ARCHIVED REPORTS UIC PERMIT APP - Laserfiche WebLink

Home Browse Search

Conditions for N-2697-1-3 (continued) Page 2 of 6 6. The catalyst bed and other components of the SCR system shall be made available for visual inspection by the District at least once a year. The District shall be notified at least 30 days prior to scheduling such inspection. [District NSR Rule] Federally Enforceable Through Title V Permit 7. The turbine shall be equipped with a CO catalyst to reduce CO and NMHC emissions. [District NSR Rule]Federally Enforceable Through Title V Permit 8. The turbine shall be equipped with an automatic air/fuel ratio control system. [District NSR Rule] Federally Enforceable Through Title V Permit 9. The permittee shall provide a continuous temperature monitoring and recording system to indicate the flue gas temperature through the SCR system. [District NSR Rule] Federally Enforceable Through Title V Permit 10. The stack height shall be minimum of 50 feet,and shall be adequate for stack sampling pursuant to EPA reference methods for source testing. [District NSR Rule] Federally Enforceable Through Title V Permit 11. Results of continuous emissions monitoring must be reduced according to the procedure established in 40 CFR,Part 51,Appendix P,paragraphs 5.0 through 5.3.3, or by other methods deemed equivalent by mutual agreement with the District,the ARB, and the EPA. [District Rule 1080, 7.2] Federally Enforceable Through Title V Permit 12. The NOx CEMS shall complete a minimum of one cycle of operation(sampling, analyzing, and data recording) for each successive 15-minute period or shall meet equivalent specifications established by mutual agreement of the District,the ARB and the EPA. [District Rule 1080,6.4 and 40 CFR 60.334(b)(2)] Federally Enforceable Through Title V Permit 13. The continuous NOx and 02 monitoring system shall meet the performance specification requirements in 40 CFR 60, Appendix F, and Part 60,Appendix B, or shall meet equivalent specifications established by mutual agreement of the District,the ARB, and the EPA. [District Rule 1080, 6.71 Federally Enforceable Through Title V Permit 14. A violation of NOx emission standards indicated by the NOx CEM shall be reported by the operator to the APCO within 96 hours. [District Rule 1080, 9.0] Federally Enforceable Through Title V Permit 15. Operator shall notify the APCO no later than eight hours after the detection of a breakdown of the CEM. Operator shall inform the APCO of the intent to shut down the CEM at least 24 hours prior to the event. [District Rule 1080, 10.0]Federally Enforceable Through Title V Permit 16. Operations during periods of startup or shutdown shall not constitute representative conditions for the purpose of a NOx performance test nor shall NOx emissions in excess of the level of the emission limit shown in this permit during periods of startup and shutdown be considered a violation of the applicable emission limit unless otherwise specified in the applicable standard. [40 CFR 60.8(c)] Federally Enforceable Through Title V Permit 17. The owner or operator shall maintain records that contain the following: the occurrence and duration of any start-up, shutdown or malfunction,performance testing, evaluations, calibrations, checks, adjustments, any periods during which a continuous monitoring system or monitoring device is inoperative,maintenance of any CEM system that has been installed pursuant to District Rule 1080(as amended 12/17/92),and emission measurements. [40 CFR 60.7(b) and District Rule 1080,7.0] Federally Enforceable Through Title V Permit 18. The owner or operator shall, upon written notice from the APCO,provide a summary of the data obtained from the CEM systems. This summary of data shall be in the form and the manner prescribed by the APCO. [District Rule 1080, 7.1] Federally Enforceable Through Title V Permit 19. Results of the CEM system shall be averaged over a three hour period,using consecutive 15-minute sampling periods in accordance with all applicable requirements of CFR 60.13(h). [40 CFR 60.13(h), and District Rule 4703, 5.1, 6.4] Federally Enforceable Through Title V Permit 20. Operator shall maintain a stationary gas turbine operating log that includes, on a daily basis the actual local start-up and stop time, length and reason for reduced load periods, total hours of operation and quantity of fuel used. [District Rule 2520, 9.4.2] Federally Enforceable Through Title V Permit CONDITIONS CONTINUE ON NEXT PAGE N-2697.1-3:Mar 212007 6:01AM—SCHONHOM