Laserfiche WebLink
11 <br />of Conterg <br />Introduction <br />SafetyPrecautions............................................................................................................1 <br />Warningsand Instructions................................................................................................2 <br />IMPORTANT SAFETY INFORMATION...................................................................2 <br />PRELIMINARY PRECAUTIONS..............................................................................2 <br />REQUIREMENTS FOR USE....................................................................................3 <br />OPERATING PRECAUTIONS.................................................................................3 <br />FuelCompatibilities..........................................................................................................3 <br />Installation <br />INSTALLATION SAFETY NOTICES ATTENTION INSTALLER......................................4 <br />Follow These Directions Carefu€ly......................:.............................................................5 <br />Installing The Pumping Unit..............................................................................................5 <br />Attaching the Expansion Relief Vent Line.........................................................................6 <br />Wiringthe Conduit Box.....................................................................................................7 <br />Wiring Instructions- 208-230 Volt. Singe Phase Pumps...........................................8 <br />Wiring Instructions - 208-230, 400 or 575 Volt Three -Phase Pumps .......................8 <br />Starting the System and Completing the Installation......................................................16 <br />Floating Suction Installation Information.........................................................................18 <br />Installing A Big Flo Diaphragm Valve..............................................................................19 <br />Attaching the Siphon and Vacuum Lines with Factory Installed Siphon Assemblies ......20 <br />Installing Two Pumps for Tandem Operation..................................................................21 <br />Testing the Installation <br />Testingthe Piping...........................................................................................................24 <br />Testingthe Tank.............................................................................................................25 <br />Purgingthe System......................................................................................................25 <br />Adjusting the Pressurstat Line Relief Pressure...............................................................26 <br />Service and Repair <br />Removing the Extracta Assembly...........................:.......................................................27 <br />Procedure for Removal of. Plug-in Type Pump - Motor Assembly..................................28 <br />Installing the Extracta Assembly (Ref. Figure 21)...........................................................29 <br />Replacing the Check Valve Assembly............................................................................31 <br />Repairing the Check Valve Lock -down Screw and Seals...............................................32 <br />Parts <br />6" Maxxum Big Flo - Repair Parts Packer Manifold Assembly Parts - Side View ...........35 <br />6" Maxxum Big Flo - Repair Parts Packer Manifold Assembly Parts - Top View ............36 <br />6" Maxxum Big Flo - Repair Parts Yoke Assembly.........................................................37 <br />UL Listed Motor Control Box for 2HP Pumps Model P200H1-CB..................................38 <br />Red Jacket Replacement Pump Motors.........................................................................39 <br />Magnetic Contactor for 2, 3, & 5 HP 3 Phase Pumps ...................... .............................39 <br />Appen8ix A: 6" Maxxum STP ATEX Safety Instructions for European Installations <br />Appendix B: Declaration of Conformity <br />Appendix C: FDNY Certificate of Approval <br />Appendix D. ANZEx Conditions Of Certification <br />