INSTALL 2018 - Laserfiche WebLink

Home Browse Search

INTRODUCTION Installation Manual in order to safely and properly install our under- ground storage tank and accessories. I.Before beg inn in g the tank insta I lati on,read through the entire • Fai I ure to follow these instructions wi I I void our obligations under Installation Manual and Operating Guidelines(subsequently the limited warranty,could result in death,serious personal injury, referred to as the Installation Manual)and any applicable property damage and/or tank failure. supplemental materials.It is the responsibility of the owner, • The presence of our representative does not relieve the installer installer and operator to understand and follow all requirements of having sole responsibility for proper tank installation. contained in the Installation Manual. 12.Our limited warranty applies only to a tank installed according to these 2.Work must be performed according to standard industry instructions.Since we do not control the parameters of any installation,our practices applicable to tank installations and operations. sole responsibility in any installation is that presented in the limited warranty. 3.Work must comply with all codes,regulations and standards 13.It is the responsibility of the owner and operator to always follow of appropriate governmental agencies,such as: the operating guidelines set forth in our applicable limited warranty. • construction,health,safety and environmental codes 14.It is the responsibility of the owner and operator to always follow the • relevant US fire codes(for example,National Fire Protection operating guidelines set forth in section 9 of the Installation Manual. Association standards 30,30A and 31) 15.It is the responsibility of the owner to retain the limited warranty • of Canadant odes and the Installation Manual provided with the tank for future reference. of Canada and provincial fire codes) • industry standard practices(for example,PEI RP100, Go to zcl.com for a copy of the current limited warranty. API RP1615) 16.Use the Tank Installation Checklist(Appendix E)for all under- 4.Foradditional information,contact appropriate governmental ground storagetanks throughoutthe installation process. agency storage-tank authorities,includefire orbuilding departments, 17.Record the relevant information foreach tankinstalled on theTank and environmental agencies. Installation Checklist.Additional copies are available at zcl.com. S.The following safety designations will applywhen reading 18.Tank installer must retain a copyofthe completedTank Installation the Installation Manual: Checklist and provide tank owner with a copy in orderto facilitate any A WARNING Indicatesa potentially hazardous situation, warranty claim. which,if notavoided,could result in death 19.AnyvaTiation to,ordeviation from,the instructions in the Instaflation or serious injury. Manual must be approved in writing from us prior to the tank installation. A CAUTION Indicates potentially hazardous situation, . All correspondence regarding anyvariances must be retained in the which,if not avoided,could result in minor event of a future warranty claim. or moderate injury. NOTICE Indicates information considered important 20.For any questions regarding the interpretation of these instructions or for butnothazardrelated.Failuretoheedthis any other technical inquiries,contacttechnicalsupport feng.supoort@zcl.com). notice could result in property damage. 21.All contact information applicable to installation is found on the back 6.Keep the Installation Manual available at the installation cover of the Installation Manual. site to refer to safety procedures as needed. A WARNING USE OF TANK DATA CHARTS (APPENDICESA&B) Follow OSHA regulations and/or consult your local Canadian regulations concerning tank excavations, 22.Ta n k d ate cha rts—Ap pe nd ices Al,A2,A3 a n d A4(Adu a I Ca pa citi as whichever a re relevant.Collapse of excavation walls and Dimensions of Single-wall and Double-Wall Tanks)and Appendices could result in death or serious injury. B1,B2,B3 and B4(Weights of Single-Wall,Double-Wall and Multicom- 7.Working in and around excavations is dangerous.Priorto beginning partmentTanks)—address the most frequently sold tanks.For information work at the site,the installer must follow any governmental or other (ng.suponaltad.cnk oms,contacttechnicalsupport codes and/or regulations applicable to excavations. (eno.suoclices l.com). • Appendices Al and B1 apply to tanks manufactured and installed S.Careless activity or reckless operation of equipment can cause death, in the United States(red tanks). serious injury or property damage. • Appendices A2 and B2 applyto tanks manufactured in Canada and installed in the United States(green tanks). 9.Governmental agency ry • Appendices A3 and B3 applyto tanks manufactured and installed in take precedence over our requirements. Canada(green tanks). 10.No instructions or procedures presented in the Installation Manual • Appendices A4 and B4 apply to tanks manufactured in the United should be interpreted so as to put at risk any person's health orsafety,or States and installed in Canada(red tanks). to harm any property or the environment. 23.Appendices A charts are intended for use with individual Il.It is importantto follow the procedures and instructions in the single-wall and double-wall,one-compartment tanks. INTRODUCTION 03