SR0082410 - Laserfiche WebLink

Home Browse Search

INTRODUCTION Installation Manual in order to safely and properly install our under- ground storage tank and accessories. • Failure to follow these instructions will void our obligations under I.Before beginning the tank installation,read through the entire the limited warranty,could result in death,serious personal injury, Installation Manual and Operating Guidelines(subsequently property damage and/or tank failure. referred to as the Installation Manual)and any applicable . The presence of our representative does not relieve the installer supplemental materials.It is the responsibility of the owner, installer and operatorto understand and follow all requirements of having sole responsibility for proper tank installation. contained in the Installation Manual. 12.Our limited warranty applies only to a tank installed according to these 2.Work must be performed according to standard industry instructions.Since we do not control the parameters of any installation,our practices applicable to tank installations and operations. sole responsibility in any installation is that presented in the limited warranty. 3.Work must comply with all codes,regulations and standards 13.It is the responsibility of the owner and operator to always follow of appropriate governmental agencies,such as: the operating guidelines set forth in our applicable limited warranty. • construction,health,safety and environmental codes 14.It is the responsibility of the owner and operatorto always follow the • relevant US fire codes(for example,National Fire Protection operating guidelines set forth in section 9 of the Installation Manual. Association standards 30,30A and 31) 15.It is the responsibility of the ownerto retain the limited warranty • relevant Canadian fire codes(for example,National Fire Code and the Installation Manual provided with the tank for future reference. of Canada and provincial fire codes) Go to zcl.com for a copy of the current limited warranty. • industry standard practices(for example,PEI RP100, AN RP1615) 16.Use theTank Installation Checklist(Appendix E)for all under- 4.For additional information,contact appropriate governmental ground storage tanks throughout the installation process. agency storage-tank authorities,include fire or building departments, 17.Record the relevant information for each tank installed on the Tank and environmental agencies. Installation Checklist.Additional copies are available atzcl.com. S.The following safety designations will apply when reading 18.Tank installer must retain a copy of the completed Tank Installation the Installation Manual: Checklist and provide tank owner with a copy in order to facilitate any A WARNING Indicates a potentially hazardous situation, warranty claim. which,if not avoided,could result in death 19.Any variation to,or deviation from,the instructions in the Installation or serious injury. Manual must be approved in writing from us priorto the tank installation. A CAUTION Indicates a potentially hazardous situation, . All correspondence regarding any variances must be retained in the which,if not avoided,could result in minor event of a future warranty claim. or moderate injury. NOTICE Indicates information considered important 20.Foranyquestions regarding the interpretation of these instructions orfor but not hazard related.Failure to heed this any other technical inq ui ries,contact technical support(ena.su000rt&d.com). notice could result in property damage. 21.All contact information applicable to installation is found on the back 6.Keep the Installation Manual available at the installation cover of the Installation Manual. site to refer to safety procedures as needed. A WARNING USE OF TANK DATA CHARTS (APPENDICES A&B) Follow OSHA regulations and/or consult your local Canadian regulations concerning tank excavations, 22.Tank data charts—Appendices Al,A2,A3 and A4(Actual Capacities whichever are relevant.Collapse of excavation walls and Dimensions of Single-wall and Double-Wall Tanks)and Appendices could result in death or serious injury. B1,82,B3 and B4(Weights of Single-Wall,Double-Wall and Multicom- 7.Working in and around excavations is dangerous.Prior to beginning partmentTanks)—address the mostfrequently sold tanks.For information work at the site,the installer must follow any governmental or other on additional tank sizes,contact technical support codes and/or regulations applicable to excavations. (ena.su000rt@zcl.com). • Appendices Al and 61 apply to tanks manufactured and installed 8.Careless activity or reckless operation of equipment can cause death, in the United States(red tanks). serious injury or property damage. • Appendices A2 and B2 apply to tanks manufactured in Canada and 9.Governmental agency codes,regulations and standards always • installed in the United States(green tanks). take precedence over our requirements. Appendices A3 and B3 apply to tanks manufactured and installed in Canada(green tanks). 10.No instructions or procedures presented in the Installation Manual • Appendices A4 and B4 apply to tanks manufactured in the United should be interpreted so as to put at risk any person's health or safety,or States and installed in Canada(red tanks). to harm any property or the environment. 23.Appendices A charts are intended for use with individual 11.It is important to follow the procedures and instructions in the single-wall and double-wall,one-compartment tanks. 03