 Z1 i I
<br />i I I t € I I I €
<br />I € 1 I t I I I I I I I f 1 E ! €! I I i I 1 r
<br />�I € I € l ¢ E I ! I I ! ; ; 1 i
<br />i 0 yi �I
<br />I t [ t 1I 7T
<br />€ �! I �]. G1. C]
<br />! I I € I I ❑ I j j [ ! I i I j j I 4 t € I
<br />DUE,
<br />zl I ! I I I I ! I I € ! I ! R f �! L I z} z z�,
<br />€fllullll�W���i1�����t� iai W LSI
<br />F-1 L! F t!(! ! ! I ! f 1 1
<br />1- E I- iI1 I
<br />Ci.3 I ¢! ¢! ¢€ ¢€ Q I I I I I ! I t I J ! I k I E ! I I I N LCIS R F.
<br />I I I 1 !€ 1 1 I r I
<br />------------------------------------------------
<br />- `- ! I t w ! r
<br />€ I I ! `Y -----
<br />I € I I I 1 t I I 1 € I I 1 I { € I t 1\L---.�......_.................................,._...,....-...._..._...._..�.._-....._.._____..............-.._.......-�, ! 1 1 ! i r i I f i[�._--------_--�_____..._}..-...I__-!--�---l---I--t-'
<br />I------------------
<br />j
<br />i ------------------ 1 iy ! E I I I--------i-
<br />I i € I I I t I ....I _-i---j-------- --L- -1- €- -I-- ' I € 1
<br />_I C-- -------'-- I I ' 1- '
<br />---_........_._.--- W f IJ ---.----____ ! �------ i_t I * l--------------- I ----------
<br />-------------a __I_,_ 1 i
<br />_I____________ f F-�i 11�-------- ------_-____ C t i I t 1 I I 1 --------- -
<br />t------------f-----------------f--t �------ 1---------- `1 �1-----�1 ! i 3 i f I` �` __�------ — --r -� j- fi_�-j'^
<br />_......._....,.,........_...t..-._._...._.._ ------------ L........_...._....�..._..__.._ ! ! I I ,r �� � JJ f 1 i ! �` � .---_--k--------T_-€--i -t- �--1--1--I---- �-i-� p � � ...._..._....}._- �w4-
<br />I I I I I I I ! 1------------ i 1 ---- € \ I I i I r ��...... - i__......._............__ � I� _ I ! I �---------- I_ I i I_ 1 1 i�-1 i ------t--
<br />I I I I I I I------7 - - - - f I 1 1 1 I i t-------- t-____-__-__ a_ J_-1 _ I-_-_ I i- i 1 I€ f f f €
<br />1 1 -------------� -I- �---------_-_---.......-._....._._---�-------------__! _.............,..-- � ;- €- --
<br />-
<br />- i
<br />! 1 I I I 1 �� I -1--i- t ----------------_--_---....... -------------------___i
<br />€ � _-...._..--_ I ! I r I I I I I I I ,'-_�....-__._-_---- 1__--------- r --------
<br />I -.___ � t 11-- � r--_-- - -I 1- E I I-- -C 1-f --�T----------t fi---__- __-�_� I I f 1 I f 1
<br />I4 t 1 - _ __ _-_ _!-_------_-_-_-I---_-.-- _- _v I �-h ai---_----___
<br />! € I E \ -t i 7 -{ I r_-__ f __ I
<br />I I ---------------------------!-----ka------------!------------- t-- kt-----!-I----f----------- 1 ------- I -r- t----------_...- ! f I I € 1 I I
<br />- -
<br />t 1_I....._..-.__.-_..-_�J_-_.___....._.._- �\ j � I r I ! � l , -f f ---------- ;J-- ------- �-L-1_�I- �_____ _- - ------------- --._.........._.....w....-- t �_-1__�-I--�-t- r--j-r-r I -t r-------� I €
<br />II ! ,------------------------------------__----�J-----------t1------------_+----14-------!
<br />L_
<br />- -1 ------- --- -r____-_- -
<br />---------_- I l t ! I - f i"_...-------__--------------- 1 -----------C----__.-_--_Lr-------------------
<br />--------- I-�---- ____ 4fi----- ------ r------------+— - ------_---___.-- —_--------
<br />------f --------
<br />I
<br />. ��__.._..._......_ E.._€j..... _ I I_1 i € I- r r f I----_---______-1.�_................_._..._.._.........{_j._€_ }#-�-_--------------------.............___------------- L !_-1- ._ ._...._.............._._.��
<br />_______. _ I __ ___ �_I I�___--._-___ ! I _- ____- -____ J � I �- I --!--J -T I � I i y _ i -I i I I � _
<br />1 f f 1 f t __I _________ f -1 I l l �J -----! ; l_ _ 1_; __________ ___ _
<br />i -1 -_______r- 1 -1 ---------- T -1-i _-i-yt--_- -� rr I�1-----------r L _...-. �.------L___ -1--- _- --- --- w_. -------..-. - ----------------I4-
<br />-r - --1--1-----3-F-}----- I-I-�T r t - ._------------------_.............._........_....I _.__.-
<br />ENTRANCE i E I I r l i_� !-_ L� __ _i l �_� L -..- --- . €!----- _____ I I I E
<br />----------- r..-----._._.._...._...._.I�--�-1-�g---------------_.-_-.....-------------------
<br />—��.-
<br />ELECTRICAL PANELS i i I! ! 4 f i i l I i i ( f t I I i i! ,-1 -------------I_ w_—_------------------------------------------
<br />/---Ifr------- �' i f€
<br />AND COMMUNICATIONS i i 1 1 I I------- t € I I I I I I! I t! 1 1 1 1 1---- f € i --------------------------------------------L-----------' ! } s I 1 I 1 AIR—WATER
<br />f I t Ij-I---a-1---------+--� 1-�--�J l_ --I- -�LL� t T -_--� --d t----- -- €---;- -C---------......-......_...__----------------------_._....!_..,,.--.-----_--1 ') I I f I DISPENSER
<br />f< f ---_..-_w_ i--� i Yr i i i � —r r i d �--H I---�__r—.�—_ �I-------- -I_� t_y-----------------------�—_--____------------F---------------_--' / I i i W HEATER
<br />€ i C IJTOMER--_I h__.._.......-- l ....- ..- - i� f--------------------------.......,.�,.'-----------------f---------------__ j /
<br />€! SERVICE i i i i t 1 1 r l f f I I I I € 1 1; € ,f-�rt i. E 1--------�--- ��-------- ---------------i*----- —' %
<br />--_....... __.-.--------
<br />------------ -..-........_._.._-------------------_--.....L.............--........ __-_�--------
<br />134 -Y--- .-------------- --_-._-.....-..-
<br />i
<br />29 29 29
<br />o
<br />\
<br />0
<br />}
<br />29
<br />}1FOnD4LESJ FILL URB FILL 7URBF.S.0.t STORE COMPARTMENT 1 -.WL-/)COMPARTMENT 2
<br />(E.D.P. ROa; AND PHONE E.D.P. REGULAR UNL. ,EjLY_UM 21--
<br />ROOM
<br />ROOM -____--
<br />B
<br />LOCATIONS SHOWN
<br />SCHEMATICALLY. CONTRACTOR 61 86 61 86 61 86 61 86
<br />TO DETERMIN" ACTUAL 61 86
<br />LOCATONS.) PHONE
<br />ROOM 37 ! 37
<br />l
<br />41
<br />1 41
<br />_-___.------ ---------------
<br />`------_--_�.._-- -----------------SUMP-TYP.-- (2) -- ------------1 LEVEL TYP. OF (2)
<br />(1) 3/4" C
<br />UNUERGROUND CONDUIT RLN SCHEMATIC FROM CONTROLLER ENCLOSURE (1) 1" C (2) BELDON #8760
<br />_ (3) BELDON #8760 (1) #12 GND
<br />NTC (1) #12 GND
<br />GENERAL NOTES:
<br />A: SEE MATERIALS LIST (M-1) FOR SPECIFICATIONS ON
<br />EQUIPMENT U`€=D IN THIS CONSTRUCTION.
<br />B: ROUTINGS SHOWN ARE SCHEMATIC, FINAL LOCATIONS
<br />SHALL BE SHOWN ON AS -BUILT DRAWINGS -
<br />ALL EQUIPMEN-1 SHALL BE INSTALLED AS PER
<br />MANUFACTURER'S SPECIFICATIONS.
<br />D: FUNCTIONS O� THE CONTINUOUS MONITORING:
<br />- MONITORINC, OF ALL ANNULAR SPACES.
<br />- MONITORING OF ALL PRODUCT PIPING SUMPS.
<br />--- PROVIDE CONTINUOUS TANK LEVEL MONITORING.
<br />- DISPENSER SUMP MONITORING.
<br />E- ALL WIRES IENTERING CONTROL PANELS, MAIN PANELS,
<br />AND SUB PANELS SHALL BE MARKED WITH PHASE
<br />TAPE CODING AS FOLLOWS:
<br />"A" PHASE = BLACK
<br />"B" PHASE = RED
<br />"C" PHASE = BLUE
<br />F. THE CONTINUOUS MONITORING DEVICE SHALL PROVIDE
<br />POSITIVE SHUTDOWN OF TURBINES AND DISPENSERS
<br />IN THE EVENT OF A LIQUID RELEASE AND MANUALLY
<br />THROUGH THE ESO SWITCH LOCATED ON THE
<br />CONTROLLER EINCLOSURE AND REMOTE ESO SWITCH
<br />AS INDICATED ON SITE PLAN.
<br />G. ALL. CONDUCTORS SHALL BE STRANDED COPPER WITH
<br />75°C THWN INSULATION.
<br />H. AN EXPLOSION PROOF SEAL OFF (EPS) MUST BE
<br />INSTALLED UP_)N ENTERING AND LEAVING AN
<br />EXPLOSION PF`)OF JUNCTION BOX.
<br />NOTE
<br />A) ALL CONDUIT` SHALL HAVE INSULATED GROUNDING
<br />BUSHINGS INSTALLED AND TIED TOGETHER W/#4
<br />BARE COPPER WIRr
<br />B) AN EXPLOSIO'' PROOF SEAL MUST BE INSTALLED
<br />UPON ENTERING AND LEAVING AN EXPLOSION PROOF
<br />JUNCTION BOX
<br />C) STUB UP F" A1:3OVE GRADE AND CAP
<br />MATERIALS
<br />28 VEEDER-ROOT INTERSTITIAL FIBERGLASS TANK
<br />REQUIRED
<br />ONLY
<br />IN
<br />4
<br />ISLAND
<br />OR
<br />3
<br />ISLAND
<br />EXPANDABLE
<br />TO
<br />4
<br />ISLAND
<br />CONFIGURATIONS.
<br />(TURBINE)
<br />REQUIRED
<br />ONLY
<br />IN
<br />5
<br />ISLAND
<br />OR
<br />4
<br />ISLAND
<br />EXPANDABLE
<br />TO
<br />5
<br />ISLAND
<br />CONFIGURATIONS.
<br />LIQUID SUMP SENSOR (DISPENSER)
<br />REQUIRED
<br />ONLY
<br />IN
<br />6
<br />ISLAND
<br />OR
<br />5
<br />ISLAND
<br />EXPANDABLE
<br />TO
<br />6
<br />ISLAND
<br />CONFIGURATIONS.
<br />.� r
<br />i
<br />2 106
<br />3
<br />LEFT- WALL
<br />f03
<br />CANOPY LIGHTS
<br />ON /OFF
<br />STP CONTROL
<br />ON/OFF
<br />REAR WALL
<br />CANOPY FASCIA
<br />LIGHTS ON/OFF
<br />) I
<br />c�
<br />97 �
<br />z
<br />CJ
<br />PETRO I�
<br />POWER
<br />CENTER o I
<br />(CONDUIT LOCATION UNDER
<br />VR -TLS 390 R
<br />93 !
<br />RUN CONDUIT TO HIGH
<br />OR RIGHT
<br />EXTERIOR ENCLOSURE EVOLTAGE
<br />WALL AS INDICATED
<br />ON E-1 1 !
<br />i I
<br />1 106 t 108
<br />102 96
<br />r i}
<br />94 95
<br />I II I! !
<br />RIGHT WALL
<br />ALIGN HV/LV PARTITION IN
<br />LV WIREWAY WITH HV/LV
<br />DIVISION ON VEEDER
<br />ROOT MODULE
<br />INTERCOM
<br />LOW
<br />VOLTAGE 109
<br />€
<br />6” x 6" f
<br />WIREWAY
<br />7f
<br />PHONE BOARD „ PETRO POWER CENTER U 33 HvI I I i r
<br />CONTRACTOR DISCRETION)
<br />I I CJ LV VR HV LV
<br />2 4 6 ` 8 QD2", Q4 D6 C1 C3 C521 rIT2 I4 I6 46 48 49 52
<br />��1 5 7 D13�D520 �G2�C4�C6 107 3 22 6 i 33� 20 32 31 3a 36 37 38 Q39t40 41 1€ 2
<br />i I ! 1 I I 1 �I I 1 I € I i i €I 11131151301471 501 51t 3
<br />! j j l l l 'I❑ t f l l � r l i i i l i I I f l
<br />! I € I
<br />€i III €lI l!I rf lI! ;'❑ €I II �€I �!I�! 11€ r1 i �II » 1iI l1 i1 iI iI iI i1 21 24 L4 29 30 32Cx 6l❑
<br />UPS-3KVA 2!8
<br />I Q 1€ 0! 1 I 1I €WIREWAY
<br />II
<br />! I UE `t1 ¢I <1 di I f 1 ( 1 } € I ! 9 1
<br />€ I I I I I !❑ f ! I ! ! f € ! I # ! I f 1 I 10,_I! I ! ! I I I I I I ! € ! ! ! 1 !
<br />I I 11 ! I f C 1 i✓ i CL f I I €
<br />tlQdiltl llQ�lillll��Q i! 0I i ! I I 1 r I fY f L J I Ld I W I LSI I
<br />i k f 11 I ii i CLI ilF€ t 1 t I I f f ! !! t E € I I! 11 l i I I t
<br />❑ 1 i € I € I f l l I r l I I I i I I I I I�� �I �I �I �I I � � � i f i 1 f j f I 1 i€€ I r l l I! I f I I I b
<br />¢1 QI <I Q1 I I E I ! t I I [ i E I I I€ f l€ I l t! I! 1 1 1 1 1
<br />¢I
<br />} I I I I I ❑ I € I I ! € ! ! € ( f t f I I 1 �i 1 I ! f 1 f I I € I €
<br />I! I; f 1 1 j f € j Z1 (Xj zj Z! Zi Z1 Z1 i I
<br />i I I t € I I I €
<br />I € 1 I t I I I I I I I f 1 E ! €! I I i I 1 r
<br />�I € I € l ¢ E I ! I I ! ; ; 1 i
<br />i 0 yi �I
<br />I t [ t 1I 7T
<br />€ �! I �]. G1. C]
<br />! I I € I I ❑ I j j [ ! I i I j j I 4 t € I
<br />DUE,
<br />zl I ! I I I I ! I I € ! I ! R f �! L I z} z z�,
<br />€fllullll�W���i1�����t� iai W LSI
<br />F-1 L! F t!(! ! ! I ! f 1 1
<br />1- E I- iI1 I
<br />Ci.3 I ¢! ¢! ¢€ ¢€ Q I I I I I ! I t I J ! I k I E ! I I I N LCIS R F.
<br />I I I 1 !€ 1 1 I r I
<br />------------------------------------------------
<br />- `- ! I t w ! r
<br />€ I I ! `Y -----
<br />I € I I I 1 t I I 1 € I I 1 I { € I t 1\L---.�......_.................................,._...,....-...._..._...._..�.._-....._.._____..............-.._.......-�, ! 1 1 ! i r i I f i[�._--------_--�_____..._}..-...I__-!--�---l---I--t-'
<br />I------------------
<br />j
<br />i ------------------ 1 iy ! E I I I--------i-
<br />I i € I I I t I ....I _-i---j-------- --L- -1- €- -I-- ' I € 1
<br />_I C-- -------'-- I I ' 1- '
<br />---_........_._.--- W f IJ ---.----____ ! �------ i_t I * l--------------- I ----------
<br />-------------a __I_,_ 1 i
<br />_I____________ f F-�i 11�-------- ------_-____ C t i I t 1 I I 1 --------- -
<br />t------------f-----------------f--t �------ 1---------- `1 �1-----�1 ! i 3 i f I` �` __�------ — --r -� j- fi_�-j'^
<br />_......._....,.,........_...t..-._._...._.._ ------------ L........_...._....�..._..__.._ ! ! I I ,r �� � JJ f 1 i ! �` � .---_--k--------T_-€--i -t- �--1--1--I---- �-i-� p � � ...._..._....}._- �w4-
<br />I I I I I I I ! 1------------ i 1 ---- € \ I I i I r ��...... - i__......._............__ � I� _ I ! I �---------- I_ I i I_ 1 1 i�-1 i ------t--
<br />I I I I I I I------7 - - - - f I 1 1 1 I i t-------- t-____-__-__ a_ J_-1 _ I-_-_ I i- i 1 I€ f f f €
<br />1 1 -------------� -I- �---------_-_---.......-._....._._---�-------------__! _.............,..-- � ;- €- --
<br />-
<br />- i
<br />! 1 I I I 1 �� I -1--i- t ----------------_--_---....... -------------------___i
<br />€ � _-...._..--_ I ! I r I I I I I I I ,'-_�....-__._-_---- 1__--------- r --------
<br />I -.___ � t 11-- � r--_-- - -I 1- E I I-- -C 1-f --�T----------t fi---__- __-�_� I I f 1 I f 1
<br />I4 t 1 - _ __ _-_ _!-_------_-_-_-I---_-.-- _- _v I �-h ai---_----___
<br />! € I E \ -t i 7 -{ I r_-__ f __ I
<br />I I ---------------------------!-----ka------------!------------- t-- kt-----!-I----f----------- 1 ------- I -r- t----------_...- ! f I I € 1 I I
<br />- -
<br />t 1_I....._..-.__.-_..-_�J_-_.___....._.._- �\ j � I r I ! � l , -f f ---------- ;J-- ------- �-L-1_�I- �_____ _- - ------------- --._.........._.....w....-- t �_-1__�-I--�-t- r--j-r-r I -t r-------� I €
<br />II ! ,------------------------------------__----�J-----------t1------------_+----14-------!
<br />L_
<br />- -1 ------- --- -r____-_- -
<br />---------_- I l t ! I - f i"_...-------__--------------- 1 -----------C----__.-_--_Lr-------------------
<br />--------- I-�---- ____ 4fi----- ------ r------------+— - ------_---___.-- —_--------
<br />------f --------
<br />I
<br />. ��__.._..._......_ E.._€j..... _ I I_1 i € I- r r f I----_---______-1.�_................_._..._.._.........{_j._€_ }#-�-_--------------------.............___------------- L !_-1- ._ ._...._.............._._.��
<br />_______. _ I __ ___ �_I I�___--._-___ ! I _- ____- -____ J � I �- I --!--J -T I � I i y _ i -I i I I � _
<br />1 f f 1 f t __I _________ f -1 I l l �J -----! ; l_ _ 1_; __________ ___ _
<br />i -1 -_______r- 1 -1 ---------- T -1-i _-i-yt--_- -� rr I�1-----------r L _...-. �.------L___ -1--- _- --- --- w_. -------..-. - ----------------I4-
<br />-r - --1--1-----3-F-}----- I-I-�T r t - ._------------------_.............._........_....I _.__.-
<br />ENTRANCE i E I I r l i_� !-_ L� __ _i l �_� L -..- --- . €!----- _____ I I I E
<br />----------- r..-----._._.._...._...._.I�--�-1-�g---------------_.-_-.....-------------------
<br />—��.-
<br />ELECTRICAL PANELS i i I! ! 4 f i i l I i i ( f t I I i i! ,-1 -------------I_ w_—_------------------------------------------
<br />/---Ifr------- �' i f€
<br />AND COMMUNICATIONS i i 1 1 I I------- t € I I I I I I! I t! 1 1 1 1 1---- f € i --------------------------------------------L-----------' ! } s I 1 I 1 AIR—WATER
<br />f I t Ij-I---a-1---------+--� 1-�--�J l_ --I- -�LL� t T -_--� --d t----- -- €---;- -C---------......-......_...__----------------------_._....!_..,,.--.-----_--1 ') I I f I DISPENSER
<br />f< f ---_..-_w_ i--� i Yr i i i � —r r i d �--H I---�__r—.�—_ �I-------- -I_� t_y-----------------------�—_--____------------F---------------_--' / I i i W HEATER
<br />€ i C IJTOMER--_I h__.._.......-- l ....- ..- - i� f--------------------------.......,.�,.'-----------------f---------------__ j /
<br />€! SERVICE i i i i t 1 1 r l f f I I I I € 1 1; € ,f-�rt i. E 1--------�--- ��-------- ---------------i*----- —' %
<br />--_....... __.-.--------
<br />------------ -..-........_._.._-------------------_--.....L.............--........ __-_�--------
<br />134 -Y--- .-------------- --_-._-.....-..-
<br />i
<br />29 29 29
<br />o
<br />\
<br />0
<br />}
<br />29
<br />}1FOnD4LESJ FILL URB FILL 7URBF.S.0.t STORE COMPARTMENT 1 -.WL-/)COMPARTMENT 2
<br />(E.D.P. ROa; AND PHONE E.D.P. REGULAR UNL. ,EjLY_UM 21--
<br />ROOM
<br />ROOM -____--
<br />B
<br />LOCATIONS SHOWN
<br />SCHEMATICALLY. CONTRACTOR 61 86 61 86 61 86 61 86
<br />TO DETERMIN" ACTUAL 61 86
<br />LOCATONS.) PHONE
<br />ROOM 37 ! 37
<br />l
<br />41
<br />1 41
<br />_-___.------ ---------------
<br />`------_--_�.._-- -----------------SUMP-TYP.-- (2) -- ------------1 LEVEL TYP. OF (2)
<br />(1) 3/4" C
<br />UNUERGROUND CONDUIT RLN SCHEMATIC FROM CONTROLLER ENCLOSURE (1) 1" C (2) BELDON #8760
<br />_ (3) BELDON #8760 (1) #12 GND
<br />NTC (1) #12 GND
<br />GENERAL NOTES:
<br />A: SEE MATERIALS LIST (M-1) FOR SPECIFICATIONS ON
<br />EQUIPMENT U`€=D IN THIS CONSTRUCTION.
<br />B: ROUTINGS SHOWN ARE SCHEMATIC, FINAL LOCATIONS
<br />SHALL BE SHOWN ON AS -BUILT DRAWINGS -
<br />ALL EQUIPMEN-1 SHALL BE INSTALLED AS PER
<br />MANUFACTURER'S SPECIFICATIONS.
<br />D: FUNCTIONS O� THE CONTINUOUS MONITORING:
<br />- MONITORINC, OF ALL ANNULAR SPACES.
<br />- MONITORING OF ALL PRODUCT PIPING SUMPS.
<br />--- PROVIDE CONTINUOUS TANK LEVEL MONITORING.
<br />- DISPENSER SUMP MONITORING.
<br />E- ALL WIRES IENTERING CONTROL PANELS, MAIN PANELS,
<br />AND SUB PANELS SHALL BE MARKED WITH PHASE
<br />TAPE CODING AS FOLLOWS:
<br />"A" PHASE = BLACK
<br />"B" PHASE = RED
<br />"C" PHASE = BLUE
<br />F. THE CONTINUOUS MONITORING DEVICE SHALL PROVIDE
<br />POSITIVE SHUTDOWN OF TURBINES AND DISPENSERS
<br />IN THE EVENT OF A LIQUID RELEASE AND MANUALLY
<br />THROUGH THE ESO SWITCH LOCATED ON THE
<br />CONTROLLER EINCLOSURE AND REMOTE ESO SWITCH
<br />AS INDICATED ON SITE PLAN.
<br />G. ALL. CONDUCTORS SHALL BE STRANDED COPPER WITH
<br />75°C THWN INSULATION.
<br />H. AN EXPLOSION PROOF SEAL OFF (EPS) MUST BE
<br />INSTALLED UP_)N ENTERING AND LEAVING AN
<br />EXPLOSION PF`)OF JUNCTION BOX.
<br />NOTE
<br />A) ALL CONDUIT` SHALL HAVE INSULATED GROUNDING
<br />BUSHINGS INSTALLED AND TIED TOGETHER W/#4
<br />BARE COPPER WIRr
<br />B) AN EXPLOSIO'' PROOF SEAL MUST BE INSTALLED
<br />UPON ENTERING AND LEAVING AN EXPLOSION PROOF
<br />JUNCTION BOX
<br />C) STUB UP F" A1:3OVE GRADE AND CAP
<br />MATERIALS
<br />28 VEEDER-ROOT INTERSTITIAL FIBERGLASS TANK
<br />98 UNINTERRUPTED POWER SUPPLY
<br />99 PELCO 24" VAC POWER SUPPLY
<br />102 PHONE RINGER
<br />103 DIM CABLE ADAPTER BOX
<br />104 AUTOGAS MULTILINE DATA PROTECTOR
<br />105 RED JACKET TURBINE CONTROL BOX
<br />106 SINGLE RECEPTACLE
<br />107 DUAL RECEPTACLE
<br />1pg QUAD RECEPTACLE (DEDICATED GROUND)
<br />109 ATTENDANT INTERCOM
<br />110 TELEPHONE SURGE SUPPRESSOR
<br />134 AIR --WATER DISPENSER W/ HEATER
<br />(D DEDICATED SINGLE RECEPTACLE FOR CAMERA
<br />DEDICATED SINGLE RECEPTACLE FOR MODEM
<br />DEDICATED SINGLE RECEPTACLE FOR BROWN BOX
<br />1. BLACK #12 HOT TO AC POWER.
<br />2. GREEN #12 TO GROUND.
<br />3. WHITE #12 TO NEUTRAL -
<br />4. RED #12 TO SUBMERSIBLE #1 PUMP.
<br />5. BROWN ##12 TO SUBMERSIBLE #2 PUMP.
<br />6. BLACK #12 TO SUBMERSIBLE #3 PUMP. FOR 59OU DO NOT USE -
<br />7. NOT USED.
<br />8, NOT USED.
<br />9, NOT USED,
<br />10. NOT USED.
<br />11. GREY ##14 CAT, CARD READER DATA,
<br />12. BROWN ##14 CAT, CARD READIR DATA.
<br />13. GREY ##14 DATA PUMP CONTROL.
<br />14. BROWN ##14 DATA PUMP CONTROL.
<br />* FOR UNITS 59OU AND 39OU INSTALL PER
<br />MANUFACTURER'S RECOMMENDATION.
<br />VEEDER-ROOT WIRE REFERENCE NOTES
<br />93 VEEDER-ROOT CONTROL PANEL: AC HOT = BLACK ##12
<br />NEUTRAL = WHITE #12
<br />(2) GROUND = GREEN ##12
<br />-----
<br />SENSOR
<br />HV
<br />A
<br />VEEDER-ROOT
<br />DISCRIMINATING LIQUID
<br />29
<br />SUMP SENSOR
<br />(FILL)
<br />B
<br />VEEDER-ROOT
<br />DISCRIMINATING LIQUID
<br />29
<br />SUMP SENSOR
<br />(TURBINE)
<br />37
<br />VEEDER-ROOT
<br />SERIES MAG 1 TANK PROBE
<br />41
<br />RED JACKET 1-1/2
<br />HP SUBMERSIBLE PUMP
<br />61
<br />WAYNE VISTA
<br />SERIES DISPENSER
<br />REVISIONS -_
<br />VEEDER-ROOT-
<br />VR794380-208 NON -DISCRIMINATING
<br />86
<br />LIQUID SUMP SENSOR (DISPENSER)
<br />90
<br />AUTOGAS SITE
<br />MATER CONTROL UNIT MODEL 510
<br />91
<br />AUTOGAS PRINTER
<br />92
<br />WAYNE DATA DISTRIBUTION BOX
<br />93
<br />VEEDER-ROOT
<br />CONTROL PANEL -TLS 350 R
<br />g4
<br />EMERGENCY SHUT OFF SWITCH
<br />95
<br />VEEDER-ROOT
<br />OVERFILL ALARM
<br />WITH HORN/STROBE 120VAC
<br />9G
<br />VEEDER.-ROOT
<br />ACKNOWLEDGMENT SWITCH
<br />97
<br />PETRO POWER
<br />CENTER
<br />98 UNINTERRUPTED POWER SUPPLY
<br />99 PELCO 24" VAC POWER SUPPLY
<br />102 PHONE RINGER
<br />103 DIM CABLE ADAPTER BOX
<br />104 AUTOGAS MULTILINE DATA PROTECTOR
<br />105 RED JACKET TURBINE CONTROL BOX
<br />106 SINGLE RECEPTACLE
<br />107 DUAL RECEPTACLE
<br />1pg QUAD RECEPTACLE (DEDICATED GROUND)
<br />109 ATTENDANT INTERCOM
<br />110 TELEPHONE SURGE SUPPRESSOR
<br />134 AIR --WATER DISPENSER W/ HEATER
<br />(D DEDICATED SINGLE RECEPTACLE FOR CAMERA
<br />DEDICATED SINGLE RECEPTACLE FOR MODEM
<br />DEDICATED SINGLE RECEPTACLE FOR BROWN BOX
<br />1. BLACK #12 HOT TO AC POWER.
<br />2. GREEN #12 TO GROUND.
<br />3. WHITE #12 TO NEUTRAL -
<br />4. RED #12 TO SUBMERSIBLE #1 PUMP.
<br />5. BROWN ##12 TO SUBMERSIBLE #2 PUMP.
<br />6. BLACK #12 TO SUBMERSIBLE #3 PUMP. FOR 59OU DO NOT USE -
<br />7. NOT USED.
<br />8, NOT USED.
<br />9, NOT USED,
<br />10. NOT USED.
<br />11. GREY ##14 CAT, CARD READER DATA,
<br />12. BROWN ##14 CAT, CARD READIR DATA.
<br />13. GREY ##14 DATA PUMP CONTROL.
<br />14. BROWN ##14 DATA PUMP CONTROL.
<br />* FOR UNITS 59OU AND 39OU INSTALL PER
<br />MANUFACTURER'S RECOMMENDATION.
<br />VEEDER-ROOT WIRE REFERENCE NOTES
<br />93 VEEDER-ROOT CONTROL PANEL: AC HOT = BLACK ##12
<br />NEUTRAL = WHITE #12
<br />(2) GROUND = GREEN ##12
<br />-----
<br />EXPLOSION PROOF SEAL
<br />HV
<br />HIGH VOLTAGE
<br />LV
<br />LOW VOLTAGE
<br />VR
<br />VEEDER -- ROOT
<br />E.S.O.
<br />EMERGENCY SHUT-OFF
<br />E.D.P.
<br />ELECTRICAL DISTRIBUTION PANEL
<br />C
<br />CONDUIT
<br />F.F.
<br />FINISHED FLOOR
<br />LSI Adapt Inc.
<br />24651 CENTER RIDGE ROAD, SUfTE 190
<br />WESTLAKE, OH 44145--56.27
<br />TEL: 410-871-1603 FAX: 440--87f-1739
<br />P POJ C T -NUMBER
<br />AS—NOTED
<br />02-26-01
<br />E7A7E W1�37�:L?
<br />02---26-01
<br />:>I3M
<br />,,� cf��elcr=la
<br />WDH
<br />RrMSIGIIS
<br />ELECTRICAL SCHEMATIC: FOR C�
<br />KIOSK OR CONTROL RRL DOOM (SINGLE TAMC) -
<br />5
<br />zh
<br />NO.
<br />REVISIONS -_
<br />DAfE _
<br />DWN
<br />CKD .
<br />LSI Adapt Inc.
<br />24651 CENTER RIDGE ROAD, SUfTE 190
<br />WESTLAKE, OH 44145--56.27
<br />TEL: 410-871-1603 FAX: 440--87f-1739
<br />P POJ C T -NUMBER
<br />AS—NOTED
<br />02-26-01
<br />E7A7E W1�37�:L?
<br />02---26-01
<br />:>I3M
<br />,,� cf��elcr=la
<br />WDH
<br />RrMSIGIIS
<br />ELECTRICAL SCHEMATIC: FOR C�
<br />KIOSK OR CONTROL RRL DOOM (SINGLE TAMC) -
<br />
|