Laserfiche WebLink
P-C-1 1 1 C <br /> Ii <br /> 5.3.3 Instruction label . A suitable label with the following instructions <br /> printed thereon shall be attached to each container. <br /> For type I compounds : <br /> DIRECTIONS FOR USE <br /> 1 . This compound is to be diluted with water before use. Vigorously <br /> shake can or stir to mix contents thoroughly. Transfer compound to cleaning <br /> bath and add an equal volume of water. Stir bath for 15 minutes . <br /> i <br /> 2. Fill cleaning bath to a reference mark with fresh compound. <br /> 3. Before soaking item in compound, remove all loose grease, dirt and oil <br /> with a degreasing solvent (kerosene, Stoddard solvent, etc.) . Place objects <br /> to be cleaned in a wire basket or hang them by a wire so as to be off the <br /> bottom and completely immersed. <br /> 4. Soak for 2 to 16 hours as necessary to remove or loosen carbon. Raise <br /> items slowly, allowing for drainage. Rinse with water, kerosene or solvent. <br /> To effectively remove carbon, brush with a stiff bristle brush under running <br /> hot water. <br /> 5. Make-up liquid and drag out replacement: <br /> a. Fill tank with fresh cleaner and mark level permanently after <br /> reaching operating temperature (do not use at temperatures above 130°F.) . <br /> b. After work is completed for the day, add make-up liquid (see <br /> paragraph (e) for composition) in the amount calculated by multiplying the <br /> number of hours of operation by the factor determined in (f) . <br /> c. After adding make-up liquid, add original cleaner until liquid is <br /> j at original tank level to correct for drag out. <br /> d. Before starting operations for the day, when bath reaches operating <br /> temperature add make-up liquid if needed. ` <br /> e.. Make-up liquid consists of 3 gallons ethyleneglycol monobutyl <br /> I <br /> ether, 1-1/2 gallons diethyleneglycol diethyl ether, 3 pints monoethanolamine <br /> to every 45 gallons water. Mix thoroughly. This must be used to restore <br /> cleaner to original composition and maintain activity. <br /> I <br /> 22 <br />