Laserfiche WebLink
1.5 DEADMAN SELECTION GUIDE <br /> SINGLE, DOUBLE, AND TRIPLE WALL FIBERGLASS TANKS <br /> DEADMAN ANCHORS DEADMEN W/GALVANIZED ANCHOR POINTS <br /> NOMINAL NOMINAL TURNBUCKLES NUMBER OF <br /> TANK TANK REQUIRED DEADMEN LENGTH <br /> DIAMETER CAPACITY (2 PER STRAP) REQUIRED (FEET) <br /> 10 40,000 20 8 18 <br /> 10 35,000 16 2 - 18 and 4 - 22 18 and 22 <br /> 10 30,000 16 6 18 <br /> 10 25,000 16 4 - 14 and 2 - 18 14 and 18 <br /> 10 20,000 12 4 18 <br /> 10 15,000 8 4 14 <br /> 10 12,000 8 2 22 <br /> 10 10,000 6 2 18 <br /> 8 15,000 12 2 - 12 and 4 - 16 12 and 16 <br /> 8 12,000 8 4 18 <br /> 8 10,000 8 4 16 <br /> 8 8,000 8 4 12 <br /> 8 6,000 4 2 18 <br /> 8 5,000 4 2 16 <br /> 8 4,000 4 2 12 <br /> 6 6,000 8 4 16 <br /> 6 5,000 8 4 12 <br /> 6 4,000 4 2 20 <br /> 6 3,000 4 2 16 <br /> 6 2,500 4 2 16 <br /> 6 2,000 4 2 12 <br /> 4 550, 600, 1,000 4 2 12 <br /> 2.0 INSTALLATION <br /> A. Deadmen with Anchor Points using Containment Solutions Turnbuckles(6',8'and 1 O'diameter tanks only) <br /> When using CSI supplied turnbuckles, proper positioning of the deadmen is necessary to insure proper <br /> performance and to avoid the need for supplemental wire rope and clamps. CSI supplied turnbuckle assemblies <br /> will not connect the strap to the anchor hook point if positioned incorrectly. <br /> • Position deadmen beside the tank so the tank designated anchor locations align with the deadmen anchor points+/-1". <br /> • Use only 1 strap per anchor point. <br /> • Deadmen must be positioned so the edges of the deadmen are aligned with the tank shadow. <br /> • Place CSI deadmen with the bottom of deadmen at the same level as the bottom of the tank or with the bottom <br /> of the deadmen 12" below the bottom of the tank. <br /> To use CSI turnbuckles with contractor supplied deadmen or anchor pads,the anchor hook point must be located <br /> in the same position as the CSI deadmen anchor hook points (see turnbuckle section). <br /> B. Offloading Deadmen Anchors <br /> LIFTING CHAIN OR SLING LIFTING CHAIN OR SLING <br /> WARNING <br /> ANCHOR POINT ANCHOR POINT <br /> Only use anchorpoints supplied by CSI when lifting 600 to sow <br /> and positioning deadmen. Insure lifting equipment is <br /> rated to handle the load before lifting. Lift deadman <br /> using a minimum of two equally spaced anhor points. <br /> 5150 Jefferson Chemical Road • Conroe, TX 77301 • Tel: 936-756-7731 • Fax : 936-756-7766 <br /> www.containmentsolutions.com <br /> Litho U.S.A. April 2003 Copyright©2003 Containment Solutions,Inc. Pub.No.ACC5002E 3 <br />