Laserfiche WebLink
For operation in northern climates, we heat trace and Insulate the <br /> of as it is the only place in the system that could <br /> knock our p r build <br /> build up any amount of water. Then, considering that water <br /> is a possibility,u bilitwe install an automatic system shut down <br /> p t et to an excessive level. If <br /> should this water or free produc- g vel, it <br /> the sys tla eshuts itself down because of the liquid l� <br /> ovex=ides all other control :unctions and must be satisfied before <br /> the system can be restarted. <br /> OPERATION: <br /> Oaeration and control of a Y`.+PO� CE=CR system is the s�«�1est yet <br /> safes-t. system on the market. <br /> } T~,x_--n ma=n power on via a lever located an the front of the <br /> cant_of panel. <br /> 2} Turn an/off selector s;r_tyZ to the "on" position and the <br /> actuator bypass/run swyt_h to the ='bypass" pos_' tlon. <br /> The Gcombustionburger co.;,es an a}_ It' s highest air flow <br /> startIng a timed air pu=ce of <br /> the combustion chamber that <br /> allows for at leas f Gur (4) air oranges of the chamber <br /> m�, ,s cycle groes out, the ccr,.bus tion <br /> before proceed-, ng. y••_ ii <br /> blower automatica'_ly goes to low a,r `law, and a second <br /> aJ.r purge cycle starts . The -Urge cycles COMP -ed , the <br /> plot light will 1:.ght. If the flame+safety sys:.em proves we <br /> have ignition, the main Gas solenoid will "};ick" 2.4- . I_ on <br /> t <br /> he ot'zer hand, =cr:_t�cns not prove-s no flame ex_sts and the <br /> Svs tem will shl:t _t.self down for f'_a.'M f a, lure. <br /> J <br /> Next: Assuming rxlat 1-7ht is <br /> lit <br /> ,�- .�. _ �� ..1z_n Sas valve, sw�tch the <br /> 3 Manual 1y set ne L�..k ,.e .. <br /> bypass/run 5:,_, tt:I to the position <br /> r The main bu_Tner is now ignited at low fire and w=11 <br /> continue to increase flame intensity until az high fare or <br /> until the desired set pont is reached. Once the <br /> combustion chamber is at 1400° F, the burner will <br /> continue to modL_ate to maintain tZe set pont of the <br /> controller. <br /> NCTZ,. _ �+ the entire sys tem will <br /> � L.3�J Serr.I�..I G..iM� �S not followed, r. <br /> either shut itself down or refuse to proceed any further. <br /> w�;G, cat�ng li cnts are =rov=ded on the panel to keep the <br /> operator informed. <br />